Ford Excursion :: 2005 - Not Starting When Turned Off After Running For 20 Minutes
Started having trouble with my Excursion 6.0 Diesel stalling after being in tow/hauling a 22' boat. That issue has gone away buy now I start it and run for 20 minutes, turn it off and try to start it again and all it does is turn over. If I let is sit for about 8hrs it will start again. What is going on?
View 1 RepliesFord Excursion :: 2000 V10 Running Rough - Tug Or Misfire At Low RPM
I have a 2000 excursion 4x4 v10 with 90k. The past few months I've noticed a tug or miss fire at low RPM (2000 AN UNDER) the past week its gotten worse, some occasional rough idol and the missing is getting worse. Whats wrong?? I don't want to take it to ford yet! No Check Engine Light yet...
View 14 RepliesFord Excursion :: 2000 V10 - Won't Idle Or Stay Running?
This is for a friends gasser V-10. It has a new fuel pump and oil change. Wont idle or stay running?
View 9 RepliesFord Excursion :: 2000 - Whirring Sound From Rear And Rough Running When Rainy
I have two issues with my 2000 6.8L gas excursion. Neither seem to be causing any harm...
1st issue - While its raining, or even just really humid, on a cold startup, my truck runs rough. it almost feels like it wants to die, but doesn't. After about a 1000 feet down the road, it runs normal.
2nd issue - I've started noticing that almost always, I here a whirring type of sound coming from the back. It is not from the brakes, as they are new and the sound is best heard at a complete stop. The sound lasts for about 3 seconds and then repeats after a few more seconds. At first I thought it was the coolant circulating through the pipes that run to the rear heater unit, since the sound sounds a lot like fluid flowing through a pipe. However, my coolant level is normal and the system is tight and I have not had to add any since the only major overhaul in January. At idle, the engine sounds like it isn't idling at a constant rpm, but more like a slight up and down in rpm, but the amount is so slight, it doesn't register on the tach. The only other thing that comes to mind is the fuel pump. Is this sound a sound of imminent failure of the fuel pump? Or is it normal? The truck otherwise runs great at any speed and pulls my boat as well as I would expect it to.
Ford Excursion :: V10 Running Hot During Highway Driving
My truck has been running hot during highway driving. As long as I'm driving around town I don't have an issue. Truck has run around 199 degrees in Florida summer weather since I got it. Pulling this info from torque. At this temp the dial hits the gauge at about the 1/3 Mark. On the highway the dial will jump up to about 8/10th with a torque reading of 203 degrees. Pegging out with temp reaching as high as 210.
As soon as I pull over or even get off the interstate and continue to drive, temps come back down. Not sure what the issue is here. in the last year I have replaced the thermostat with a failsafe thermostat that if I recall was a 190. I also replaced the plastic heater control valve. I'm not really sure where to go here. My suspension is the water pump, or belt slip. I replaced the power steering pump this winter. I suppose maybe I didn't get the puppy lined up perfectly, but not sure if that would cause an issue like this.
Ford Excursion :: Running Lights Not Turning Off
What would cause the running lights to not turn off? The door ajar light is not lighting up so would it be safe to assume that it isn't a door ajar problem? The interior lights are on as well but I have already done the interior light switch mod and changed them to LEDS so my battery draw will be a lot less. The running board lights do turn off after about 45 minutes though.
My overhead console backlights do not turn on and the rearview mirror isn't lit either since last week but I do not know if the issues are related. The Lie O meter still works fine though. What fuse it is? I would like to pull it till I get this resolved.
Ford Excursion :: AC Keeps Running After Car Is Turned Off And Key Is Removed
2000 Ford Excursion - ac keeps running after the car is turned off and the key is removed. Air is actually coming out the vents!!! My wife can turn the ac off with the console switch. Nothing else is running
View 3 RepliesFord Excursion :: Starts But Won't Stay Running When Cold
When its cold outside it starts and runs good for about a second and then shuts off or runs really rough and then takes off. I tried turning it off and starting it about 4 times. After the fourth time I gave it a little gas and it started after that. If the block heater is plugged in it starts fine. And starts great the rest of the day after the initial start. It is not that cold here, lower 20's in the morning. Where to start with this problem?
View 13 RepliesFord Excursion :: 5R110 Running Hot - No Warning And Not Towing
2005 Excursion 6.0 104,000 miles
I have a scanguage2. Normal driving yesterday morning. Not towing. Temp got up to 200 deg.....then later to 240!! Never an issue with the tranny !!
Yesterday I checked:
-the fluid level and it's fine.
-There was some crud on the dipstick though.
-temps for EOT and EWT are fine.
-a distinctive hot rubber smell too when it got to that temp.
Today I checked:
- the coolant for traces of transmission fluid...there was none.
-looked under the truck for fluid that may have blown out the vent....none
-no leaks anywhere
The truck is parked and will be towed to the shop so i don't incurr any more damage. So what could the prob be??
Ford Excursion :: Running Power To Cargo Area?
