Touareg :: Front And Rear Bumpers Removal?
Looking for a DYI or any info on this? Going to have my front and rear lower valances painted and the side skirts. They want to take off the bumpers 100% and not paint them on the vehicle.
View 1 RepliesGolf V R32 :: Hatch Bumpers Adjustment To Eliminate Rattles
The hatch rattle has been driving me nuts. I'd heard that the bumpers on either side of the hatch could be adjusted to fix this problem. I couldn't find a good howto on this, so I snapped a few pics.
Basically, if you adjust these bumpers so that they apply slight tension on the hatch when closed, it appears to stop the rattles that happen over low speed bumps. It's been a couple days, some pretty bumpy roads, and no rattles since the weekend. [IMG] [URL] ......
Tools Required
- One 3mm hex driver
- Two hands (one would probably do)
1) Open the rear hatch and note the bumpers on either side:
2) Note the 3mm socket in the center of each bumper, deep inside:
3) Insert 3mm hex driver into the socket, loosen (but do not remove) the screw:
4) Wiggle the bumper out -- I moved mine out about 0.5" or so. Retighten screw.
5) Close the hatch to test fit. The rubber bumper should be SLIGHTLY compressed against the stopper, but not mashed up against it:
6) Go take a drive. Tell the wife/husband/other that you need to test for rattles. Spend a few hours driving fast, just to be super sure.
Ford Excursion :: 2005 - Getting 14 Mpg?
Why am I getting at best 14 mpg. I drive 80% highway. I have 05 6.0 powerstroke 4x4. 285/75r16 non lifted 65psi. I never get over 68 mph. I see a lot of post and people are getting 17. I ran diesel keen silver through last tank still didn't do anything. My ficm puts out 48.5 constant. My delta between oil temp never gets over 5 degrees. Would stiction cause lower mpg? When first crank it rump rumps a couple times and lines out. I ordered Rev x should be here in next few days. How do I tell what flash for ficm. I read that if it has latest flash it could get bad mileage. I would like to get at least 16mpg.
View 14 RepliesFord Excursion :: 2005 - Alternators Keeps Going Out
I have a 05 EB Excursion 6.0L and I am on my third alternator. Just bought the third and I have 113K miles on the Excursion. No extra electronic just a set of backup lights. What is making the alternators go out. The second on lasted about 4 years and the first one 5 years. I have added extra wire from the alternator to the batteries.
View 10 RepliesFord Excursion :: 2005 - Programming Key Fob?
Just bought a 2005 excursion diesel and they handed me a key fob and said that all I have to do is program it.
View 8 RepliesFord Excursion :: 2005 Won't Go Into Gear Sometimes
My 05 excursion wont go into gear some times. I have to push the brake pedal a few times to get it to go..
View 6 RepliesFord Excursion :: 2005 - Stuck In 4Lo
My 2005 Diesel Excursion is stuck in 4 low. I have tried suggestions in manual but it did not work.
View 7 RepliesFord Excursion :: 2005 - Running Right Around 2000 RPM At 70 MPH?
When I purchased my 2005 Limited 6.0l I just assumed it had the factory gears in it which are 3.73s but I noticed the other day that my speedo is pretty much bang on with the 35" tires. So, that got me to thinking maybe they've been replaced already. It runs right around 2000rpm at 70mph.
View 14 RepliesFord Excursion :: 2005 - Steering Box Adjustment?
How many have had luck and results adjusting there steering box.I ajusted mine and it corrected the bad wandering proplem. I just hope this will last.
View 7 RepliesFord Excursion :: 2005 - V/B Spring Swap?
I work at a ford dealership in detroit, im looking into doing a v/b code swap, and just had some questions. my current stock excursion springs are completely shot. so i need new ones so might as well do the swap. do i need to order or get anything other than the v code springs, and the b code springs, new u-bolts, and modify the b code springs? i do not need shackles or anything to have the ex sit level when im done..? just making sure before i get involved. have viewed many topics on here about it and just want a definitive answer. 2005 excursion, v10. i actually wanted to go with the X's in front, but i dont know how to make those level in back.
View 14 RepliesFord Excursion :: 2005 V10 - Cylinder 4 Misfire
I recently purchased a 2005 Ex 6.8L V10 and I have been struggling to figure out the Cylinder 4 Misfire for close to 3 months. First thing I did was replace all 10 spark plugs with Motocraft plugs. Check engine stayed away for a few weeks... then came back. I next replaced just the #4 coli with a DG508 Motocraft coli I picked up at O'Reilly's. Again the check engine light stayed away for a few weeks.
Finally, I cleaned out #1-4 fuel injectors and swapped positions of #1 and #4. This time the check engine light stayed away for over a month. However, it just came back today, and again, it is #4. I am now at a loss for what to do. I assume it is not the fuel injector since I swapped the #1 and #4 injectors. If I have new plugs and a new coil pack, then what am i missing?
