Ford Excursion :: 2002 - Rear Heat Installation?
I picked up an 02 ex value xlt with out the rear heat i was wondering if any of you have installed it in a truck that never had it. i work at a scrap yard as a mechanic and will hopefully have a truck come in with the parts i need, what it all entails. Any headliner out for some odd reason maybe you could snap a photo of the piping.
View 14 RepliesFord - Windstar :: 2000 Stopped Putting Out Heat To Any Front Vents
Ford - no front heat - 2000 Windstar - actuator
My Dad's 2000 Ford Windstar van stopped putting out heat to any front vents. I was able to hear a rhythmic thumping sound when the heat control slider was placed in the hot position. I looked for info on line, and found many posts that said the actuator was probably the issue. I also went back and asked my Dad if before the thumping sound he had heard anything else, and he confirmed he had heard some gear grinding noises, which others have reported as the actuator is starting to grind and slip its internal gears. If the actuator is not working correctly, it won't hold the heater duct door in the open position, which means you can't get any hot air.
Ford Excursion :: Putting Rubber Tubing In Door Seals?
I seen a thread on here about putting rubber tubing in your door seals to stop drafts. What size tubing is used?
View 13 RepliesFord 6.0L Power Stroke Diesel :: 2003 Excursion Putting Out Black Smoke / No Tuner
I have a 2003 Ford Excursion with the 6.0 diesel. Just driving the truck today and it was putting out black smoke. What could be causing it? No tuner on my truck, just a 4 inch straight pipe and a k&n air intake (bullet proofed, but thats not for performance) ....
2003 ford excursion 6.9, black smoke, why? - YouTube ....
Pontiac - Grandprix :: 2002 - Air Conditioner Putting Out Hot Air
Hottest day ever on Planet Earth and my air conditioner in my Pontiac decides to throw hot air in my face! Luckily, for my female companion, she gets ice cold air. This 2002 Grand Prix 40th Anniversary edition has 236,000 miles, I never once had a problem with the air conditioner in the past (have thought about contacting GM asking what they did right in this car)This model has dual climate control. I noticed that in turning the selector knob on the dash climate control panel, there is hot air in the vent, bi-level, heater and defrost, but cold air comes out on the passenger side. The interior temperature functions are all similar on the '97 through '03 models of Grand Prix, just wondered if this is something I can fix, or do I need to visit a Pontiac dealer to have it diagnosed (and spend a lot of money)
View 3 RepliesSaturn - Sl :: 2002 - Car Stalls After Putting In Gas And Starts When Pulled A Fuse
I have a 02 Saturn sl2 and every time I pump gas, the nozzle will click every few dollars as if my tank is full even when its near empty or half full.
2 weeks ago: I started my engine up and went about a few feet then my engine went dead. My car would crank but not fire up and I wasn't getting a reading on the instrument panel so I figured it was a fuel pump related problem. I took a look at the fuse panel for any fuses that could be blown or in bad shape. The only fuse I pulled out was the PCM-b fuse but upon further inspection, it was good and after that, it started up fine.
Next day: I get gas after work, drive home, grab a few things, start the car up, get a few feet, dies, won't start, its instrument panel reading, pull the same fuse, put the same fuse back, go on my way.
Next week: So I haven't put any gas in my car for a week and it has been working perfectly. I start to get near 1/4 tank so I put another $25 of gas in, started my car up and only got far enough to get away from the pumps when I notice my gas gauge going down, low rpm, and lost power steering. My car then died as I was pulling into a parking space. I did the same little trick and it started up again.
Today: Make a list of reasons why my car is stalling and plan to fix them from cheapest to most expensive. Start with putting gas line antifreeze as I rule out if there is water in my tank or not. ( I meant to put in one with water absorber, but I put a normal bottle in) Start my car up, get to school which is about 6-10km and when I was pulling in I noticed that my gauge was almost empty. I stopped the car and went to start it up again to see if I would get a new reading but my car just cranked. Tried a few more times but it wouldn't start until I did my little pcm-b fuse trick.
Now I am just wondering what you people think could be the problem but this is my conclusions and debates.
Water/Air in the tank - Why would does my car stop giving me an reading on my instrument panel after it stalls.PCM fault -Why does it only happen shortly after I open my gas tank (or maybe coincidence)PCM fuse blew -It works after I put it back inFuel filter clogged or fuel pump blew -why does my car start after I do the fuse trick.
Ford Excursion :: No Cold Air Blows Only Heat
I have a 00 Ford Excursion and only heat blows out of the front vents, the temp control doesn't work at all! The back has it's own controls and will come out cold (not a/c just the outside air) when the front is on (blasting heat). What this could be?
View 10 RepliesFord Excursion :: Rear Heat Won't Working?
the rear heat doesnt work, the front heat works and the rear AC works fine.