I am wanting to put subs in the cargo area behind the 3rd row seats. Running power under the car back there? I'd like to come up between the 2nd and 3rd row seats since the amp will be right behind the 3rd row.
View 14 RepliesFord Excursion :: Hole In A/C Line Running To The Rear
I am not sure if it is the high pressure or low pressure line. The line had rubbed on the frame and it wore a hole in the line. I want to get this fixed and wondered any remedies or if I need to replace the whole line. Someone said I could take it to a radiator shop and they could repair the line???
View 14 RepliesFord Excursion :: Leaking Coolant Whether Engine Is Running Or Not
This guy started as a slow leak. Now leaks down entire coolant res whether engine is running.or not. Appears the connection to the rest leg isn't sealed. Not sure if available from factory, or if I should cut it out and replace with barbed tee and hose clamps. That's my inclination. Not a ton of room to work with. I think it's an excursion specific thing, from pics I don't think super duty has a t there. Guessing it's where rear coolant line tees off?
View 7 RepliesFord Excursion :: Running Lights Wire Under Dash?
I wanna hook up my tow mirrors lights to the running lights, not the turn signals. Which wire it is?
View 10 RepliesFord Excursion :: A/C Compressor Running While Using Heat - Normal?
So I was doing my coolant flush yesterday and turned on the heat, both front and rear, to move any old coolant out of piping and cores. I notice that the rear was not blowing as "warm" as the front.
I did notice that the compressor was clicking on and off the whole time. A/c pipes coming off of accumulator were freezing up/getting cold/frosty.
Is it normal for the compressor to do this when the heat is on?
Ford Excursion :: Replaced Injectors Still Running Rough?
The X 6.0 was running rough at 1700 rpm and cold it barely ran at all. The dealer did full compression test - pass with no issue. Fuel pressure regulator was bad, they replaced it. They also replaced the fuel filter. That didn't work, so back to the dealer and they diagnosed that the injectors were not optimal for about half of the cylinders. The recommendation was to replace the injectors and they gave me their quote...time for some DIY.
So, I dive in; order and install Warren rebuilt stock injectors (new down tubes and dummy plugs as well). I also went ahead and replaced both oil cooler and screen as well as the EGR cooler with an aFE improved design. I also noted the Turbo was throwing oil into the intake so I replaced the turbo with the PowerMax. Additionally, I replaced the FICM with a BulletProof unit set at 53V. Heck, I went ahead and installed an XPD coolant filter system as well.
Got the X back up and running this weekend and she runs nice, smooth and with authority. So far so good.
This morning I start her up, notice that she isn't running as smoothly. I drive and now the X is not running with that real authority (not as much power but she runs) and I note that some roughness is once again apparent at 1700 RPM.
Obviously, all of this work didn't take care of the root of the problem. What else could cause this issue? Will Rev-X take care of it (I'll get some of that ASAP)? How did she run so well for a few miles and now the problem is coming back?
I have the PHP FICM programmer and am looking to install that next but I doubt that will eliminate the root problem. I don't want to get frustrated so I'm trying to approach this systematically.
Ford Excursion :: 2002 V10 Stalls At Idle With AC Running
Since having dealer work on my brakes: replaced booster and brake light switch. While at the deal the changed all the fluids. Now my EX has been intermittently stalling when stopped in drive with AC running. When it stalled the OD light was flashing. Now we have noticed that the EX is sputtering when stopped while in drive and may stall. Also, itermittently seeing the the ABS light come on. Today it stalled and now the CEL is ON.
View 14 RepliesFord Excursion :: Dome / Running Board Stays On?
My inside dome lights and running board lights used to turn off after 30 seconds or so, after closing the door. I noticed this evening, they are staying on for 10 to 15 minutes before shutting off. I thought maybe I left the inside rolling switch on next to the headlight switch, but that was not on. I washed the vehicle earlier and dried out the contact points for the rear window and barn doors using WD-40 and wiping that off, as I noticed they had a little water around them after washing. I have washed the vehicle a few times before (had it only 3 months) with no problems until now. Lights are still staying on an extended period of time.
View 3 RepliesFord Excursion :: No Rear Running Lights Or Dashboard Lighting
I have a 2001 7,3 TDI. Yesterday I rented a trailer and when I connected the cable from the trailer to my car, the rear running lights and the dashboard lighting died. I have checked all the fuses. I read that the dash lights go out when the rear running lights go, but I cant find out what fuse or relay to change. I have checked the fuses in the car and in the engine room, but I cant find a broken one. What to do ?
View 2 RepliesFord Excursion :: Hard To Shift From Park While Running In Cold?
As it's progressively grown colder (which may or may not be related), my truck has grown all but impossible to shift from park into reverse neutral or drive with the engine running when the truck is cold. I often have to shut the engine off, and once I do it immediately is very easy to shift out of park into neutral, and then I can restart the engine. Once the truck has been driven some, it's not hard to get out of park, but if it's shut off for some time (an hour maybe) it will be difficult to shift out of park again. I don't know how to begin troubleshooting this.
View 8 Replies