Ford F-150 - 1997-2003 :: 2000 - Knocking / Replaced Crank Shaft Now Water In Radiator - No Power?
I bought this truck an it ran good then one day it started knocking really bad so i replaced the crank shaft an bearings. Put everything back together started the truck an it ran like crap an i just happened to check the oil an it is milky. All the water in y radiator is now in the motor oil an truck has no power...
View 2 RepliesFord F-150 - 1997-2003 :: 2000 - Intermittent Vibration When Go Over 50 Mph Feels Like Driving Down The Rumble Strips
I have a 2000 f150 lariat. Mo problem started about 2 weeks ago. Around town its fine but when I go over 50 mph it feels like I'm driving down the rumble strips on the highway and after a couple miles it just smooths out and its fine! Yesterday I went on the interstate and it did the same but this time I ran up to 85 and the vibration stopped.
I had another motor put in about 2 months ago, #4, and he changed my rear u joint as well. I replaced the rear passenger side wheel bearing a couple months ago but there seemed like a little play in the axle still but not bad. I've been to the dealer and a few other mechanics but it doesn't do it all the time and they couldn't find what is wrong.
Ford F-150 - 1997-2003 :: Knocking Sound Coming From The Top Of Engine
New to owing a ford pickup. I bought a 2002 Ford F-150 lariat 4x4 as a project truck. I've always wanted a truck to mess around with, but once I got the truck home I noticed it had a knocking sound. It didn't sound like it came from the top of the engine so I checked the muffler first and found it had a 3" slit in it. I replaced it but the sound remains. I heard it could be lifters? Is that something I should mess with or not?
View 8 RepliesFord F-150 - 1997-2003 :: 2001 - Occasional Knocking Noise Coming From Engine
I have a 2001 F150 4x4 4.6L Auto trans. 96,000 miles... I purchased it in Jan with 93,000. About a month ago it started making and occasional knocking noise coming from the engine, this noise was heard at idle in park and in drive. when I revved the motor it would go away but as the idle settle back down you could hear it again. the noise would go away as I was driving and come back with no rhyme or reason, I put a stethoscope on the engine and it seemed loudest under the oil pan. The oil gauge is up between 5/8 to 3/4. Fast forward to now, When I start it I hear a scraping almost grinding noise that resonated thru the cab it has the same intermittent characteristics. I think I am going to remove the serp belt, remove the trans inspection cover next and see what happens. Oh I did put a scan too on it, no codes but did notice 1 long term 02 sensor trim was staying around -.618 if I remember.
View 11 RepliesFord F-150 - 1997-2003 :: 1998 4.6L - Starter Cranks Over The Engine But Intermittent No Start
I'm a relatively new F150 owner (just got rid of the 98 Ranger I drove since 99), so I thought I'd check in to see if I was overlooking something obvious. A few days ago, after driving to the store with no obvious issues, I went shopping (coincidentally for oil change materials) and when I returned to my truck it would not start.
Here is a bit of info:
Starter cranks over the engine.
Battery is relatively new, and has plenty of power.
I can hear the fuel pump kick on briefly.
Check engine light is on (EGR Valve fault).
Engine started with starter fluid.
Engine ran like normal after starting.
Finally, the vehicle started/ran fine for a few days before the issue occurred again.
Like I said, I'm not too familiar with the vehicle yet, but I'm assuming the issue must be with the fuel delivery system. I plan on replacing the EGR valve, but I am curious whether a faulty EGR valve cause a no start? Also, I'm wondering if it's more likely that the fuel pump is going bad, or something electrical is the problem since I'm under the impression that the engine stops sending fuel to the cylinder if/when the engine doesn't start quickly after turning the key.
Ford F-150 - 1997-2003 :: Small Vibration On Dashboard And Noise Underneath The Truck
I have a 2001 Ford F150 with 165800 miles. I just had my power steering pump, PVC valve, and serpentine belt replaced by tire kingdom this Sunday 3/2/14.
After they replaced those parts, and I picked up the truck. I noticed the truck was making some new noises, these noises occur when I brake an it sounds like a small vibration on my dashboard and there is a noise underneath the truck. the sound also get louder when I roll up and down the window and run the ac. This had never happened before the repairs.
I took it back on Thursday 3/6/14 back to the mechanic and told them about the new problems. Now they said I had a brake problem. So they replaced the calipers, brake pads and rotors. But I still have the weird noise.
