Ford F-150 - 1997-2003 :: 2001 - AC Was Cold But No Blower / Intermittent Heat
I found no heat last week in my 01 F150. The AC was cold but no blower. The heat was there but no blower. I replaced the blower motor resistor. Result: i believe a FEW of the speeds worked when turning the fan speed switch...but was intermittent. It would blow L, M, H, then nothing. I jiggled the know on the dash mounted switch and heard it on/off, on/off the motor as I jiggled. I DID notice that when I disco'd the connector off the resistor the HIGH speed worked. Is the switch on the dash perhaps crusty ? Or should I be looknig at the motor itself.
View 4 RepliesFord Excursion :: 2001 - Blower Fan Won't Shut Off
I have a 2001 Ex 5.4 4wd ... I shut down my ex jumped out, locked her up and came out two days later and she was deader than a door nail. Charged battery (charger/starter) started her up and let her run for a while. Came back noticed the abs light was on, shut her down and noticed my blower motor was still running, after I shut the engine down and removed the key. Tried it again, same thing. This is obviously what drained the battery, but what in the wide wide world of sports in going on? the blower motor usually shuts off with the ignition switch when you turn the engine off..
I believe this to be the original battery, would minimal battery power make thing act strange or ????? Ignition switch is tight, never had any problems with it. I have not done any "fixin" of the wiring system so it should be ok. Took it for a drive, radio turns off with ignition as should, blower motor will turn off if I turn the b/m switch to off position before I turn the ignition off. If I leave the B/M on and turn ignition off the b/m continues to operate in any speed and will NOT shut off even if I position the b/m switch to the off position. Turn ignition on turn b/m switch to off the b/m turns off............still perplexed!!!!
Ford F-150 - 1997-2003 :: 2001 - Emergency Fuel Shut Off Switch Triggers When Truck Sits
My emergency fuel shut off switch triggers when my truck sits. Never on the road. Why would it do this?
View 3 RepliesFord F-150 - 1997-2003 :: Oil Light Came On Made A Knocking Noise And Shut Off
I have had a noise in the front of the engine of my 2002 f150 4.6 for about 2 weeks. On my way home my oil light came on made a knocking noise and shut off. The engine would not start back starter would engage but not turn motor it was seized. i called a tow truck and had it towed home. The next day just out of curiosity I tried to start it. It fired up ran and built oil pressure. If the oil pump froze will that make it . Can the oil pump make the engine act seized up?
View 3 RepliesAlero :: 2003 - Blower Shut Off And Cruise Light Will Come On
03 alero blower will shut off and the cruise light will come on. If I hit the cruise on/off and also the window switched then the blower will turn back on. If my windows wont roll down then I turn on the blower and cruise and the windows work again... similar with the cruise and turn signals... what gives here?
View 1 RepliesFord F-150 - 1997-2003 :: 2001 - Rattling Noise At 75 - 80 MPH?
At the above speeds my truck has a rattle/ticking. I think its the cats but I'm not sure. I checked all the obvious like the heat shields and stuff. The truck has 118000 miles on it and has been in So. Cal. its whole life.
View 6 RepliesFord F-150 - 1997-2003 :: Blower Motor Resistor Location
I'm looking for information and possible photo location for the blower motor resistor. My truck has climate control. I've looked under the dash on the passenger side and behind the glove box door and I've been unable to spot the location. Do I have to remove the plastic panel behind the glove box?
View 6 RepliesFord F-150 - 1997-2003 :: Blower Motor Switch Removal?
How to remove the blower motor switch on my 99 F150 without breaking anything.
View 1 RepliesFord F-150 - 1997-2003 :: Blower Motor / Blinkers Not Working
My 99 f150 blower motor and blinkers slowly but surely went out on me. The hazards still work. I changed the flasher relay and the relay for the blower motor, and nothing. I've checked all the fuses, and checked for wire issues and nothing.
View 4 RepliesFord F-150 - 1997-2003 :: 2001 - Grinding Noise When Starting
My 2001 5.4 makes a grinding noise when starting. Not all the time but some of the time. it will always start but it is annoying. Need to know if this would be starter or solenoid?
