Ford Excursion :: 2000 - Clicking Noise Coming From Fuse Panel
Well I went to go to home depot and the key turned and my theft light started blinking and I hear a clicking noise coming from my fuse panel. By the way this is on a 2000 7.3l 4x4 limited. I found what was clicking (see picture) it is the second relay down, the one with the chipped plastic. My question is is this a relay I can replace or is it part of the fuse box? Where I can get a replacement? This is my daily driver so I need to fix this ASAP.
View 7 RepliesFord F-150 - 1997-2003 :: 2001 Truck Will Not Start And Clicking Noise Coming From A Relay In Cabin Fuse Box
I am having trouble with my 2001 F-150. Starting yesterday it would not start. At 1st i thought it wa the battery, so i took it off, charged it, put it back in the truck and still no start. There is a clicking noise coming from a relay in the cabin fuse box, disconnected the battery, removed relay to inspect and everything looks good. After plugging it back in, and connecting the battery, the truck still wont start and there is a clicking sound coming from the dash near the radio. Rhis is my work vehicle!!!
View 3 RepliesPhaeton :: Clicking Sound Coming From Two Cylinders Near Fuse Panel
Still trying to track down my electrical issues. While poking around in the engine compartment near the fuse panel by firewall - i heard a clicking sound coming from the two cylinders near the fuse panel.
They are cylinders - side by side - about 1 1/2 inch wide and 2 inches tall - with electrical connections and either fuel or vacuum lines attached. What are these? Some sort of solenoids? Are they part of the EVAP system?
How long should they continue to "click" after the car is turned off? Mine kept going for a half hour. I then disconnected the left side battery and it stopped. 5 hours later after fully charging the battery I hooked it up again - and the clicking came back. Is this normal or could it be a source of my battery drain?.
Ford 7.3L Power Stroke (1999-2003) :: Starter Won't Engage - Clicking In Fuse Panel?
Batteries charged, connection & cables checked. After turning ignition switch, gauges on dash jump around & starts clicking in fuse panel. Top left relay then clicking sound from beside steering column on right side next to trailer brake box. Been having electrical issues & something draining batteries...had absolutely no cold start this winter. No decent mechanics here other than to be ripped a new one @ local dealership.
View 1 RepliesFord F-150 - 1997-2003 :: No Crank / No Start - Relay In The Fuse Box In Dash Clicking
I have a 98 f150 Lariat 4wd Automatic with a 2000 4.6. When i turn the key the only thing that happens is i hear a relay in the fusebox in the dash clicking. I can cross the starter relay on the firewall with a screwdriver and itll start right up. Heres what ive done troubleshooting wise.
1. Checked battery terminals. Fine, it will start with jumping the relay so it seems good with that regard.
2. Tested the relay per the manual. Good.
3.Ohms Tested the white ignition switch box under the dash per manual. Good
4. Voltage tested the Trans Range Sensor per manual. Good.
5. Checked over all fuses, none blown.
6. No theft lights come on.
I figure since it will start jumping the relay that the battery, starter, and starter solenoid are all good. Only thing i cant seem to find is the Starter Interrupt Relay, or any sign of fusible links on the main battery cables. I am really at a loss here i figured one of the components ive tested would be it.
Ford 7.3L Power Stroke (1999-2003) :: F250 - Dome Light On And Off - Noise Under Dash Fuse Panel?
I was to leave tomorrow for a trip with three horses. Last night when I parked my truck the dome light went on and off and there was a noise (like a relay opening and closing?) coming from the area. (I have been having issues with the turn signal getting "tired". At times they would only come on solid then other times try would quit after sitting at a long light.)
Checked my manual for fuses to this issue and I removed the fuse in the spot indicated for the "dome and courtesy lights", number 14. Actually I had removed spot number 15 (5amp). This ended the noise. Drove the truck after and all seemed in order, cruise control, turn signals, interior lights! This was the incorrect fuse according to the book! This event occurred with the ignition in the OFF position. Not wanting to start my trip before I get this in order.
Jeep - Cherokee :: 1997 - Leaking Sunroof / Clicking Sound Coming From Under Glove Compartment Or Fuse Box In Same Area
The passenger side of my jeep accumulates water when it rains. (leaking Sunroof) I remove the water as soon as possible, however Lately it has developed problems starting. There is a clicking sound that is coming from under the glove compartment or maybe the fuse box in the same area. Is it possible that the fuse box could be causing the shortage and my next question is can this problem detected/ corrected, by rewiring entire box or damaged wires? I love my Black Beauty, very little problems and only 112, 000 miles.
