Ford Excursion :: 2nd Row Seats Won't Lift Up
I bought a used 2001 Excursion. Neither of the middle row 60/40 bench seats will lift up.
The 60% (wider) bench seat lifted fine a week ago. Then I installed two car seats above them, drove it for a week, and when I took them out and tried to lift that bench seat, it seems stuck. I pull up on the lever, but the seat won't lift.
The previous owner re-upholstered the seats before I bought it, and there is no opening in the new upholstery for it even to latch into the base. So I'm very confused how it could be locked.
Similar story for the other 40% (smaller) seat. We actually just lifted this seat up and cut out holes in the new upholstery so that it could lock into the base. And when we finally pushed it down and heard it lock, after that we could not get it to lift. We pull the latch up and hear it unlock, and we can feel underneath that it is unlocked. Yet the seat will not lift.
I'm pulling with all my strength, but the seats are stuck.
Ford Excursion :: Swapping 2nd Row Bucket Seats For Bench?
I was wondering if the 2nd row bucket seats in a 2003 ex can be replaced with a bench seat. are the brackets in the same location?
View 12 RepliesFord Excursion :: Indicator Lights Come On For Both Seats On Startup
If I start my Ex even without touching the seats, the indicator lights come on for both seats, what is going on?
View 6 RepliesFord Excursion :: Removing Second Row Seats - How To Get To Torque Screw
I have a 2001 excursion and am trying to remove the second row bench seat. How do you get to the back set of of torque screws? The front ones are easy to get to but the rear are under the seat trac and I haven't been able to get to them. I am pretty sure I am overlooking the obvious.
View 3 RepliesFord Excursion :: Annoying Metal Tapping Noise From Seats
Ever since i put tires and rims on the tread of my tires gives i little bit of vibration in the cab. Now i noticed at highway speeds mostly an annoying metal tapping noise from the second row captain chairs. What could be doing that out of the seats....
View 5 RepliesFord Super Duty (1999-2016) :: 2002 F250 - How To Hook Up Wiring For Heated Seats
I have an 2002 F250 super duty that has leather seats. The seats are power but not heated. I bought seats out of a Harley Davidson edition that are electric and heated. They have an extra plug that my truck don't have. How can I make the seat heaters work?
View 4 RepliesFord F-150 - 1997-2003 :: 2002 - Front Seats Higher Than Rear - Remove Coil Spacers?
I have an 02 f150 2WD with a "leveling" kit. It was on the truck when I bought it. However, the front sets noticeably higher than the rear. The rear has lifting blocks, while the front has the lifted spindles as well as the coil spring spacers. At least I think they are spacers. I had to replace lower control arm bushings a while back, and there were black plastic rings on top of the springs. Can I remove the spacers? If I can, I plan on doing that and replacing the rear blocks with whatever I need to get the stance back. I like the height of the truck now, just hate the front being higher than the rear. I do pull my boat with it.
View 2 RepliesFord Wiring/Electrical :: 2002 - Add Power Seats On Non Power Seat?
I have a 2002 excursion XLT. it does not have power seats for the driver or passenger. I came across some power seats from a 2002 limited. what I need to know is, can I remove the non power seats and put in the seats from the limited, is the wiring already in the XLT model to just plug it in, or im I going to have to do some rewiring.
View 2 RepliesYaris/Scion & Vitz :: 2002 Echo - How To Remove Rear Seats For More Storage
I have a 2002 Echo sedan. I'd like to remove the rear seats completely for more storage (I am a musician). I was able to get the bottom foam off, but the seat "backs" are more stubborn. I see there are two bolts on the floor frame in the middle of the seat backs, and one bolt on each side of the seats where they meet the doors/frame. I tried to remove the bolts on the metal floor, but they do not budge... One socket wrench sheared right off while trying to spin it loose, and when I used a socket bit on my drill with an impact wrench attachment, it still wont budge... Are they locktitied in?
View 1 RepliesFord Excursion :: 2002 - Vibration At 70 - 75 MPH
I have a newish to me 02 ex with 7.3 psd. It had a gradual vibe at 70-75 mph that i brushed off when i test drove it. I figured it was tires, old vehicle, etc. Fast forward to a couple months later, it still happens in the same range of speed but now is bad enough to shake your coffee in the cup holder. Vibes happen regardless of throttle position, OD on or OD off, etc etc. It is entirely speed dependent, occurs on 2 lane roads when I go that fast, or on the interstate. Ive even kicked it into neutral on the interstate and the vibe is till there until it gets to 69, then it goes away.
I feel the vibe in the seat of my pants, barely in the steering wheel (I feel like what little is in the steering wheel is transmitted thru the frame, etc.) So here's what Ive had done thus far, and the vibe is still there, unchanged:
1. had wheels and tires balanced and rotated
2. had driveshaft balanced
3. had rear driveshaft u joints replaced
4. took rear driveshaft out and ran it up to 70mph on jack stands (no vibe)
5. pulled both rear axles one at a time to see if wheel bearings were OK and if vibe was there with axles out, and vibe was still there.
so i finally took it to a driveline shop and had them go through the rear end, thinking it had to be something there. They called me and said your carrier bearings are toast, so I said go ahead and rebuild the rear end with new timken bearings and new gears, etc. So they do that and I still have the same vibe at 70-75 mph. I'm at my wits end here, the shop totally expected the rear end rebuild to cure it.
