Ford F-150 - 1997-2003 :: Alternator Or AC Compressor Growling Noise?
I drive a '99 F150 4x4 5.4 EFI 196,000 miles. Recently I started noticing a growling noise that followed engine speed. I immediately thought alternator going out. So I pulled the belt off and it spins free and doesn't feel rough at all.
So I started it up and realized the noise got a lot louder when the ac clutch cycled. Now I'm thinking ac compressor. A short trip to my mechanic who didn't even really look at it very long and he said the compressor is about ready to seize up. I thought I might just put on an ac bypass pulley to get by for a while. Not really a sound decision in the middle of July, I'm thinking, but I'm poor and it beats having the compressor lock up, right?
Today, when I get off work and pop the hood with the ac off and the clutch not engaged the noise is worse than ever. I put a stethoscope (long screwdriver, I told you I was poor) on the alternator and it is making all of the noise. Turned the ac on again and it was really making noise now. So I applied the stetho-driver to the ac compressor and it is quiet as can be.
I am cautiously optimistic that the alternator is the sole culprit and that it only gets louder when the ac cycles because of the extra drag on the belt.
Does that seem like a logical explanation? Should I just try the alternator? I really don't want to destroy a perfectly functioning ac system only to find out that it was OK to begin with and I don't want to buy a $150 alternator for no reason either.
Ford F-150 - 1997-2003 :: 2001 - Rear Differential High Gear Noise
I just came back from a long trip and during the 400 miles drive I started to hear noise coming from my differential - kind of like a constant high gear loud noise. I will hear this noise when I start to accelerate and it will only gets louder and louder as I go faster and faster. I had a pinion seal leaked fixed last week and I checked the fluid and it is full.
View 9 RepliesFord F-150 - 1997-2003 :: 2001 V8 - Scrubbing Noise From Right Rear When Applying Brakes Heavily
2001 F150--V8-4.6-3.55--8.8. 221000 Miles. Changed front rotors and pads. Had scrubbing noise from right rear when applying breaks heavily. Changed rear rotors and pads. Still have scrubbing noise when breaking hard. I do not hear any noise when driving regular or when normal breaking. Differential fluid was a tad low. Applied fluid. Still have scrubbing noise. No leaks at hub seal or pinion. Bearings ? Maybe?
View 5 RepliesFord F-150 (2009-2014) :: 2011 - Rubbing / Growling Noise When Turning
I have a 2011 F-150 4x4 5.0 with about 45k miles. When I drive at slow speeds (ex. 5mph) and turn the wheels left or right there is a rubbing/growling sound coming from sounds like the front end. It does it either in forward or reverse. It's not a squeaking, clicking, or metal on metal sound. It does not do it when the wheels are straight. I rolled underneath and couldn't see anything that stuck out right away. What could be causing this?
View 12 RepliesFord F-150 - 1997-2003 :: 2001 - A/C Clutch Not Turning On?
My AC clutch is not turning on. I do not have any AC gauges but if I unplug the compressor and put a meter on the 2 harness pins, I do not see any voltage when truck is running and AC on. I really don't know much about AC but I am thinking the problem may possibly be the low pressure switch or possibly low on freon. How can I check if I am low on freon without gauges? Where exactly is the low pressure switch located on my truck and if I jump the switch and the clutch kicks on, does that tell me that the problem can only be the low pressure switch or low on freon. I'm just trying to work through a few of the gremlins.
View 14 RepliesFord F-150 - 1997-2003 :: Clunking From Rear End When Turning Corners With Bumps Only
When I turn over bumps not on corners I hear nothing lol ..I just changed the tie rods for other reasons and nothing is loose in the front end now..But this sound is from the box of the truck like something is in the box bumping around when turning corners over bumps..Its frustrating and I cant find out what it is..Only happens when turning over bumps ?
