Ford Excursion :: 2000 - Front A/C Blower Not Working
I have a 2000 EX and my front A/C blower wet the bed yesterday. I have checked the fuses under the dash and under the hood. I removed the blower motor and supplied 12vdc directly to it. Works like a champ. I metered the harness connector with the ignition on and the fan speed switch at all speeds, I get a range of 8.1 to 8.9vdc. I metered the fuse terminals as well and get a steady 13.2vdc. Before I rip the dash apart, what is the most common to fail the Blower Resistor, Fan Speed Switch, or Blower Motor. Or, do I have a completely different issue?
View 5 RepliesFord Excursion :: A/C Not Working - Change Blower Resistor?
Ok, I've read about the blower motor resistor, and everyone says you should have HIGH speed on the fan.
2002 Excursion with digital display.
I turn the truck on, then turn on the blower. A small puff of air comes out then shuts off completely. I can hear the direction doors opening when i change between foot and face A/C.
Is this the blower resistor that needs changing?
Ford Excursion :: 2000 - Front Blower Keeps Failing
I'm on my second blower motor and fourth blower motor resistor since purchasing my 2000 Ex approximately 3 months ago. The fan returns after replacing the resistor but ultimately, fails after 2-3 weeks. What can I test, what can I do? The weather is changing quickly here in NOVA and being without a reliable heater is a non-starter for the family vehicle.
View 7 RepliesFord Excursion :: 2005 V10 - Front AC Blower Cutting Out Randomly
Have an 05 Limited Excursion v10 where the front blower motor will cut out randomly. The rear blower will work without issue even when the front is not working. When the front is working (98% of the time) all speeds seem to work and can adjust to all heating/cooling positions. After searching the forum I thought the likely culprit was the blower motor; which I replaced this pass weekend but coming home from work it cut off again, clearly the issue is not resolved. I know the ford resistor are known to be prone to issues but symptoms do not seem to point that direction. Also it is does not happen with any consistency, happens at idle just as frequently as the expressway. What else to check and how to check before I have to give in and take to dealership...
View 2 RepliesFord A/C :: 2003 E350 - Front Heater / AC Blower Motor Isn't Working
Recently bought a 2003 E350. The front heater/ac blower motor isn't working. I found the control switch melted and bought a new switch. Before installing it, I need to do some diagnostics. I checked the blower with a couple of jumpers ant it turns and blows. I think that leaves the blower motor resistor. Where it is on a 2003 E350? I also need to check the relay. I have a power distribution box at the front left under the hood. Is the relay there? The box is not labeled like my GM products. Which is the blower motor relay? Finally, which fuse controls the blower motor? I read it might be a 40 amp fuse. If so, that might narrow it down.
View 6 RepliesSuburban :: Front Blower Motor Stopped Working On All Speeds
I own a 99 Suburban 1500 5.7. The front blower motor stopped working on all speeds so I replaced the resistor, it still did not work. I then replaced the speed selector switch and it started working fine. Three days later I smelled a slight electrical burning smell and the fan stopped working again. I plan on replacing the switch again to see if that is what went bad. Whats causing this to happen? Maybe the motor is going bad and causing the switch to short?
View 6 RepliesFord Excursion :: 2000 - Right Front Turn Signal Not Working
Put a new bulb in the right front turn signal, still doesn't work (parking light works though).
View 10 RepliesFord Excursion :: 2000 - Front 2 Power Windows Not Working
My driver side on my 00 x works for the the front 2 windows but not the rear and no other door switch works the windows ...
View 8 RepliesVolvo - V70 :: 1999 - Blower For Heater Blower Not Working
The car is a '99 Volvo V70 XC AWD. The blower for the heater wasn't working this morning. When I left work it was blowing a little but not as high as it should on full.
View 7 RepliesFord Excursion :: 2003 - Windshield Front Wiper And Sprayer Quit Working
I'm working on a 2003 that the front wiper and sprayer quit working on. The rear wiper and sprayer still work fine. We replaced the multifunction switch and no change. I would like to test the motor before we keep throwing parts at it.
View 5 RepliesFord Excursion :: 2001 - Blower Fan Won't Shut Off
I have a 2001 Ex 5.4 4wd ... I shut down my ex jumped out, locked her up and came out two days later and she was deader than a door nail. Charged battery (charger/starter) started her up and let her run for a while. Came back noticed the abs light was on, shut her down and noticed my blower motor was still running, after I shut the engine down and removed the key. Tried it again, same thing. This is obviously what drained the battery, but what in the wide wide world of sports in going on? the blower motor usually shuts off with the ignition switch when you turn the engine off..
