Elantra XD (2001-06) :: 2003 - Ran For 10 Seconds Then Shut Down Now Will Not Restart / No Spark
I have a 2003 Elantra 2.0 with no spark, no codes... anymore. The car was driven about 6 miles, shut off, went back out to start it, it ran for 10 seconds then shut down. Now it will not restart.
What I did: As per some of the advice of others I replaced the crank sensor, cam sensor, ignition coil, check compression, pulled codes from the ecu with one being a crank sensor. I have power at the fuel pump during crank, i can smell gas during crank, plugs are dry just no spark. Timing belt and timing are fine, engine sounds as it should during crank but no spark. There is power at the coils, crank and cam sensors. MIL is on when key is turned and goes off during crank.
Ford F-150 - 1997-2003 :: Hard To Restart After Driving For A While
I recently bought a 1998 F150 with 4.6 . I've been having problems starting it after I drive it awhile... When I try to restart it, it just clicks out on the firewall... The difference in what I've read about this problem and mine is that after 30 or 40 minutes mine starts right up , so far . I know the battery is good and I put a new solenoid , battery cable ends and a neutral safety switch . I just can't pinpoint the problem...
View 14 RepliesFord F-150 - 1997-2003 :: 2002 - A/C Causes Rough Idle And Stall / Sputter And Die On Restart
I have a 2002 4.6L FX4. When I run the A/C for an extended period (say 15-20+ minutes), it will start to cough and sputter and eventually just die. It will restart but run rough and cough, sputter, die.
If I turn off A/C and let it set a while, it runs fine. No check engine light. Possible EGR problem????
Ford F-150 - 1997-2003 :: No Restart / Clicking Noise Coming From Behind The Fuse Panel When Turn The Key
I have a 1999 f-150 and am having a problem that I cannot pin down . After starting the truck and running it for 10 min or so I shut it off and it will not restart again for approx. 3-4 hrs . When you turn the key there is a clicking noise coming from behind the fuse panel . Also the truck will not start if temp outside rises above 80 degrees . Is there a replaceable relay under there or is it the computer module ? Battery is new .
View 9 RepliesFord F-150 - 1997-2003 :: Spark Plug Blowing Out
I have a 1997 F150 4.6 V8 and as we all know these trucks are notorious for the spark plug blowing out. Although when I bought it I never had an issue until we put motorcraft plugs in. After a couple weeks of having these plugs in the porcelain blew out of the plug with the threads still in the head. The spark plug screws into a threaded insert which then screws into the head. We replaced the plug and nearly a month later the porcelain blew again. Replaced it, same story a week and a half later. Before the motorcraft plugs I had autolites in it, and I never had the slightest spark plug blowout problem. Should I just put an autolite in the cylinder that's blowing them?
View 4 RepliesFord F-150 - 1997-2003 :: Spark Plug 3 Blow Out
I had a plug blowout last Thursday on the freeway. I wasn't sure of what happened with my truck, it was a shutgun going off. I had to towed to my local Firestone.
My truck is a F-150 4.6 2003 with 206,000 miles.
The short of the story, plug #3 blowout. It trashed the coil and I needed a new plug. They used a Helicoli and I have been reading that they shouldn't have used a Helicoli. They should have used a Time-set.
What's wrong with the Helicoli's? Is this fixed going to last for awhile? They said the helicoli worked well. The truck had 7 NGKs and 1 motorcraft. It has all new motorcrafts now.
Ford F-150 - 1997-2003 :: No Spark To Any Cylinder And Won't Start
I recently took a 4.6 from a 98 e-150 van and put in a 1997 f 150. put new oil pump, bearings, and rings. Got everything hooked up and ready to roll. turn over but no spark to any cyl. What it might be?