View 6 RepliesFord Excursion :: Hard Cold Start And No Heat
I just bought an 03 Ex that hadn't been driven but 600 miles the past three years. Needless to say, there's probably some sludge causing issues somewhere. I have a Scangauge installed, which has been very useful thus far.
I've flushed the coolant, currently with distilled water, changed the oil and filter, atf and filter, and installed my 2nd set of fuel filters after getting stranded after I ran my first tank of fuel through it. After changing the fuel filters the second time, I was still having cold starting problems, requiring 3-4 long cranks before firing. Once warm, runs fine. I just installed a FICM from Diesel Tech Ron, but I still have to try 3-4 times to get it to cold start, then it runs and starts ok. Not sure why the hard cold starts...
Also, the heat doesn't work. A/C is fine, blower is working. I installed a new thermostat, and like I said, I have flushed the coolant with tap water and now distilled water, but didn't want to pour in fresh coolant just yet, in case I have to drain it again with this heat issue. That vc7b is not cheap. Tonight I drove the truck about 20 miles and my highest temps for EOT was around 215 and ECT was 205. Fluctuated between the the mid 190s to low 200s most of the time, this was over some hilly roads with no load or anything. Anything else I can monitor or check on in the mean time?
Ford Excursion :: A/C Compressor Running While Using Heat - Normal?
So I was doing my coolant flush yesterday and turned on the heat, both front and rear, to move any old coolant out of piping and cores. I notice that the rear was not blowing as "warm" as the front.
I did notice that the compressor was clicking on and off the whole time. A/c pipes coming off of accumulator were freezing up/getting cold/frosty.
Is it normal for the compressor to do this when the heat is on?
Ford Excursion :: Intermittent No Heat In Front Or Rear
I was driving yesterday and had no heat, tried rotating the dial several times, changed the vent setting and such and no heat front or rear. Then all of a sudden while waiting for a train to pass, the heat started working in the front and rear.
This morning I stated her up and had heat, but by the time I got to work (30 minutes) it was barely warm. Due to heated seats! It's 26 degrees out and I'm at work, so it'll be this evening before I get a chance to look at it.
2000 limited v10 4x4 in case it didn't show up.
Ford Excursion :: Front Heat Works Occasionally?
My front heat controls work at start up occasionally. The heat will eventually come on in front after 15-30 minutes of the truck running. Needless to say this sucks for defrosting the front window during warm up. The rear controls work fine. I do have a couple that need replacing but the fan control isn't one. Temp & selectors. I've searched but haven't been able to find anything about same issue. Where to start?
View 14 RepliesFord Excursion :: Heat / AC Turned On By Itself And Would Only Blow Warm Air
Yesterday driving home the heat/AC turned on full bore by itself and would only blow warm air. It will turn off. The rear control works correctly but the front will not blow cool air.
View 12 RepliesFord Excursion :: 2000 - Tow Mirrors With Heat And Power
I have searched many threads and seem to be confused. I have a 2000 excursion and unsure of exact plugs. I currently have the paddle mirrors that are heated and powered, and want to get the tow mirrors with heat and power. They don't need to have signals or power telescoping or folding. As long as they can manually fold. What is a good reliable mirror that will fit what I need?
View 14 RepliesFord Excursion :: Heat Is Blowing Through Dash Vents With Controls Off
Heat is blowing through my dash vents in front of the windshield with the controls OFF!
View 14 RepliesFord Excursion :: Turn Signal Flasher Doesn't Work In The Heat?
Turn signal flasher doesn't work in the heat. What gives?
All lights work. Turn signal stalk works fine. It just flashes a couple of times, then stays on. Everything works fine in cool weather, but it rarely works at all when the temperature outside is above 90 degrees. Very annoyed.
Ford - Taurus :: AC But No Heat In 2002 SEL
I have LOVED my 2002 Taurus SEL..until just recently. I have ac but no heat! which is a bit of a problem because I am in Minnesota and soon the snow will be flying!! Also, my vents on my dash are not working either.
View 7 RepliesFord - Taurus :: 2002 - No Heat Only Blow Cold Air?
I have a 2002 Ford Taurus. When we bought the car the heat worked fine. One day we went to turn the heat on and it would only blow out cool air. We replaced the thermostat and that did not work. The blower works fine it just doesn't blow any hot air out. Also, the driver side seat adjusting control went out. The seat will slide backwards and will raise the seat up and down, but when you try to slide the seat forward it just makes a funny sound. It was working fine and the other day I went to move my seat forward and it wouldn't go forward.
View 2 RepliesFord Ranger / B-Series :: 2002 - A/C And Heat Blows Through Defrost Only?
I have a 2002 Ford Ranger 3.0L truck that, all of a sudden, has a problem with the HVAC system that blows air only thru the defrost vents even when selecting any other vent levels (defrost, face/middle or floor levels).
I did find a thread on another forum regarding this problem, only it was for the 95-01 Ranger model years, yet they say that the 2002 Ranger is not the same as those earlier models.