Ford - F150 :: 2004 - Exhaust Smell After Plug Change
I have a 2004 f150 LAriat supercab 5.4L triton with 120,000 mile on it. Without good reason, I let the dealer convince me to put new plugs in it. Ever since, I've had a serious smell in the cabin of gasoline and or exhaust, and a 2MPG drop in MPG. At first it smelled like gasoline. I took it back to the dealer and they said a connector had backed off, which is code for I don't even want to know what. They "fixed it" but the smell remained.
They then changed the rings on the fuel injectors. The smell got better, but there is more of an exhaust smell now. I checked many blogs about it and found several bloggers with almost the same exact situation. I suggested to the dealer that they need to check that the proper spark plugs were used and they were correctly seated. They of course confirmed this but God only knows if they actually checked.
I also looked up to see if there is a cabin filter on this vehicle and there seams to be some disagreement on the blogs about this fact as well. Now that the cold weather has arrived, I prefer not to take the cowl off or check the plugs myself until it gets a little warmer. The smell is noticeable most of the time and especially stopped at a light regardless of the heater or air conditioner. Should I be more worried about the smell or the fact that I actually took it to this dealer in the first place?
Ford - Taurus :: 1993 - Exhaust Clamp Between Resonator And Exhaust Pipe Came Off
I have a 93 ford taurus 3.8L V6 automatic GL. The exhaust clamp between the resonator and exhaust pipe came off and I need to know what size clamp I will need to replace it. I think it is a 2 inch but I am not sure.
View 1 RepliesFord Exhaust System :: 1996 F150 - Exhaust Making Strange Howling Noise
Ok, probably about 1/3 times i start my 96 f150 4.9 with true duals, the left pipe has a higher pitched howling noise, its a steady tone whether I rev the truck up or not it just gets louder. It will do it for about 6 seconds and then stop. The truck doesn't run badly because of it, but i took her to autozone to get her scanned and they said that the oxygen sensor on the first manifold bank has a slow response on startup. Is that what causes this strange noise, I don't even know how it would make it, it sounds much different from the engine. The right pipe doesn't do anything.
View 9 RepliesFord Exhaust :: 2008 F150 - Changing Exhaust To Something Having Lower Rumble And Deep Sound?
I just got a brand new 2008 F150 supercrew FX2 last wed. I love it, it's my first truck ever and I'm excited to drive it. I wanted to change the exhaust to something that has a low rumble and is deep, not too loud or anything.
View 1 RepliesFord Exhaust :: 1995 F150 - Removal Of Second Cat For Better Sound From Exhaust?
I have a 95 f150, Eddie Bauer, extended cab, 4x4, 302, 285 tires. My question is this... What happens if I remove the second cat. I am trying to get a better sound from the exhaust and have been told the second cat is making that impossible. There is no o2 sensor downstream of the second cat, so I'm thinking the computer will never know its gone. Also how well this affect power. With the bigger tires, it's kinda sluggish off the line.
View 5 RepliesFord Exhaust :: 1987 F250 - Exhaust Smell When Driving
I have a 87 F250 with a 302. Every time I drive it I smell like exhaust. Doesn't matter how short or long the trip, but the longer the trip the stronger the smell when you get out. I found 1 loose manifold bolt and tightend it, but no difference.
View 13 RepliesFord Exhaust :: Stock Exhaust Into Dual Exhaust?
.What would happen if I had a muffler shop turn my stock exhaust into a true dual exhaust system with 2 magnaflow mufflers on my 6.9L N/A diesel?
View 5 RepliesFord - F150 :: 2013 - Exhaust Pop After 20 Seconds When Truck Started
When I start my truck in the mornings. In 20 seconds + -, there an exhaust "pop". I'm assuming its to warm up the turbos. The manual says to warm them up before driving. The engine is an engineering marvel, unlike my Cub Cadet that has a plastic hose to push in the oil drain and the filter don't have a hole in the metal frame for the oil to run into the catch basin. I hope that engineer dies a slow painful death
View 8 RepliesFord Exhaust System :: 2005 F150 - CEL Came On For Code P0420
Had the check engine light in the 2005 F150 (90,000 miles) come on. Got the code checked and its P0420. I know that has to do with the cat threshold levels etc. So I believe I am looking to replace the o2 sensor, if I am not mistaken.