View 14 RepliesFord F-150 - 1997-2003 :: Random Interval Engine Stops With Short Delay To Restart - Code PO231
I have got the most aggravating electrical gremlin possible. For over a year now, the truck intermittently just dies. Mostly it happens about 2-3 mins after start (every couple weeks or so), then takes a couple of key offs, then back ons to restart. But it does restart and then runs fine for a time.... 2 weeks ago I was rollin' down the road and hit a pothole, and whammo, she died, and wouldn't restart. I thought, "great it was the intertia cut-off going bad." I had it towed to the shop where they did some diagnosis and told me it threw a PO231 code.
The tech then said he was doing the diagnostic manual directed test, and swapped out the fuel pump relay, and it started right up. New relay, out the door. A few days later on the way to work about 2 - 3 minutes after start, she dies again. I hang my head, say a curse word, and key it a couple times, and it starts back up and runs fine. Presently speaking she's back at the shop, but the owner, who's a straight up dude was loath to take her back, because it was running fine at the time.... I've got to figure this thing out before I drive it off a cliff.
Truck -- 2001 7700 XLT 5.4L 88K miles
Symptoms -- Random interval engine stops with short delay to restart, 1 hard bump engine stop with no restart. PO231 code (after the hard bump no restart). Didn't check it previously (wasn't aware there were "soft" codes).
Troubleshooting to date -- 1 new fuel pump, 1 new fuel pump relay.
Only things left are the inertia cut-off switch (which apparently don't go bad that often), and the wiring itself/connections to the different components....
Ford F-150 - 1997-2003 :: Spark Knock - Pinging When Go Above 3000 RPM
Had it before, code p1401. Changed out dpfe and it worked for 6 months. Now spark knock again. Now though I have no codes though. No vacuum leaks that I can find. New egr from before I had the problem. I applied vacuum to the green hose and it stumbled so the ports should be ok. Snytime I go above 3000 rpm i get the pinging. I replaced the dpfe again and no difference.
View 3 RepliesFord F-150 - 1997-2003 :: Water In Spark Plug Recess
1997 f-150, 4.6, 147K miles. This morning I started the truck and the engine light was on. Felt a miss in the engine. Drove 1 mile and back then checked the wires. Found one not firing. Traced it back to the plug. When I pulled the plug boot off I noticed water in the recess, surrounding the plug. Once I blow out the water, I'll checjk the plug but I would like to know if this is a natural occurrence. I thought the boot would prevent water from filling the recess and sitting there. Or does the water just evaporate when the engine gets hot?
View 14 RepliesFord F-150 - 1997-2003 :: Spark Plug Socket Stuck
i just purchased an '01 expedition with the 5.4. I was told #5 spark plug blew out. Upon examination, it appears to be #6, second from the front driver side. Anyway, as I was looking, it just didn't look right. There was a spark plug socket stuck in the well, with the plug still in place. How to get the socket out? I can get an extension on it and it will turn, but it's tight. But I can't pull the socket out.
View 9 RepliesFord F-150 - 1997-2003 :: Coolant In Spark Plug Hole
Okay so I was getting the misfire in cylinder 3 so I pulled the plug out and it had coolant in it. Does that mean it needs a new intake manifold gasket? That is what the guy told me at the parts store. Also can I drive it like this or will it damage the engine?
View 1 RepliesFord F-150 - 1997-2003 :: 2002 - Crank But No Start Or Spark
I have a 2002 F150 5.4L (VIN-L) that has been sitting in the driveway since February. I have been a mechanic for 30 years for large commercial trucks, and my own truck has me stumped. I'm sure I've forgotten something but I'll try to list everything I have tried so far. It started with crank no start, no check engine light, checked for trouble codes got a trouble code for the CHT(cylinder head temperature) sensor.
- Replaced the CHT sensor. Cleared codes.
- Dash lights up fine, shows mileage, and anti-theft is not flashing while cranking.
- Fuel Pump does not seem make any sounds. Hit the tank with a hammer. Nothing.
- A little fuel comes out of the schrader valve on the fuel rail when I push on it. I have not checked it with a pressure gauge.
- Attempted to start with ether, nothing, so I'm assuming no spark.
- Fuel pump inertia switch isn't triggered.
- Checked several ground connections to the frame and checked ground connections in the PCM harness. All have less than 5 ohm resistance.