View 4 RepliesFord F-150 - 1997-2003 :: Loud Single Knocking Noise Coming From Behind The Dash When Turn Key On
The last couple days my truck (1997 f150 4.6l) has been having starting issues. At first it would just turn over and not start then the battery would die. So i bought a new battery and yesterday now its starts sometimes but when trying to start it while its ttuning over it stops then starts turning and starts up. Then i drive wherever I am going when i get back in to start there's nothing.
Its not turning over at all but when i turn the key there is a loud single knocking noise coming from behind the dash near the passenger floor vent. Actually there ate two noise from the same area, one when i initially trun the key and another when i release the key. But after just sitting there doing this it will finally turn over and start. What this is, there are no codes being thrown besides my dreaded P0401 which i cant seem to get rid of either. Ive changed every part that has to do with the egr system and cleaned the throttle body replaced vacuum lines and still the code.
Alero :: 1999 Won't Start - Clicking Noise Coming From Fuse Box
I have a 99 Alero that wont start. I have had 3 people look at it and they don't seem to understand what's wrong with it. I was told to replace the ignition switch and to also get a new battery , which I did. It still wont start. I go to turn my key and it does absolutely nothing. Makes no noise , nothing. When I have it in the on position all my lights begin to flicker including my headlights. They also get very dim and it makes a fast clicking noise coming from the fuse box under my hood. Someone told me that my security system needs to be reset and to put it in the on position for 10 mins , but nothing happened.
View 2 RepliesFord F-150 - 1997-2003 :: Ignition Fuse Blows Every Time Turn The Key To On Position
97 F150 4.2 auto with Simple trans pan gasket change because it was leaking and now the ignition fuse blows every time I turn the key to the on position. Ran fine before now what? can't pull code with reader with key on or off.
View 4 RepliesFord Excursion :: Click Coming From Behind The Fuse Panel On Driver Side When Try To Start
Yesterday my wife went out to go somewhere and just got a click when she tried to start the X. I went home and thought it may be a weak battery and charged it up but same thing. The "click" is coming from just behind the fuse panel on the driver's side in the cab. When I turn the key to the ignition position some of the smaller lights on the dash turn off too, like the door ajar light etc, and then when I release the key they turn back on (don't know if that's normal or not, haven't really payed that much attention while starting).
2000 V10 Limited, K&N Filter, Rancho RS9000's
Ford F-150 - 1997-2003 :: Clicking Sound Coming From Steering Wheel
I have a 97 F150 that I just got a few weeks ago. I was driving home Wed. night when the 4x4 low range light would come on and off intermittently I had it in 2h the whole time. I went online and couldn't really find anything on it. So I get up to go to work on Thursday and the truck wouldn't even turn over. The battery was dead. I have put in a new one but now after turning the truck off I hear a clicking sound coming from the steering wheel. What this may be?
View 3 RepliesFord F-150 - 1997-2003 :: 4x4 And Low Range Light Come On And Off With Clicking Coming From Under Dash
I have a 97 f150 lariat 4.6L 150,000+ miles, and I am getting a lot of electrical things going wrong, been looking, and found sum kind of electric module could be the issue, except the problem are a bit dif then the ones listed. I am just wondering if it could be my issue. my problems are, 4x4 and low range light come on and off with clicking coming from under dash, daytime lights work here and there, air bag light flashes.
Then this morn my wife went to leave for work and there was a air leak hissing sound coming from the brake pedal area and that was b4 she started the truck, then she said when she got there that the heater stayed on after she shut it off and there was a beeping sound coming from the glove box. I am a general diy mechanic and dont know electrical very well, and i am at a loss.
My steering wheel seems like it is bout to fall off, and when making turns it seems to bind and not wanna turn, but when i try to pull on it, it seems sturdy but it will kinda flop if i go side to side or up and down with it.
Toyota - Corolla :: 2003 - Fuse Box Under Steering / Relay Making Clicking Noise?
I have 2003 Toyota corolla. Recently one of the relay from the fuse box under the steering wheel started making clicking noise. I got it fixed from my mechanic by replacing it twice. When my mechanic checked for codes, he found that there was some problem with igniter circuit and car's motor is not able to generate enough power. I have observed that whenever I try turning on the heater, the relay also starts making clicking noise. I got it diagnosed from a professional auto electrician but he was also not able to find the fault and now the check engine is on all the time and flashes some time. I don't know how to fix my car.