The truck still needs two rear tires a new high-end ac line and a freeze plug. Would any of these cause the noise underneath the truck or the noise in the dashboard or is there something else?
Ford F-150 - 1997-2003 :: 2001 - Strange Rubbing And Whumping Noises Coming From Underneath The Truck
I have strange rubbing and whumping noises coming from underneath my truck. Yesterday I changed the old e-brake and lines, thought it my be rubbing on the wheel. Today I changed the front and rear axle u-joint and rear pinion seal. The front u-joint was ceased and the pinion seal was leaking. I thought this would cure it but the noise is still there , the noise is more pronounced when I make a turn. Besides that the truck runs perfect. This summer I changed all 4 rotors, calipers and pads and ball joints , shocks and muffler. Tomorrow I will jack the front up and check the front, where the noise would coming from.
2001 F150 4X4 7700 ....
Ford F-150 - 1997-2003 :: 2000 - Engine Swap Of 5.4 To 4.6?
I have a 2000 f150 5.4 4x4 auto with a bad engine, and have 1997 f150 4.6 4x4 auto rolled but with a strong engine. What would need to be done to replace the 5.4 with the older 4.6 engine?
View 1 RepliesFord F-150 - 1997-2003 :: 2000 - Service Engine Soon Light Came On?
The Service Engine Soon light has come on on my 2000 F-150 with a 4.6L when I was driving home in the rain. It has about 120,000 miles on it now. What are some of the main reasons why this comes on? Oxygen Sensors?
View 14 RepliesFord F-150 - 1997-2003 :: 2000 V6 - ABS Light Came On / Engine Cutting Out
I have a 2000 - F150xlt - 4.2L - V6:
Today while leaving work for lunch I started the engine and suddenly the ABS light came on and the engine cut out before I put it in gear. Then as I was driving each time it cut out the ABS light came on. So I stopped at the convenience store across the street from work to get some gas thinking it was low although it had a 1/4 tank. But after filling up it would not start. Then relay #2 began clicking in the fuse panel and would not stop whether the key was on or off. Several minutes of this went on and then I pressed the brake peddle in once more and everything on the dash lighted up, the dials fluttered around, the clock came back on, etc...
So I tried starting the engine again and suddenly everything started working and the engine started up. I drove it home and it ran fine with no issues, no cutting out or anything. After lunch I tried it again to head back to work and the truck would not start again. But this time there was no clicking from relay #2. Everything was dead until I pumped the brake peddle several times with the key off and then turned key in the ignition and then it started right up and drove like normal. Why it's doing this and what to check to fix it?
Ford F-150 - 1997-2003 :: 2000 - Overheating Above 55 Mph - Replace Engine?
I own a 2000 F150 4.2L (I think off the top of my head) v6 XL model. For the past couple of years I've had an issue with overheating. So far I've had the following replaced:
Radiator
Thermostat
Radiator Cap
Water Pump
The intake manifold has been repaired, that was the first item to have some work done to it. The shop I took it to said the coolant hose that runs into the manifold was corroded at the entrance to the manifold. They stated there was no way to actually replace the hose, but they gave me two options:
1. replace the entire manifold or
2. cap the existing entrance port, drill a hole into the manifold next to the port, and run a new hose.
I chose the cheaper option which I suspect is part of the problem. Now to the problem.
I can drive around town all day long no problems even in 100+ degree Oklahoma summer heat. I left it idling on the side of a street for 2 hours during summer and no problems. The moment I get the truck to 55mph it starts to overheat. Not just overheat, but peg completely out in just over a mile after hitting 55mph.
Once I drop the truck down to about 40mph the temp starts to lower, but will fluctuate between normal and 3/4 to max.
What I need to look at? I've been told head gaskets, but there's no leaks and no water in the oil. I've been told to replace the engine, which if I could afford that I could afford a down payment on a new truck. It's a bit frustrating at best.
Ford F-150 - 1997-2003 :: 2000 - Engine Surging At Idle And In Gear
My truck is a 2000 model 2wd with the 5.4 engine. It has about 234000 miles on it. It suddenly started surging last night rpm jumping around approximately 4-600rpms each time. I noticed that once I got up around 50mph it would smooth out...
View 4 RepliesFord F-150 - 1997-2003 :: 2000 2WD - Engine Cranks Great But Will Not Start
2000 F150 4.6L Romeo 2WD. Engine cranks great. Fuel pump working. Changed fuel filter. Will not start. No codes. Fixed A/C day before yesterday, only had air coming out defroster, disintegrated vacuum hose at firewall. Ran errands yesterday, no problems whatsoever. Get in truck today to go to work and no start at all, engine turns over fine. What next?