- Unplugged and plugged back in cam shaft sensor.
- Checked voltage on the TPS(throttle position sensor) I'm unsure about the results, if the TPS was bad wouldn't it just idle funny and/or stall?
Fuel Pump and PCM relays in the underhood fuse block appear to be good. All other fuses and relays appear to be good. I have been swapping the relays with one I think is good, although. Searched all over for additional relays, and found 3 inside the cab behind the passenger air-bag. Can't seem to find anything in the Haynes/Chilton manual that lists what they do. They are about half the size of the fuel pump relay.
Manually grounded the fuel pump relay, relay clicks but I don't hear a buzz from the fuel pump. Id like to run 12V to the fuel pump directly to see if that's my issue, but I'm not sure where to connect it without frying something important.
I bought the alldata.com DIY guide for my truck and it hasn't worked much. I have read extensively about others with similar problems and I just don't know what to do next. My main question here is, if the fuel pump is bad, would that stop the spark plugs from working? I'd rather not replace the fuel pump without being absolutely sure.
Ford F-150 - 1997-2003 :: 2001 - Oil In Spark Plug Wells
I have an 01 f150 with 5.4 triton. This has been great truck, never really had to do anything to it. It has 195k on it. Week or so ago it started running rough. So I replace the plugs and coils. I noticed some of the plug wells had oil in them. Got done and the truck is running like new.
Not sure where the oil is coming from. Not the piston as the plug was dry on the tip and truck not smoking any. I has began using a quart or so between oil changes. I have always changed it every 3k. Is it just time for new motor. Like I said it is running like new.
Ford F-150 - 1997-2003 :: Truck Suddenly Shut Down And Now No Spark
1997 F150 4x4 4.6. Truck was running fine ...suddenly shut down & now no spark, no fuel pump run, no start
1. Shot ether -no start
2. pulled plug - no spark
3. Checked crank sensor - reading .5 - .6
4. Checked fuel inertia switch - seems good
5. Switched fuel relays - no change
Thinking ECM/PCM. Also.. ?? will the "no spark" condition create a "no fuel pump run" condition ? or visa versa? I'm not positive about the reading from the crank sensor... it stays solid at .5... should it move up & down or remain constant ?
Ford F-150 - 1997-2003 :: Fuel In Spark Plug Holes / Gas Smell
I was checking my COPs and the first one I pulled out of my 2002 f150 5.4l had a clearish liquid on the coil boot. I looked down in the spark plug hole and it was filled almost to the top of the spark plug itself. I smelled it and it smelled like gas. Why this would happen and what should be done to fix it?
View 3 RepliesFord F-150 - 1997-2003 :: 2001 - Leak Right To Spark Plug Behind Hose?
I found a leak today on my 2001 Ford F150 Super Crew, 5.4 engine. In the picture, it was leaking to the right of the spark plug, behind the hose. It was bubbling up from the metal. It hasn't been overheating except when I got home and idled with the AC on. What I'm facing?
View 12 RepliesFord F-150 - 1997-2003 :: 2002 Suddenly Won't Start / Cranks But No Spark
All of a sudden my 2002 F150 6cyl, will crank but won't start. First thing I did was hook up my timing light to see if I'm getting spark when I crank. Tried a few different plug wires.....no spark. Can a coil just go out like that? I have a multimeter, what do I check to see if the plug that goes to the coil is providing correct power and input?
View 14 RepliesFord F-150 - 1997-2003 :: Missing / Died On The Side Of Road And Have No Spark?
I recently purchased a 1997 F150 4.2 Liter. On the way home it started missing. Within the next few days it died on the side of the road. After towing home I found no spark. A few days later I t started but only for a few minuites and died. No spark, coil pack is new so I replaced the CKP and it started up. Drove it about 1/2 Mile and died again, No spark again. Not getting power to coil pack when I am turning it over. So in short, new coil pack and CKP sensor and no spark. If it sits for a few days it may start or it may not. But if it does it only runs for a short period and then no spark again.
View 3 Replies