Ford F-150 - 1997-2003 :: 1998 - Suddenly Died / Cranks But Won't Start - Back Link Error Code
My 4.2L died all of a sudden, it cranks but won't start. Checked the harness side to coil packs, pos. signal but no neg. Tried a code reader keeps coming back link error. Does this mean PCM is fried?
View 4 RepliesFord F-150 - 1997-2003 :: 2002 - Crank But No Start Or Spark
I have a 2002 F150 5.4L (VIN-L) that has been sitting in the driveway since February. I have been a mechanic for 30 years for large commercial trucks, and my own truck has me stumped. I'm sure I've forgotten something but I'll try to list everything I have tried so far. It started with crank no start, no check engine light, checked for trouble codes got a trouble code for the CHT(cylinder head temperature) sensor.
- Replaced the CHT sensor. Cleared codes.
- Dash lights up fine, shows mileage, and anti-theft is not flashing while cranking.
- Fuel Pump does not seem make any sounds. Hit the tank with a hammer. Nothing.
- A little fuel comes out of the schrader valve on the fuel rail when I push on it. I have not checked it with a pressure gauge.
- Attempted to start with ether, nothing, so I'm assuming no spark.
- Fuel pump inertia switch isn't triggered.
- Checked several ground connections to the frame and checked ground connections in the PCM harness. All have less than 5 ohm resistance.
- Unplugged and plugged back in cam shaft sensor.
- Checked voltage on the TPS(throttle position sensor) I'm unsure about the results, if the TPS was bad wouldn't it just idle funny and/or stall?
Fuel Pump and PCM relays in the underhood fuse block appear to be good. All other fuses and relays appear to be good. I have been swapping the relays with one I think is good, although. Searched all over for additional relays, and found 3 inside the cab behind the passenger air-bag. Can't seem to find anything in the Haynes/Chilton manual that lists what they do. They are about half the size of the fuel pump relay.
Manually grounded the fuel pump relay, relay clicks but I don't hear a buzz from the fuel pump. Id like to run 12V to the fuel pump directly to see if that's my issue, but I'm not sure where to connect it without frying something important.
I bought the alldata.com DIY guide for my truck and it hasn't worked much. I have read extensively about others with similar problems and I just don't know what to do next. My main question here is, if the fuel pump is bad, would that stop the spark plugs from working? I'd rather not replace the fuel pump without being absolutely sure.
Ford F-150 - 1997-2003 :: Truck Suddenly Shut Down And Now No Spark
1997 F150 4x4 4.6. Truck was running fine ...suddenly shut down & now no spark, no fuel pump run, no start
1. Shot ether -no start
2. pulled plug - no spark
3. Checked crank sensor - reading .5 - .6
4. Checked fuel inertia switch - seems good
5. Switched fuel relays - no change
Thinking ECM/PCM. Also.. ?? will the "no spark" condition create a "no fuel pump run" condition ? or visa versa? I'm not positive about the reading from the crank sensor... it stays solid at .5... should it move up & down or remain constant ?
Hyundai - Elantra :: 1997 - Quits And Won't Start / Cranks But No Spark
I have a '97 Hyundai Elantra (That has been turned in to a Dirt Race Car) anyway the car will idol for an hour fine. When we take it on the track it will run 4 or 5 laps fine then we take it in the pits shut it off for an hour and then go back on the track and on the 2nd lap it will quit and will not start it will crank but their in no spark also the dash lights no longer work. After the cars sits for a couple hours it will start back up and idol fine. We have replaced the ECU/ECM relay as we thought that was the problem but the symptoms remain the same. We have checked fuses and don't seem to find a problem our next step is to replace the ECM....
View 8 RepliesAccent LC (2000-05) :: 2003 - Cranks, Has Spark But Won't Start
My wife's 03 accent cranks over good, but won't start. It does fire some but won't start. I tried squirting starter fluid in the intake and that only made it fire less. Spark is strong on all four cylinders. At first I thought I found the problem because it had weak spark on the middle two cylinders and i replaced that coil pack and now all four are strong, but still same problem.
She drove it home and parked overnight, and in the morning it wouldn't start. I don't think it is the timing belt. I replaced it not too long ago, and I took a peak behind the top of the cover and all still appears to be as it should.
I am now at a bit of a loss. I mean it has good spark, won't start with starting fluid, so what could it be?
Ford F-150 - 1997-2003 :: Cranks But Won't Start?
I'm trying to diagnose a no start issue on my son's 1997 F150 4.6L W code motor. It quit on him while driving and we haven't been able to get it re-started since. We immediately assumed the fuel pump was bad as we were not getting any fuel pressure and we cannot hear the pump running at key on. So we pulled the pump and bench tested it, and the pump itself seems fine.