View 7 RepliesFord F-150 - 1997-2003 :: 4.6L DOHC Engine Swap To 2000 SOHC?
I have acquired a 4.6l DOHC out of a mid year 85 mustang cobra, would like to install in my 2000 F150 that has a 4.6l sohc, what is available for ECM with the swap?
View 2 RepliesFord F-150 - 1997-2003 :: 2000 - Engine Backfiring Through Intake At Startup
We have a 2002 F-150 4.6L 4x4. The engine went bad and we bought a new engine (remanned ATK). Had this engine installed and a year later it was bad and was determined it was a manufacturer defect so they sent a replacement engine under warranty.
We had this new engine installed. The mechanic fired it up and it backfired through the intake. They claim that the compression is good, the fuel pressure is good, and the timing is correct. Can they check these things when the truck is not running? The mechanic is completely frustrated with the situation...
Everything I read leads to a timing issue but they say they checked it so before I go in there screaming I want to make sure it couldn't possibly be anything else...
Santa Fe (CM - 2007-12) :: Intermittent Engine Cranking / Knocking Noise
My 2007 CM Santa Fe 45K miles began acting up intermittently. We have owned it 5 years from new and never any issues whatsoever. My wife told me that first thing in the morning it made a horrible clanking noise and the entire car shuddered so she shut it off. Then it cranked and ran for days normally. The other morning I got in it and cranked it and man, it sounded like rods knocking, pistons slapping the crank, it was awful. Actually it sounded like premature or off time detonation, the engine would not idle and would die.
After a couple more tries the engine cranked and ran smoothly but with increasing idle speed and after two instances of normal cranking but idle increasing ever upward (same morning in sequence of 10 minutes or so of trying) I called AAA and had it carried to the dealer afraid oil pump giving out, timing belt jumped, bad crank / cam sensors, who knows? Oil was changed 5K ago with Hyundai toilet paper filter.
Anyway dealer found a code, something about engine torque excess - who knows - it wasn't causing the horrible cranking idling banging noise... did some ECM/ECU update, and repaired a TSB for the passenger side Airbag seat detector. They kept it over night and still could not make it occur.
My wife is really worried because honestly it sounds like it's going to throw a rod or something *I know it doesn't have them*. It's just a horrible gut wrenching noise. Dealer mechanics could not find anything wrong and they kept it overnight to crank it cold, and when we picked it up today it cranked fine.... She can't trust it anymore.
Santa Fe (CM - 2007-12) :: Intermittent Ticking / Knocking In Rear Of Engine
I have a 2007 2.7L with 150,000 miles. Yesterday while driving at 20mph my engine all of a sudden started knocking like I lost the timing belt which I replaced 10,000 miles back, including the tensioner fully (bought as a kit off Rock auto). I parked immediately. Today we investigated a little more and what we found is that os is more like a loud knock and not a metal on metal sound. It definitely knocks faster or slower with the RPM of the engine. It even ceased for a while and the engine idles silently but then on the next restart it came back.
It even went away again with an increase in RPM but then came back at an idle or sometimes didn't. You can clearly hear it in the rear of the block. I will admit I have never changed the plugs. We can a scan on it and a misfire in #4 cylinder came up. Unfortunately my check engine light is always on because I have a bad sensor in my fuel tank that ill get to some day. So I'm not sure if that code is recent or not. I know I need to identify the location of the sound more closely before anyone touches my motor. Could it be bad gas that causes a misfire and knocking? I have had that code before and new gas fixed the misfire but there was no knocking then. I religiously change my oil every 5000 miles and just did 500 miles ago.
Ford F-150 - 1997-2003 :: Knocking After Get Up To Speed And Let Off The Gas A Bit
My 2000 F150 started knocking, it does this after I get up to speed and let off the gas a bit, it will know as I push on the gas again but if I push heavy on the gas it dose not knock, What could if be? By the way it is a hard knock not a pinging sound.
View 3 RepliesFord F-150 - 1997-2003 :: 2000 - Service Engine Soon Light On Dash / Ignition Coils Going Bad
I have a 2000 f150 with 198,000 miles. The lite on the dash came on, "service engine soon" , I had the codes read and they said the coils are going bad.
View 2 Replies