IS F (2008-2014) :: Code P0420 After New X Force Exhaust System Install
just recently installed the new X force exhaust system on my 2008 ISF with 72,000 miles on it. I've had the exhaust on the car for about 300 miles it when I was driving home from work today the vsc and check engine light pops up. I turn the car off when I got home and then turned it back on the check engine light was off but the stored Code was still there when I read it with the scanner P0420. I'm thinking maybe there's an exhaust leak even though it sounds fine.
View 14 RepliesChevrolet - Prizm :: P0420 Code / Replaced Exhaust System - Making Noise
I have a 2001 Chevy Prizm that I just had the front pipe replaced on. It was not accelerating well and making noise. New front pipe and it feels like a new car. The check engine light came on. i cleared the code, drove it for a day or so, and the light is back on. My exhaust mechanic says we don't really need to worry about the cat con hurting our engine unless we see a decrease in performance. Are there any mechanics out there who would say that is true. The car has 160,000 miles and we want to see it go another 100,000 or so, and not do anything to damage the engine.
View 4 RepliesFord Exhaust System :: 1996 F150 - Exhaust Making Strange Howling Noise
Ok, probably about 1/3 times i start my 96 f150 4.9 with true duals, the left pipe has a higher pitched howling noise, its a steady tone whether I rev the truck up or not it just gets louder. It will do it for about 6 seconds and then stop. The truck doesn't run badly because of it, but i took her to autozone to get her scanned and they said that the oxygen sensor on the first manifold bank has a slow response on startup. Is that what causes this strange noise, I don't even know how it would make it, it sounds much different from the engine. The right pipe doesn't do anything.
View 9 RepliesFord - Taurus :: 2004 - Getting P0420 Code - Exhaust Smell In Cabin?
I own a 2004 Ford Taurus (3.0L V6, OHV (12), non-flex fuel) registering a P0420 engine code. If I can smell exhaust fumes in the cabin, can I assume there is a leak in the catalytic converter system, or could the O2 sensors be the issue (or could it be the catalytic converter itself...)?
View 3 RepliesFord Exhaust System :: 2004 F150 - O2 Sensor Location
So I was wondering where the O2 sensors are on the 04 f150s and if I could cut the rear set of cats out without throwing off those sensors?
View 13 RepliesFord - Explorer :: Check Engine Code P0420 - Catalyst System Efficiency Below Threshold
Book says "catalyst system efficiency below threshold (Bank 1)".. Is it just based on mileage or an actual bad O2 sensor or other bad system component?
View 14 RepliesFord Super Duty (1999-2016) :: P0420 Code - Leak At The Joint Where Exhaust Manifold Meets Pipe Beside The Engine
I have a 2011 F350 CC long box 4x4, with a 6.2, 93,000 km on it. I periodically get a P0420. I clear it and sometimes it comes back in 10 or 20 KM and sometimes it comes back in a couple hundred km. Been doing this for about 800 KM.
Yesterday I got an exaust leak at the joint where the exaust manifold meets the pipe beside the engine. Checked close, bolts appear intact, leak is on the outboard side blowing towards the frame. Looks like a gasket or donut seal failed.
I am wondering if the catalytic converter was plugged or restrictive, would this cause the P0420 and could back pressure from a restricted catalyitic converter cause the gasket to blow?
Ford Exhaust System :: 2002 F150 - Making Duals Louder
I currently have dual exhausts on my 2002 F150 and that's all I have besides stock for the exhaust system. How can I make it louder without getting rid of the duals?
View 6 RepliesPrius (2004-09) :: 2006 - Check Engine Light - P0420 Code / Air Leak In Exhaust
So today my CEL came on. I immediately looked at my mileage and I was EXACTLY at 500m past my oil change the other day. I checked the dip stick and lo and behold, it was about 3/4" past the full marker. I took it back to the oil change place and had them drain it down to a good level.
I had driven from NH to NY this week. I filled up my gas tank on my way home from NY. Gas cap was on nice and tight for sure.
The code is still on (not sure how many miles or drive cycles is required) for something to clear. I figured it was perhaps due to too much oil added. I decided a few hours later to take it to AutoZone and grab the diagnostic code. It's a P0420 code (Cat System efficiency below threshold: Air leak in exhaust before rear HO2S, AF Sensor Error, Fuel System Fault, Faulty Catalytic Converter).
Honda - Accord - Code :: P0420 - Catalyst System Below Efficiency / Bank 1
P0420 Catalyst System below efficiency -- bank 1
I've had this code for a couple months trying to trouble shoot it. My gas mileage has been affected, as I'm getting about 23/24 MPG city/highway. I replaced the upstream 02 sensor with am aftermarket Bosch variety( I'm not sure why a non-OEM one would make a difference, as long it's working correctly).
My car has 253k miles, the cat doesn't rattle and I don't smell any rotten eggs or anything, but it has to be clogged or the 02 sensor I got was defective. My engine runs fine and I don't have any problems accelerating or decelerating. It may still be the 02 sensor since the gas mileage decrease is so significant, or it could be my converter is really clogged up.