We then checked for spark, we have spark in all cylinders. After that we started checking fuses and #30 under the dash was blown. We replaced that and it blew again at Key on. We ended up going through about a 1/2 dozen of them while poking and prodding at misc. wire harnesses trying to figure out why it keeps blowing. Today we put a new one in and have tried restarting and that one is not blowing anymore, but we still cannot get fuel pressure. We've checked all fuses and swapped relays around. We noticed that under the dash #20 and #21 do not have power, but the fuses are ok. Are we finally on to something here?
Ford F-150 - 1997-2003 :: No Spark To Any Cylinder And Won't Start
I recently took a 4.6 from a 98 e-150 van and put in a 1997 f 150. put new oil pump, bearings, and rings. Got everything hooked up and ready to roll. turn over but no spark to any cyl. What it might be?
View 14 RepliesFord F-150 - 1997-2003 :: 2003 F150 Cranks But Won't Start
This has happened twice in 3 years....I get regular service from a Ford dealer and am overdue.... I think it may be temp related. Has been below freezing the last few nights. Truck was parked on an incline during the last two "shutdowns" ( engine lower than bed slightly), I drifted to a level position and it started. This has only happened twice previously. Now it seems to be a permanent problem but I am unable to get to the dealer without a tow... which I am trying to avoid.
View 2 RepliesFord F-150 - 1997-2003 :: 2001 - Cranks But Will Not Start
I have a 2001 F150 Supercrew Lariat. About a month ago I stopped to fill up with gas and afterwards it would crank but not start. After a few tries the engine would no longer turn over. My battery was 7 years old so I replaced it and the problem went away for about 5 days. Then the same thing, crank but no start. I checked all the fuses & called the local Ford dealer.
After talking with the parts dept. I tried hitting the panic button then the truck started. After talking to parts again I replaced the PATS transceiver. After 3 weeks with no issues the problem came back. This time I locked the doors with the keyless entry remote then unlocked them & the truck started. So I'm wondering what is my problem. Could it be the PATS module or something with the keyless entry module or some other issue.
Ford F-150 - 1997-2003 :: 2001 - Cranks But Won't Start?
F-150 Super Crew 5.4 4X4 cranks won't start. what and where do I check first?
View 8 RepliesFord F-150 - 1997-2003 :: Cranks - Won't Start Intermittently?
Several months ago, my truck begins having starting issues. Intermittently, the truck will not start, even though it cranks fine. I have done the following:
- checked inertia fuel switch. Okay.
- checked connections under hood for corrosion. Okay.
- checked fuses & start relay. Also swapped relays with no luck fixing the problem.
- sprayed water at various locations under the hood and bed, since the problem occurs more often when raining. No luck stressing the problem.
- changed fuel filter a couple weeks ago. No luck fixing the problem.
- changed battery over the winter (due to my 8 year old battery was becoming weak). No luck fixing the intermittent starting problem.
- changed the starter a month ago (since the truck stopped cranking). No luck fixing the intermittent starting problem.
- Installed a fuel pressure gauge on the fuel rail.
- Tried banging on the fuel tank with a rubber mallet. No luck fixing the intermittent starting issue.
When the truck refuses to start, the fuel pressure reads 0. Sometimes I can wait 5-10 minutes, and it will start. The truck runs fine after starting.
Sometimes waiting 5-10 minutes will not solve the problem (fuel pressure remains 0). Then, I hook my battery charger to the battery, and the voltage climbs from ~12.5V to 14.7V. The fuel pressure climbs to 30, and the truck starts.
I'm apprehensive to change the fuel pump, since it seems like more an electrical problem than a pump problem. Any diagnostic test that will tell the true problem source?
Ford F-150 - 1997-2003 :: 2000 - Cranks But Won't Start
Here's the deal. Ive got a 2000 f150 4.6 4x4xlt 170000 miles, About 2 ears ago or so the truck would not start on the first try or two. now this only occurred every once and a while. Last winter it became more of a problem. All i had to do was cycle the key a couple times listen for the pump to prime and was good to go. Summer rolls around no problem at all. Fall rolls around and here we go again no prime. cycle the key a couple times good to go. As it gets colder the problem gets worse. No we fast forward to couple a weeks ago, was out in the woods cutting firewood i go to move the truck and it wont start. I have to cycle the key like 30-40 times. Now its doing it like every time i go to mov the truck until yesterday. Now it wont prime at all. Now every time it primed in the past it runs perfect after it starts . the filter has been changed every 12-15000 or every fall, Ive replaces the fuel pump relay to try it no change, tryed the other key no difference. Im leaning towards a pump but ive never heard of one doing this before.
View 6 RepliesFord F-150 - 1997-2003 :: 2001 - Cranks But Won't Start
About a month ago, my 2001 f150 supercrew (4x4 5.4L) didn't want to start one morning. This was after a very cold night (15 degree temps). It sounded like it had plenty of juice in the battery (cranked good), just wouldn't start. Later in the day, after it warmed up, still no start. I dug thru here, and someone recommended disconnecting the positive battery cable for a minute then retrying. I did it, and it worked. All was good.
About a week ago, no start in the morning again. Tried the positive cable disconnect, no luck. After several hours, it just seemed to randomly start, and all was well again.