View 6 RepliesFord F-150 - 1997-2003 :: Whine When Turning From Rear End / Shutter When Takeoff Or Back Up
I've got a 2003 F150 4x4 supercrew that's got a 9.75" rear end with 3.73 gears. I just replaced clutch packs and spider gear set 2 weeks ago. The last day or two I have noticed that when I make sharp turns that it get a whining like spinning noise. It sounds to me like the spider gears are spinning. It only does it when making sharp turns. There is no noise going down the highway or normal driver. I have noticed at times I get a little shutter when I go to take off or back up. Kinda feels like a brake is hanging. I put friction modifier in when I did the clutch packs and everything. Maybe not enough?
View 5 RepliesFord F-150 - 1997-2003 :: 2001 - Engine Is Turning Over But Starting Intermittently
The past week or 2 I have had an intermittent starting problem. Engine is turning over but wont start, but after i wait a second it will start up. I listened to see if the fuel pump was running and heard the whine. I checked the battery and the starter voltage and it was all good. i primed the fuel pump a couple of times and it started up on the first crank of the ignition. The truck runs great when driving and idling, no misses or loss of power that i have felt or heard yet. I am thinking it is either the fuel pump is starting to go or maybe the fuel filter is getting a little clogged up. Like i said up above this is an intermittent problem and that is why I am confused. Its a 2001 F150 4.6 4X4 ....
View 1 RepliesFord F-150 - 1997-2003 :: 2001 V8 - Creaking Sound Coming From Front End While Turning
2001 F 150 5.4 V8 4WD. I have a weird creaking sound coming from the front end, sounds like the passenger side, whenever I turn right at any speed. What it is?
View 6 RepliesFord F-150 - 1997-2003 :: 1998 - Clicking Noise While Turning Left
When I turn left a "clicking" noise appears, it's rhythmic and I figured it was the CV joint at the drivers side going bad. Bought a new one and installed it. Clicking seemed to get away for maybe 5-7 days. Then it occurred again. Because the package in which the cv joint arrived was very roughed up I thought maybe it took damage during delivery and bought a new one. Installed and guess what? Took a drive after that, NOTHING and now it's clicking again. It's so loud you can hear it when you drive behind my truck and I'm turning. Doesn't seem to make a difference if I brake or not.
View 14 RepliesFord F-150 - 1997-2003 :: 2001 4.6L Keeps Turning Over But Not Starting / Fuel Pump Makes Noticeable Buzzing Sound
My 2001 4.6L F-150 has been sitting on the driveway, used once every 2 weeks or so for the last 3 yrs. I came to start it a few days ago and it kept turning over but not starting. The key security chip is working, battery is charged, all plugs are firing, fuel pump fuse and relay check good. When I turn the key to ON, sometimes I hear the fuel pump priming, other times it doesn't. The times it does prime, the truck fires right up.
The times it doesn't prime, engine won't start. When the pump does prime, and while the engine is running, the pump makes a noticeable buzzing sound, much louder than normal. When the pump primes. fuel pressure measures at 42psi in the ON position, 36psi with engine running, and 46psi with engine running and vacuum hose removed. I believe all these are within specs.
My question is this: Is it safe to assume that the pump is going bad and will eventually fail completely? My second question is (and I know this can be debated til the end of time) should I get the Motorcraft or aftermarket? I have Airtex, Spectra, Carter, and Delphi available locally.
Honda - Cr-v :: 2001 - Growling Or Low Pitched Grinding Coming From Rear Tire Area
Have a CR-V noise coming from rear tire area I think. It sounds like a growling or low pitched grinding. Noticeable at 30-40 mph up hills. I have changed trans fluid and rear diff fluid in the last 15K miles.
View 4 RepliesCamry :: 2007 LE Growling Noise From Rear Right Wheel
I have 2007 Camry LE with about 88K miles on it. I get the growling noise from the read right wheel, particularly when turning right. I can very clearly hear it inside. Interestingly, this happens only first couple of times after I pull it off from parking.
I recently had the brakes and rotors replaced but the noise did not start coming until a couple of weeks later. I suspected it must have something to do with tires so I got them rotated. But that didn't stop the noise.
Initially, when I first heard the noise about 2 months back, it was very seldom but now it's almost everyday. When I got the tires rotated, I was told that I needed the rear wheels aligned. (But if it's due to alignment issue, shouldn't be coming from both wheels?)