The only thing I haven't done is remove the rear driveshaft and drive it in 4h to see if i can replicate the vibe there. I hate to spend anymore money on this just trial and errorring everything. That leaves the transfer case and transmission to be the only things causing the vibe as far as I know.
Also, the vibe occurs around 2k rpm, but only when at that speed. In lower speeds, at 2k rpm it is smooth as silk.
Ford Excursion :: 2002 - Shudder During Braking?
My 2002 Ex 4x4 developed a shudder during breaking. Today while trying to jack it up and put on jack stands. My 2 3/4 ton jack was too weak/short to lift it up to put on stands. I am using 6 ton stands just to lift the front.
So have to get new jack. Keep in mind I don't have a ton of cash for new jack. What size are you all using to get your ex up on stands?
Ford Excursion :: 2002 - Light Vibration Right At 70 Through 75 MPH
On that note I have a 02, 7.3 Limited with 195k on the clock. It has had this problem since I owned it. I have put about 20k on the Ex since I bought it. Right at 70 mph through 75 mph I get a light vibration.
I does not matter what I do, on or off the gas in neutral the vibration is there until I exceed or drop below that speed. The vibration is really annoying on long trips and I feel on edge the whole time waiting for something to break.
Its not strong enough to rattle change or the mirror but is enough that I can feel it and hear it. I had the wife drive and seems like most of it is coming from behind the drivers seat area.
I really don't want to start throwing parts at the problem. The guys at the shop said its a truck and thats what they do. Needless to say I found another place to have work done.
Here is what I have done so fare
New tires (Bridgestone Revos E)
Upper lower ball joints
Balanced front and rear drive shafts
Replaced the front Drive Shaft CV joint - what was not cheap
Lubed the slip joint on rear drive shaft
Ran the truck without the rear shaft and the vibration is almost undetectable but, still there.
I had it up on a lift and checked for play in all the wheels, found drivers side rear to have a little bit of movement. - Could that little bit of play be causing my issue? I am going to take the rear wheel bearing apart this weekend if time permits to investigate that. No leaks on rear axle.
I have not put new u-joints in the drive shaft as the shop said they were fine. Only the front CV joint has been replaced. Should I go ahead and just change the rear u joints out?
Also all fluids have been serviced and no metal shavings on the plug magnets front, rear, tranny, or Transfer case. I have no lift and suspension is all stock. I want to put a lift on but issue more then likely be compounded with a lift.
Ford Excursion :: 2002 - Heat Not Putting Out
2002 with 7.3 and Auto Climate Control...When the engine temp is at normal operating temperature, there is minimal heat coming out of the floor (on floor setting) and then when I turn on the rear heat there is almost no heat at all. Both fans work properly. I noticed when I turn the temp setting all the way down and then back up to 90* I can get what feels like 65-70* out of the front. Again, almost no heat on the rear. I still need to check the hoses to see what's happening at the heater core. I'm thinking it might be the controller, but not sure how the ACC plays with the rear controls.
View 13 RepliesFord Excursion :: 2002 - Trans Gets Hot While Towing
I have a 02 excursion 7.3 with 120000 miles. Went camping and towed my 28ft travel trailer weighs about 9000 lbs loaded . The trans got super hot dumped fluid in the past this time same thing but the front seal went had it replaced and the trans pump rebuilt on the way home it got super hot a few times what I need to do now. The trans guy said the trans had been rebuilt in the past don't know when cuz I bought the truck used 1.5 yr ago..... The truck has tow package coolers its set up for towing how the hell do I keep the temp down...
View 14 RepliesFord Excursion :: 2002 - Front End Is Getting Louder
I have an 02 limited and I have noticed that the frontend is getting louder I kinda think a baring is going out. What else it cloud be?
View 3 RepliesFord Excursion :: 2002 PSD Stuck In 4x4 Low And Won't Go Into Any Other Gear?
So after confirming that my Ex was in 2wd (dash switch) with no 4x4 light on gage cluster it still was in 4H. So I took it to the dealer and they managed to get it stuck in 4 Low and now it won't go into any gear but 4x4 Low. Definitely a transfer case problem but I ended up driving it home at 20 MPH. 119K on truck.
View 10 RepliesFord Excursion :: 2002 - Blower Cycling Off And On
Recently, my mechanic told me that I need to replace my 4wd vacuum switch (sits on the passenger side fender). After replacing the switch I drove the truck about an hour. On my way home, I noticed that blower would blow for a few minutes then cycle on an off. I was running the a/c on my drive home.Could the vacuum switch be faulty and causing this problem?
View 7 RepliesFord A/C :: 2002 Excursion - Air Blowing Through Defrost Only
I'm not sure if on my 2002 Excursion limited the air vents are controlled thru vacuum or electronically. Where to start. Where to even begin looking to correct this problem. I'd rather not have to pay the dealer prices unless it is something out of my league of fixing.
View 4 RepliesFord Excursion :: 2002 V10 Steering Is Stuttering
Need proper information so I can repair whatever the heck is messed up on my '02 V10 4WD.
Periodically while driving (usually at lower speeds <50 mph) I feel a "Stuttering" in the steering wheel. It feels like the steering wants to swerve left or right for a brief second with no warning. This occurs to greater or lesser extent but so far not terribly and not so I loose control of the truck.
Although I haven't experienced this on the highway I do feel a slight tug now and then in either direction.
My local shop has verified that all of the ball joints have been replaced/greased and everything appears to be aligned and in good operating condition.