Ford F-150 - 1997-2003 :: AC Compressor Clutch Engaging While Heater Is On
soo a friends 03 f-150 w/ the 4.6 has noticed the a/c compressor clutch engaging while heater is on. clutch engages for about 3 seconds or so and kicks back out consistently but only w/ the heater on. a/c dose function property when using a/c functions... Is this normal or does something need serviced???
View 3 RepliesFord A/C :: 1997 E350 Van Won't Start With Compressor Clutch Plug Unplugged
Troubleshooting the not working A/C in my 1997 Ford E350 Motorhome Chassis.
1. Compressor clutch spins freely
2. Started vehicle and turned on A/C, clutch not engaging
3. Unplugged Compressor clutch plug, and engine would turn over but not start
4. Replugged, started engine (normal), and when I unplugged the compressor clutch plug, the engine immediately cut-out.
Is this normal? I was planning to check if I had 12v at the compressor plug. Did I miss something? It is almost as if the clutch is wired into the ignition circuit...
Regal :: 1997 - Noise From Compressor Clutch
My 97 regal has a noise from the compressor clutch. It goes away when the a/c is turned on. Mechanic said its the clutch assembly. Is this easy to change? What causes the noise to go away when the a/c is turned on?
View 6 RepliesFord F-150 - 1997-2003 :: Radiator Plug Broke Off
I went to unscrew the radiator drain plug but the head broke right off leaving the rest of it inside.
I drilled out a little bit of it so I could drain the coolant and bough a replacement plug but there are still pieces stuck inside and I cant get them out.
Should I just drill out the remaining pieces or is there a better way to get them out?
Ford F-150 - 1997-2003 :: Rear End Differential Broke?
My rear-end differential came apart and is not repairable. I have a 1997 F150, 2WD, 4.6L engine, 5 lug wheels. Which years have the same rear ends so I can scour the junk yards for a replacement?
View 4 RepliesFord F-150 - 1997-2003 :: Sensor Broke In Cylinder Head?
I have a 1999 Ford E150 4.2l. My cylinder head temp sensor was dangling but still connected to the sensor... the connector was loosed from the filament but was still connected by exposed metal pins.
I figured I would replace it like i did to my ECT by the Water Pump. So I pulled the connector out and it started to leak...a little. and when I put the socket on it I instantly broke the sensor flush with the Cylinder Head.
I researched on here and found many people believe the CHT gives info to the Dashboard Gauge and the ECT is used by the ECU. I thought that was correct because I had ECT readings from my scantool...and my Dash Gauge never worked. When I found the dangling CHT I figured it was never working.
So I JB welded CHT hole. figuring i would fix it properly later. I replaced the ECT and expected everything to go back to normal.. No gauge reading on dash and a scan reading with no codes.
I want to replace the CHT sensor properly. Do I HAVE to remove the manifolds. Or do you think its safe to drain the coolant and drill it out. Its easy access. Im worried about all the tiny pieces getting into narrow passage ways.
I am almost 100% going to drill out. Manifold sounds like hell and its getting cold. What sensor controls what? Can I drill it out safely?
Ford Super Duty (1999-2016) :: 2003 V10 - AC Compressor Clutch Is Bad
2003 V10.. Can I replace the AC compressor clutch with out pulling the compressor out?
View 13 RepliesFord F-150 - 1997-2003 :: Vacuum Reservoir Lines Under Passenger Fender Broke Off
I have a 1997 4.2 and when i got it the big vacuum reservoir under the passenger fender had the lines broke off. Where these lines go or have a diagram...
View 1 RepliesFord F-150 - 1997-2003 :: Cracking Noise - Fuel Smell - Truck Broke Down?
My truck broke down on the freeway last night. I heard a cracking noise (metal breaking) and it sounded like a backfire. The engine was running fine, good RPM's. I rev it up and the noise got worse, It sounds like a bad lawn mower or go cart. I was also smelling raw fuel.
Could I have broken a exhaust flange or the manifold? It sounds like the exhaust is bad and not burning the fuel.
There were no codes or a check engine light. I only went 1/2 mile after it broke down. I had to tow it to a local shop.
It's a 2003 4.6 with 205,000 miles.
Ford 7.3L Power Stroke (1999-2003) :: Compressor Clicking On / Off About Every 5 Seconds - Clutch Smell
On 2500 mile trip, no A/C last 400 miles and we're cooking
Compressor clicking on/off about every 5 secs, clutch smell. Seems to be turning okay.