Today, truck started right up in the morning, but later in the afternoon (warm winter day 45 degrees) no start. Tried the positive cable disconnect, no luck. After screwing with the truck for about an hour, I decided to put the fuel pressure gauge on the rail. NO fuel pressure.
Is fuel pressure associated with the PATS, or is this a straight up fuel system problem?
Additional info: My gas tank fell out this summer, (recall on those tank straps), and I had a new tank, pump, straps and lines installed. I had a no crank, no start issue this summer, but that turned out to be the transmission not registering in park. I assume the two issues are unrelated.
Ford F-150 - 1997-2003 :: Engine Cranks Over Fine But Won't Start?
The Engine cranks over fine, but won't start. When it does start everything is okay and it runs good with no codes. I noticed that by taking the key out of the ignition, I was checking under the hood, and put it back in the truck fired right up. Also it has never done this to the second driver who has a different key. The truck runs fine at all speeds and loads, even when hauling twenty bags of wet mulch. It's a 2001, 4.6 L, RWD. Could the PATS Chip be failing?
View 9 RepliesFord F-150 - 1997-2003 :: Stalls / Stutters - Cranks But Won't Start
So I leave town Friday with the wife's car for a golf tournament that is 4 hours away. I left her with my 2001 F150 Supercrew Lariat 4x4 5.4L. She calls as I am starting my practice round on Friday stating that the truck had died on her in the local Dillons parking lot. She had driven to the east side of Wichita, then drove all the way back to the west side before swinging into Dillons to get some chinese food for lunch. When she gets in the truck to leave, she starts it and it runs rough.
She gave it gas and it ran fine for a few seconds, she put it in drive, and then it started running rough again. She stopped the truck in the parking stall ahead of her, turned it off, and restarted it. Same thing...runs rough. She tried giving it gas, but it would not go above 1500 rpm. Then it just died on her. She then tried cranking it, but it would not turn over. She let it sit overnight and got a ride from a friend (it was 102 degrees out), went back the next morning to try again. Same thing, just cranks. So I get back last night and go up with my scanner. No codes, no SES/CEL.
So, I am now thinking it is the fuel pump. I crawled underneath the truck and had her turn the key so I could see if I can hear the fuel pump. Nothing. I went ahead and disconnected the battery to let it sit overnight.
I am about to head up there and see what I can do. So far, here is my list of things I need to check:
1. Fuel pump relay #301
2. Fuel pump fuse #18
3. Check for the theft light
4. Check "inertia switch" on the passenger side kick panel
5. OPEN gas cap and listen for the fuel pump (had never heard of that one)
6. Hit the gas tank a few times with a rubber mallet to "jar" the fuel pump (again, never heard of that one).
My question to all of you is: Am I missing anything else? Alos, with it running perfect, then running rough and suddenly dying, would is necessarily be the fuel pump? I had read something about a "Fuel Pump Module" located near the spare tire. Is that something I should check into with it running rough (well, not running at all now) like this?
Ford F-150 - 1997-2003 :: 2001 - Cranks But Intermittent No Start
01 supercrew 4.6. Have had intermittent no start. The first few times it did start with a jump. Cranks fine but I thought the battery was weak. Replaced battery, same issue. 40 psi gas pressure at the fuel rail with analog gage. Theft light blinks with battery inserted. Theft light not illuminated while cranking. Battery light flashes while cranking. Battery is brand-new and charged. Opened and closed inertia switch several times to check.
View 12 RepliesFord F-150 - 1997-2003 :: 1998 4.6L - Engine Cranks But Will Not Start
I have a 98 F150, 4.6L with approx. 245,000 miles on it. recently it started, then studdered a little bit and died. I managed to get it re-started, it then shuddered a little more although I was able to drive it back up the drive way and park it. Now, it will crank however it does not even attempt to fire. The sound that it makes when trying to start seems odd to me. Like the engine is just turning against a constant resistance instead of the normal starting sound. I tried shooting a little starter fluid into the throttle body and nothing changed. I pressed on the shrader valve and got a spew of fuel to come out so it seems that it might not be a fuel problem though it sure sounds like one. Just curious, what are the symptoms of a truck with no compression?
View 4 RepliesFord F-150 - 1997-2003 :: 1999 - Truck Cranks Over But Won't Start
Last night my boyfriend took a friend to the check cashing store, truck ran fine. shut it off, and when he came out the truck would not start. it cranks over but won't start. Took ignition coil off and had it tested but its fine. What else could be wrong or what can i do to try to get it to start again.
View 5 RepliesFord F-150 - 1997-2003 :: Cranks But Takes 10 - 15 Seconds To Start?
It driving me crazy. Every 10th start of engine it cranks over and over before it fires up, no codes, changed plugs, wires, crank trigger, fuel filter, upper and lower intake gaskets, injectors, iacv. I have no clue. Runs great all time just starting issue every 10th or so start takes 10- 15 seconds to start
View 2 Replies