View 19 RepliesFord F-150 - 1997-2003 :: Intermittent Fuse Pressure - 20 Amp Fuse Wiggling
I was having intermittent fuel pressure problems. I replaced fuel pump and relay and was still having the problem. A figured out that wiggling the 20 amp fuse would cause the intermittent. Looking at the connections for the fuse, I can see one side was damaged. I figured I could pull the connector out from the back and fix the connector, but when I took the back off (see picture) I have a purple wire (labeled 1) going to one side of the fuse and a multi-connector (labeled 2) from one wire going to the other side. My luck, it's the multi-connector side that is damaged.
It Looks like the multi-connector goes to the Black and yellow wire. Instead of replacing the box, I figured I could just create an inline fuse for the fuel pump with the purple wire and splice it into the Black/yellow wire.
I can't see any problem with this, just looking for a second opinion. And I'm not sure how it would effect the relay. I can't find a fuse panel wiring diagram anywhere.
Ford F-150 - 1997-2003 :: Clicking Noise From Rear End When Slowing Down From About 20 MPH
2003 F150 SuperCrew 9.75". Today we got to tearing into my rear end on my truck. I was having a clicking noise from the rear end when slowing down from about 20mph. It was a constant click, click, click, click. It was driving me nuts. Well when I first tore the cover off to change the wheel bearings I found some metal pieces in the bottom of the rear end housing.
I did some researching and came to the conclusion it was the shims behind the side gears or the clutch packs. Well it turned out to be the clutch packs were totally shot!! The side gears and the spider gears were loose and kinda just flopping around!! I ended up changing the side gears and spiders gears, bought them as a kit through ford and then the clutch packs.
The job overall wasn't to hard at all. The hardest part was getting the spider gears spun into the carrier. Ford has a "special tool" that that compresses the clutches and another to hold the carrier through the splines in the gears so you can spin the carrier itself to spin the spider gears in. We ended up using the axel shaft itself and clamping it into a vise and setting the carrier on it to hold it from being able to spin.
We then took a piece of all thread and put it through the side gears and put washers on each of the side gears and nuts in-between them and then spinning the nuts up and down to compress the clutches. Basically what Fords "special tool" does. Then just spun the carrier with the pin that goes through the two spider gears and that was about it. Once we got that done it was all basically putting it all back together.
Ford F-150 - 1997-2003 :: 1999 - Clicking Noise And 4x4 Not Working?
Got a 99 f150 4x4. 4x4 use to work perfectly until 6 months ago. Now every time I turn the key on, I hear 5-6 clicks behind the dash (specifically behind the speedometer). This happened right when the 4x4 stopped working. This click is the same sound it use to make when it was working when I would shift 2H, 4H or 4L. (but just one click per turn). I get no light indicators nor click sound when I turn the switch. I've replaced the actuator, solenoids and the switch on the dash itself.
The same problem persists. I have a good vacuum and can see the actuator moving when manually grounding either solenoid to simulate a working 4x4 system. Fuse 23 and 104 are good. I had a semi-mechanic check the GEM and said 90% chance it was good but did come back with code 1838 Transmission Transfer Case Shift Motor Circuit Failure and code 1867 Transmission Transfer Case Contact Plate General Circuit Failure.The secret relay went bad? The wire went bad? Secret 4x4 connector came loose somewhere?
Ford F-150 - 1997-2003 :: V8 Truck Won't Start With Clicking Noise
It's a 97 with the 4.6 v8. I turn the key and the lights in the cab go out. A voltmeter on the battery reads 12.53 and doesn't drop at all when the key is turned. I took the alternator out and had it tested with a pass. The battery was replaced 2 months ago. I can hear the relay in the fuse box clicking away after the key is returned to the off position. Is my next step a new starter? Solenoid? Relay? This all just happened overnight. And it's only got 115,000 miles. The starter does not turn over...
View 7 RepliesFord F-150 - 1997-2003 :: 1998 - Clicking Noise While Turning Left
When I turn left a "clicking" noise appears, it's rhythmic and I figured it was the CV joint at the drivers side going bad. Bought a new one and installed it. Clicking seemed to get away for maybe 5-7 days. Then it occurred again. Because the package in which the cv joint arrived was very roughed up I thought maybe it took damage during delivery and bought a new one. Installed and guess what? Took a drive after that, NOTHING and now it's clicking again. It's so loud you can hear it when you drive behind my truck and I'm turning. Doesn't seem to make a difference if I brake or not.
View 14 Replies