I believe this to be the original battery, would minimal battery power make thing act strange or ????? Ignition switch is tight, never had any problems with it. I have not done any "fixin" of the wiring system so it should be ok. Took it for a drive, radio turns off with ignition as should, blower motor will turn off if I turn the b/m switch to off position before I turn the ignition off. If I leave the B/M on and turn ignition off the b/m continues to operate in any speed and will NOT shut off even if I position the b/m switch to the off position. Turn ignition on turn b/m switch to off the b/m turns off............still perplexed!!!!
Ford Excursion :: HVAC Blower Won't Turn Off
I'm new and have recently bought my first X. its a 2001 XLT with the 5.4. I really couldn't pass it up with the guy asking under 7K with 104,000 miles and not a rust bucket.
I discovered last night that my blower (at least front) continues to blow when key is out and off. I have played with the key to think its a switch but am not sure. Here's the other part, If I turn the selector to off before shutting the truck off it stays off BUT if i turn it on it will not go back off and stays on....
Ford Excursion :: 2002 - Blower Cycling Off And On
Recently, my mechanic told me that I need to replace my 4wd vacuum switch (sits on the passenger side fender). After replacing the switch I drove the truck about an hour. On my way home, I noticed that blower would blow for a few minutes then cycle on an off. I was running the a/c on my drive home.Could the vacuum switch be faulty and causing this problem?
View 7 RepliesFord Excursion :: Wobbling Noise On Settings 2 And 3 Of Blower Fan
My truck started making what I would describe as a wobbling noise on settings 2 and 3 of the blower fan last week. Yesterday I went to leave and started the truck the fan was on 2 and the selector was set to floor, I went to move it to the floor/defrost option and heard what I can only compare to the grind/screech you hear when you try to start a car that's already running, then a pop and it returned to it's normal quiet but slightly wobbly sound.
I am assuming my blower motor is warning me of it's plan to call it quits in the near future. Doesn't look like a big deal at all to change, but my question is - is there any quick/maintenance clean-up type tasks for these or are they just replace when they start issuing warning threats?
Ford Excursion :: Blower Motor Only Blows On High?
Well my blower motor only blows on high which IMO points to the resistor, went and bought one and still only blows on high. Tried to test the plug that goes to the resistor but couldn't get anything, shouldn't there be 12v going to the plug and then step down to the resistor until high is selected then 12v bypasses the resistor all together? Blows strong and cold, too cold actually since we cant turn the blower down so we have to turn it off for a few minutes.
View 9 RepliesFord Excursion :: Blower Motor Only Runs With Key Out - Battery Drain?
My blower motor runs with the key out on all speeds in my excursion. Replaced blower relay in hood fuse box. NO FIX. As I move climate selector to off and turn key to acc. and off it will turn off the blower. If I turn the selector to any position such as vent or heat with the key out, blower runs thus drains the battery. Do I have to replace the whole climate pod?
View 8 RepliesFord Excursion :: 2003 - Rear AC Blower Water / Condensation
Condensation from the rear blower drain line coming out normally BUT also have some dampness in the rear carpet just outside the jack/blower door? Possible partially plugged drain?
I'll pull the whole side panel when it cools off out here, but wondered if it was possible to diagnose without pulling the panel. I'll try the window/water trick tomorrow, but the seals look really good and are still supple, so really expecting it to be the rear blower or evaporation back there.
I'm still working through all the small nuances of bringing this old 03 Ex back to perfection mechanically....
Ford Excursion :: 2000 - Blower Resistor Wiring Short?
Bought my 2000 X from a guy a week or so ago, and am now fixing all of its little "quirks". A/C blower would only blow on high, diagnosed it as a faulty blower motor resistor and got a new one. Pulled the old one out and the wiring plug that plugs into it is fried!! 3 of the plugs are stuck in it from the resister itself and there is obvious signs of shorting. What my next step should be? Im considering getting a new plug and splicing the wires back into it, but that just ignores the obvious shorting. How to fix the short?
View 3 RepliesFord Excursion :: AC / Heater Switches From Vents To Defrost When Blower Is On
When the blower is on, it automatically switches from vents to defrost vents on its on. Does it about every 4 minutes.... like it's haunted. Curious if this is something i can tackle or do i need to take it in...
View 7 Replies