Ford F-150 - 1997-2003 :: Power Steering Noise - Hissing / Swooshing Sound When Turning The Wheel
I just bought a 99 f150. Its in great shape only 65000 on it but there is a hissing swooshing sound when turning the wheel... not really any brake sounds. The truck has been maintained and I dont see any leeks in the ps system hoses. I didn't know anything about the atf fluid in the truck... and I haven't added either ps or atf fluid to it. I'm wondering if that is maybe something the dealer i bought it from did. or maybe one of the shops the previous owner did. Would ps fluid cause these kinds of sounds? Do I need a flush of the system.. How to do that.
View 14 RepliesNissan :: 1997 - Growling Noise When Depress The Clutch Pedal With Engine Running
For a little wile now, I have had a growling noise when I depress the clutch pedal with the engine running. It mostly does it when the truck is cold and goes away after a few uses but was getting worse and taking longer to go away. The transmission shifts normally, the clutch operates normally and it does not make the noise if I put the transmission in neutral and let the clutch out. So I'm thinking dry throw out bearing.
I did an oil change Monday, and while it was up on the ramps, I decided to check the transmission oil level, I mean its got a 181k on it so its about time to check, right. Bone dry. I put about 2 qts of gear oil in the transmission that the service manual says has a 4 1/4 pint capacity. I took it out for a drive today and the noise is gone. Go figure.
I only drive the truck one or two times a week, sometimes less so in a couple of weeks I will check the transmission again for a leak, but there was no sign of a leak when I was under there Monday. But is still shifts smoothly, makes no noise.
Ford F-150 - 1997-2003 :: 2001 - Factory Sliding Rear Window Leaking
2001 F150 Supercrew Lariat, the back window is the factory sliding window, it is leaking around the top on the drivers side, leaks bad. Question is how easy is it to remove the window and replace the seal?
View 10 RepliesFord F-150 - 1997-2003 :: 2001 - Bad Valve On Passenger Side - Oil Leak At The Rear Of Engine
I have a 2001 Screw 4x4 that had a bad valve on the passenger side. I got the head rebuilt and put it all back together. Now it has a pretty bad oil leak at the rear of the engine. I thought it was the valve cover gasket but when I took it off the gasket was right where it's supposed to be. I pulled the starter and it seems to be leaking out of the new head gasket. What could I have done wrong? The thing runs perfect now but it's dripping oil like crazy so I had to have done something wrong. I used an OEM head gasket from the dealer and torqued the new head bolts to 30 ft-lbs and then went another 90 turn twice just like the book said.
View 14 RepliesSanta FE SM (2001-06) :: Growling Noise When Turn The Key To Prime The Fuel Pump
Instead of a normal humm I get a growling noise when I turn the key to prime the fuel pump.. I am think fuel pump issues.. but no sure if thats what it is??
View 9 RepliesFord F-150 - 1997-2003 :: Clicking Noise From Rear End When Slowing Down From About 20 MPH
2003 F150 SuperCrew 9.75". Today we got to tearing into my rear end on my truck. I was having a clicking noise from the rear end when slowing down from about 20mph. It was a constant click, click, click, click. It was driving me nuts. Well when I first tore the cover off to change the wheel bearings I found some metal pieces in the bottom of the rear end housing.
I did some researching and came to the conclusion it was the shims behind the side gears or the clutch packs. Well it turned out to be the clutch packs were totally shot!! The side gears and the spider gears were loose and kinda just flopping around!! I ended up changing the side gears and spiders gears, bought them as a kit through ford and then the clutch packs.
The job overall wasn't to hard at all. The hardest part was getting the spider gears spun into the carrier. Ford has a "special tool" that that compresses the clutches and another to hold the carrier through the splines in the gears so you can spin the carrier itself to spin the spider gears in. We ended up using the axel shaft itself and clamping it into a vise and setting the carrier on it to hold it from being able to spin.
We then took a piece of all thread and put it through the side gears and put washers on each of the side gears and nuts in-between them and then spinning the nuts up and down to compress the clutches. Basically what Fords "special tool" does. Then just spun the carrier with the pin that goes through the two spider gears and that was about it. Once we got that done it was all basically putting it all back together.