View 4 RepliesFord F-150 - 1997-2003 :: Blower Fan Speed Doesn't Increase On Level 3
I recently got a 2002 f150 5.4. The fan speed works on 1 & 2, and 4. It does blow on level 3, but it seems to blow at the same cfm as level 2. I'm thinking this can't be right. But, if it was a simple resistor issue, it wouldn't run at all on level 3, right? So, where I should look first.
View 10 RepliesFord F-150 - 1997-2003 :: Blower For Heat And AC Completely Stopped Working
2003 F150 4wd with auto climate control. My blower for heat and AC completely stopped working a few weeks ago. I have checked all fuses, i replaced the relay under the dash, i replaced the blower motor control module. I supplied power to the blower motor itself and it ran fine with no noises. I ran the self test on the controller in the dash under the radio and it passed. I am not sure what else to try.
View 7 RepliesFord F-150 - 1997-2003 :: Exact Location Of AC / Heater Blower Relay
Locating subject relay on my F-150 XLT Extended Cab, 4.6Ltruck. All my research thus far indicates it is somewhere on the truck. An electrical diagram I've come up with shows it in the "Blower/Flasher Relay Block". So my question is exactly where is the Blower/Flasher Relay Block?
View 4 RepliesFord F-150 - 1997-2003 :: 2001 V8 - Ticking Noise From Engine On Acceleration
I have a 2001 5.4 V8 with 55K miles and the tow package. On acceleration the engine makes a ticking noise. Engine seems to run fine, no misfire.
View 14 RepliesFord F-150 - 1997-2003 :: 2001 - Light Clicking Noise When Engage 4WD
I engage my 4wd all the time to keep it working and lubed up. tonight i turned it on and it was making a light clicking noise like a card in the spokes of a bike (not loud) and there was no vibrations or nothing that really sounded bad..what could be making this noise, what should I look for...
View 5 RepliesFord F-150 - 1997-2003 :: 2001 - Growling Noise From Rear End When Turning Right
I have a 2001 ford truck and it makes a growling sound when i am turning right but is not when going straight ahead wondering what part in the rear end could be making this sound.
View 2 RepliesFord F-150 - 1997-2003 :: 2001 - Rattle Noise From Passenger Side Of Engine
I'm wondering what is going on with my 2001 F-150's 5.4L Triton engine. Recently it's been making this noise that I can best describe as a "rattle" from the passenger side of the engine. It's not a constant rattle, it comes and goes every few seconds.
It sounds like it's either from the valve cover or timing cover, so I was thinking maybe it's the feared Cam Phaser failure, however the noise doesn't seem to match what I've heard from other videos of confirmed Cam Phaser failures.
I've attached a link to a video of the noise that I made. It also has a lifter tap from the opposite side of the engine that may be noticeable in the video. It has been present since I bought the truck two years ago, it hasn't gotten any worse and it isn't what I'm concerned about.
Video link : [URL] ....
Ford F-150 - 1997-2003 :: 2001 - Cold Air Intake Making Humming Noise?
I just installed a cold air intake on my 01 f150 with a 5.4 and as soon as i started it after the install there is a loud humming coming from the intake but with some throttle it goes away. ive looked around on some of the other threads that suggest the iac valve usually causes this humming noise but why would it go bad with the install?? also i broke iac breather trying to remove it from the old hose to install with the new hose so i just connected the new hose directly to the inlet behind the intake until i can get another one to replace it. could this be causing the humming as well??
View 14 RepliesFord F-150 - 1997-2003 :: 2001 - Occasional Knocking Noise Coming From Engine
I have a 2001 F150 4x4 4.6L Auto trans. 96,000 miles... I purchased it in Jan with 93,000. About a month ago it started making and occasional knocking noise coming from the engine, this noise was heard at idle in park and in drive. when I revved the motor it would go away but as the idle settle back down you could hear it again. the noise would go away as I was driving and come back with no rhyme or reason, I put a stethoscope on the engine and it seemed loudest under the oil pan. The oil gauge is up between 5/8 to 3/4. Fast forward to now, When I start it I hear a scraping almost grinding noise that resonated thru the cab it has the same intermittent characteristics. I think I am going to remove the serp belt, remove the trans inspection cover next and see what happens. Oh I did put a scan too on it, no codes but did notice 1 long term 02 sensor trim was staying around -.618 if I remember.
View 11 Replies