Golf IV / Jetta IV :: Error Code P0420 - Catalyst System Efficiency Below Threshold
On my 2002 (AVH) 2.0L 4cyl Jetta I have a persistent P0420 error code: "Catalyst System Efficiency Below Threshold"
I changed the oil, cleaned the Mass Airflow Sensor, replaced the coolant, thermostat, and coolant temperature sensor. But it's still showing up.
OBDII says it could still be:
A damaged or failed oxygen sensor (HO2S)
Downstream oxygen sensor (HO2S) wiring damaged or connected improperly
Damaged or leaking exhaust manifold / catalytic converter / muffler / exhaust pipe
Retarded spark timing
The oxygen sensors in front and behind the converter are reporting too similar of readings
Leaking fuel injector or high fuel pressure
Cylinder misfire Oil contamination
Ford F-150 (2004-2008) :: 2005 - Check Engine Light Code P0420 - CAT Threshold Level
Had the check engine light in the 2005 F150 (90,000 miles) come on. Got the code checked and its P0420. I know that has to do with the cat threshold levels etc. so I believe I am looking to replace the o2 sensor, if I am not mistaken.
How hard of a job is this? Ive done a decent amount of engine work and worked in a shop in high school. Just looking to see if that is the right thing to try first, replacing the sensor, before replacing the cat.
Also I know its the right bank, but if I am not mistaken there is a before and after the cat o2 sensor, which do i replace? Both?
Nissan - Maxima :: 2005 - Got P0420 Code
Keep getting the P0420 code on this vehicle. Have changed air filter, spark plugs, run fuel injector cleaner through the tank on Shell 93 octane fuel. Drove 430 highway miles to clean out the carbon and the SES light is still on and when we check the code it says Catalyst system effiency below threshold bank 1. How do i get this fixed?
View 1 RepliesPrius (2004-09) :: 2005 - Error Code P0420 / CEL Came On Again?
Just picked up a 2005 with 146k and full Toyota service history, although seems a steering recall was not done. Will run it to the dealer today to check. I need to decide a.s.a.p. if I am keeping the car or not (I know the seller, he will take it back)
Anyway to cut a long story short, two questions.
1) Car had P3190 and P0420 when I got it. Seller reset, drove home and within 5 minutes on the road the CEL was back on. Checked the codes at home and see only a P0420. Much to worry about? Seems this might be big (Cat) or small (O2). Car getting great mileage - 60mpg at 60mph and it seems to be running great. Should I worry or forget about it? Note I am in Florida with no inspections.
Prius (2004-09) :: 2005 - Pulled Over Error Code P0420
So I bought a used 2005 Prius back in August it had 88,000 miles on it and was out of warranty. But I had a full inspection on it and the car was in great shape. Well, after a few months of driving, I got the P0420 error. I took it into my mechanic who cleared the code and told me to call him if it came back on. It came back on, then I cleared it myself, and it came back on again. So it was confirmed that I had a bad catalytic converter.
[URL].......................
Dodge - Dakota :: 2005 V8 - Intermittent Check Engine Light Code P0420
My 2005 Dodge Dokota 4.7L V8 152,000 miles has an intermittent check engine light (CEL) code P0420 ('catalylst efficiency') that turns itself off.
1) 151,000 CEL on, code P0420, checked, cleared at dealer.
2) 151,948 CEL on, code P0420, checked, cleared at dealer (Cat Conv).
3) 152,200 CEL on, code P0420, checked, cleared at local auto parts store.
4) 152,597 CEL on. No checks.
5) 152,815 CEL turned off on its own
6) 152,849 CEL on. No checks.
7) 153,137 CEL turned off on its own.
Twice in this time CEL has came on soon after a fill up from near empty.
Engine runs fine, 18-19 mpg highway.
Have seen numerous on-line reports of other possible causes:
a) base engine problems (coolant or oil) -- coolant temp sensor
b) Air inleakage -- air systems or manifold
c) Lazy front O2 sensor
d) fuel pumps
e) timing or misfire
f) what else? - (gas cap, other...)
What to check first or categories to eliminate?
Ford Fuel System :: 2003 F150 - Service Light Randomly Comes On / Code For Left Bank Running Lean
2003 f150 supercrew with 166,000 miles on it. Daily driver. Service light randomly comes on and when code reader was put to it shows "left bank running lean." Will clear it and will randomly come back on. Truck seems to be running fine. No issues engine. Bad sensor? Or bad injector? Maybe way to test?
View 1 RepliesFord 6.7L Power Stroke Diesel :: Code P246E - Exhaust System Fault
I had a ford technician plug in and check my CEL. Says P246E, Bank 1 sensor 4, exhaust system fault. I am leaving for holidays in a couple of days but dealer to busy before I leave. Is this something that will leave a guy stranded on the side of the road? I've already been towed once...
View 5 RepliesFord Exhaust :: 2008 F150 - Changing Exhaust To Something Having Lower Rumble And Deep Sound?
I just got a brand new 2008 F150 supercrew FX2 last wed. I love it, it's my first truck ever and I'm excited to drive it. I wanted to change the exhaust to something that has a low rumble and is deep, not too loud or anything.
View 1 Replies