I brought some tools, including a full socket set.
Can I pull the clutch and remove shims in the campground? Looking for a condensed version of how?
Worst case, how do I replace the clutch- of I can find a dealer with one?
Pulley and clutch fixed, but cycling on and off...adding freon?
Golf IV / Jetta IV :: 2003 GLI - Air Compressor Clutch Will Not Getting Engaged
I have a 2003 2.8 GLI and my compressor clutch will not engaged i provided the clutch with a direct power and ground from the battery and it engaged. i also went to the junk yard and got a couple of Fan Control Module ($4 each) and it still does not engaged.
View 3 RepliesSanta FE SM (2001-06) :: 2003 - Noise Form Compressor Clutch
Recently I began hearing noise such as a rattle on the right front of the vehicle. It is a 2003 SF 2.7L front wheel drive with almost 180k mi. At first I thought the noise was from the Serp belt tensioner. Now I believe it originates from the compressor clutch.
Does the a/c clutch have a history with its bearings ? Is the clutch replaceable on the compressor or is this a single unit replacement ?
Golf IV / Jetta IV :: 2003 - AC Compressor Clutch Won't Engage - Low Voltage?
I got a 2003 GTI 1.8t and the AC air is blowing warm. With the car on, AC on and fans full blast both rad fans turn on but compressor clutch does not engage. Took it to a shop and the mechanic said the system was full of refrigerant but that the compressor was not getting the proper signal and there was an electrical problem.
I check the power at the compressor and it is reading about 7 volts, which is low correct? That should be getting 12-13 volts correct? I also check the pressure switch over by the passenger side and it was getting 13v. What to check next to start ruling out causes? Any quick way to determine whether this is electrical or a compressor issue? I am limited in my abilities as far as electrical work goes.
Ford F-150 - 1997-2003 :: AC Compressor Is Missing
So today, I planned on switching the belt, idler pulley and tensioner since at least two of them are making noises. After taking all of the stuff off, belt, idler pulley and tensioner... and since I always compare parts I buy to parts that were in, making sure they are identical and I didn't order the wrong one. So first up I checked my tensioner and the position of them or angles are different, completely different.
So Google it to view a few diagrams and bang! it hits me... the one I took out from my F150 is for a non-AC... so back into the truck and I'm looking. Didn't have to go far when I realized that my AC compressor is missing!!!!
I keep looking around and I see that yes, I did have AC in it before I got it; because the guts are there but sliced! Great, so the job went from easy and easy I mean buy compressor and install; but now since the guts were cut, the PO sliced the thing out simply put.
1.) What are the bolt sizes that hold the compressor in place?
2.) Is there a wire connector on the compressor? or no?
Ford F-150 - 1997-2003 :: AC Compressor Not Cycling After Replaced
My AC compressor failed so I replaced it.
I put in 1 can of R134, and I don't see the compressor cycling.
How do I remove the connector to the accumulator so I can jump it and force the AC to run.
Ford F-150 - 1997-2003 :: A/C Compressor Is Rattling And Grinding
My air conditioning compressor is rattling and grinding. I am trying to determine if I need a whole new unit or just a clutch assy. I can say this, when running it's rattling, but when the clutch engages, it clears up.
Would I be right in assessing it's the clutch? 1998 250 5.4 .....
Ford F-150 - 1997-2003 :: 1999 - No A/C - Compressor Is Not Kicking On
4.6L engine.......Well my A/C isn't working I just found out. The compressor is not kicking on. I checked the charge with my gauges and it is good so I don't think the low limit switch tripped, but I don't have a manual or anything and was wondering which number relay and fuse goes to the A/C compressor.
I also need to know which fuse goes to the power mirrors as well. I downloaded a manual from the ford fleet site, but honestly I haven't gotten around to looking at it. Not home.
Ford F-150 - 1997-2003 :: 2001 - AC Compressor Completely Seized Up
I have a 2001 ford f150 with a 4.6 liter v8, my ac compressor is completely seized up, I can't afford to replace the ac right now. So I would like to just get a shorter serpentine belt to bypass the ac for now, need to get a measurement on the shorter belt for my engine? and the proper way to re route the belt without the ac?
View 7 RepliesFord F-150 - 1997-2003 :: Freon Leaking On The Back Of Compressor
I got a 2001 f150 leaking freon on the back of the compressor, can't afford to fix this summer. When I add freon should I get the freon with oil in to get oil in the system or just add regular can of freon, it took about 6 weeks before I need to add any.
View 7 Replies