Ford Excursion :: 2005 V10 - Headlights Cut In And Out Randomly
I have a 2005 Excursion, V10, 6.8 2WD w/ 177k. About 3 months ago, I started the engine and both headlights (low beams) did not turn on (it was dark out/automatic lights) The running lights were all running. Turned the switch on/off and no luck, however the brights (high beams and flash to pass) work while this is going on. About 30 seconds later, the low beams turn back on by themselves. Fast forward 3 months, the low beams will turn off for anywhere from 1 second to 30 seconds and turn back on. This happens while sitting in driveway, driving, sitting at a light etc. No changes other then an oil change. Happens when switch set to automatic and "on" as well. Brights always work, running lights etc, just the low beams turn on and off.
View 5 RepliesFord Excursion :: 2005 - Vibration And Growling At 50 Through 70 MPH
2005 X Limited 4x4 with 80,000 miles and I'm pretty sure my non serviceable bearing units are bad. Vibration and growling at 50 thru 70 mph. Only 80,000 on OEM seems pretty low. Front bearing assemblies....
View 4 RepliesFord Excursion :: 2005 - Middle AC Is Not Working
The middle a/c is not working and to clarify my front top display is out (I took down the display and the little chips appear to need to be re-seated or soldered) so I don't know if that is playing into the whole scheme.
Right now the front a/c works, rear back works on floor, but the middle does not blow at all. I have read several posts the mention a TMX(not sure if that is it)? also mention are flapper doors (?) directional doors(?).
Had the EGR delete done (and because mine is an 05 my engine light stays on - yeah) and the SCT computer and oil cooler are next. Also replaced all the injectors and performance has greatly improved.
Ford Excursion :: 2005 - AC Defaults To Defrost When Swap To 4 Hi
I noticed when i swap to 4 hi. The AC defaults to defrost. I have read this is a possible vacuum leak. Well after driving for about a mile the AC goes back to vents " while still in 4 hi" does this mean my hubs are sticking and finally engaging? Or still probably have a vacuum leak?
View 3 RepliesFord Excursion :: 2005 - AC Quit Blowing Cold
My 05 has always had good air conditioning front and back but around three weeks ago it quit blowing cold. I found all the 134 had leaked out through a pin hole in the aluminum line that runs down the back of the engine to the rear ac unit. I removed the line and brazed the pin hole. So I reinstalled the line, put a vacume on the system for 20 mins then let it sit for another 20 to make sure I had no leaks. All seemed good so I re charged the system. Now my front blows nice and cold but the rear is warm?
My pressures at idle are around 40psi low side and 200ish on the high side when the engine is warmed up and the ambeint temp is around 74 f. If I turn it to the warmest setting for the rear it gets noticeably hotter so I'm thinking the blend door is working properly?? I've read that the thermal expansion valves can give some trouble so I pulled the jack and cubby out to gain access to it. I tried tapping on it with no gains. Also the top left line seems to be pretty cold coming out of it too the evaporator but the line coming out of the evap is room temp. I was very careful not to let any junk get into the lines when they were apart for the line repair but I'm thinking maybe some junk has plugged up the TXV?
Ford Excursion :: 2005 - Cooling Intermittent - Overheating
Original owner of a 2005 Excursion 6.8l v10, 155k miles. About a month ago 10-15 minutes or so into my ride to work on a 50-60 degree morning the check gauges light comes on, noticed the temp gauge pegged to H followed by the check engine light, then limp mode. Turned on front & rear heaters and cold air was blowing. Pulled over, checked under the hood, coolant wasn't boiling, tank was 1/2 full and cold air was blowing thru radiator. 1st thought was T'Stat. So I removed T'Stat added some antifreeze & continued to work w/o a t'stat. Then had heat thru radiator & heat in front & rear heaters. Engine ran cool with no overheat issue.
Bought aftermarker T'Stat (slant) put that in and everything back to normal. About a month later same problem happens at about the same point in my trip to work, temp pegs, no heat from heater and goes into limp mode. Shut the truck off release pressure from radiator and coolant level goes down, seems to feed back into engine. Start the truck up temp goes back to normal and everything is fine for the rest of the day with several starts/stops. Bought FORD OEM T'Stat & replaced. Next morning same problem. So i think maybe there's an air pocket somewhere, add more coolant & fill to proper level when cold. next morning from cold start same problem. Coolant is clean, just changed oil and no coolant in oil. Problem only happens from a cold startup in the morning.
I'm at a loss. I'm thinking of drilling a small bypass hole in the T'Stat.
Ford Excursion :: 2005 - Goes Out Once A Week - Replace The Battery?
my 2005 V10 Ex is garage kept. I work at home and have a different daily driver so it usually goes out once a week.
At 40,000 miles and 10 years...it still has the original factory installed battery. I keep a tender on it if it's going to sit a while and so far everything has been OK.
At 10 years, should I replace the battery just to avoid a potential problem?
Ford Excursion :: 2005 - Rear Seat Adjustable?
Just wondering if the second row seats in a excursion r adjustable. Wanting to make the rear seat of my 05 F250 adjustable.
View 13 Replies