How hard of a job is this? Ive done a decent amount of engine work. Just looking to see if that is the right thing to try first, replacing the sensor, before replacing the cat.
Also I know its the right bank, but if I am not mistaken there is a before and after the cat o2 sensor, which do i replace? Both?
Ford Exhaust System :: 2004 F150 - O2 Sensor Location
So I was wondering where the O2 sensors are on the 04 f150s and if I could cut the rear set of cats out without throwing off those sensors?
View 13 RepliesFord Exhaust :: 1994 F150 - Huge Stock Muffler Cut Off
I have a 94 f150 with the 351 and i was wondering how loud it would be with that huge stock muffler cut off and jsut the two cats still in place. I heard the cats will still quite it down a little bit cuz I don't want anything obnoxiously loud...
View 1 RepliesFord Exhaust System :: 2002 F150 - Making Duals Louder
I currently have dual exhausts on my 2002 F150 and that's all I have besides stock for the exhaust system. How can I make it louder without getting rid of the duals?
View 6 RepliesFord Exhaust :: 2001 F150 4.2L - Moving Heat Shield Right Front Cat Converter
I want to replace the auto trans coolant lines on my 2001 F150 4.2L. I discovered I can actually see the top coolant line flare nut from outside the right wheel well, with the wheel and wheel liner removed. The lower line is just a few inches below. See photo, it's a little off, so the line connector is not seen:
The heat shield is just a little bit in the way for my hands, I have to put one through the red circled area. A 1/2" hex head bolt holds the shield to the frame (circled in green). This was easy to remove from the wheel well. After that the heat shield could be moved slightly away from the points I need to access.
I would prefer to unfasten the shield & move it out of the way for my hands. I found another bolt holding the rear end of the shield down to the frame, wasn't able to remove this - the bolt fastens to a U-nut in the frame that broke off & has trapped the bolt. Are there any other bolts fastening the heat shield down?
I was able to remove the old flare nuts with a 5/8" flare nut wrench, but have not been able to start the new nuts into their fittings, just not quite enough visibility and access.
Ford Exhaust System :: Exhaust Leak - No Gasket Or Donut Ring In The Flange?
I tore it apart and there was no gasket or donut ring in the flange. Is there supposed to be a gasket or donut ring? I can feel the leak with my hand. I have retightened & it still "tick-ticks" real bad.
View 7 RepliesFord Exhaust System :: 351w Exhaust Collector Stud Nut Size
I have a 90 bronco with a efi 351w and im missing one nut for the manifold to exhaust pipe flange. I have looked all over the net and can't find the size I know its a 1/2in socket but I need the thread pitch and size, had the parts guy try to sell me the stud and nut kit seem really expensive for just a nut and to install the full kit I have to pull skid plates and the trany supports just to start to get room to do the job, seems like a lot of work to replace 1 nut...
View 1 RepliesFord Exhaust System :: 2003 V10 - Running Little Bit Rough / Exhaust Leak?
I just purchased a 2003 V10 with 270 000kms. The truck had had regular maintenance. It has an exhaust leak and runs a little bit rough. Could the exhaust leak cause the truck to run a little rough or am I dealing with another issue?
View 2 RepliesFord Exhaust System :: Exhaust Quieter When Cold / Much Louder When Warmed Up
My F150 exhaust seems rather quiet when I first start it up, but after it gets warmed up good, the exhaust is much louder (which I like). I started wondering if I had a crack up front that widened out when it got hot, so looked under it when I got home today with it hot and still idling, but didn't see any cracks. Also I did not hear any noise like a leak. All sound was coming from the side exit pipe. So... what is the phenomenon that would cause this?
View 5 RepliesFord Exhaust :: Exhaust Manifold Leak Due To Broken Rusted Bolts
I have a 97 Expedition with the 5.4 engine and 160k miles. Recently while having other work done I was told that I had an exhaust manifold leak due to broken rusted bolts.
View 3 RepliesFord Exhaust :: 2000 - Can Remove Catalytic Converter From The Exhaust System?
Long story, I'll try to make this short, 2000 E250 5.4L What would or could happen if the catalytic converter was removed from the exhaust system?
View 5 Replies