Ford 7.3L Power Stroke (1999-2003) :: Starter Relay On Fender - Wiring Diagram
Any pic or wiring diagram of the starter relay that is mounted to the fender. I'm trying to start the truck finally but it's just cranking and I think I might have mixed up the wiring. Is there supposed to be a constant hot at the glow plug relay when the ignition is off?
View 14 RepliesFord 7.3L Power Stroke (1999-2003) :: Driver Side Brake Line Cut At Inner Fender
2003 Ford excursion 7.3. Above the drivers side front tire, the hard inner plastic made contact with the hard line above the frame.. Cut the line. I can't tell if this line is 1 piece towards the reservoir since its hidden from my quick inspection. Looking for a schematic on replacing this line?
This happened after my wife took the truck back to the sugar bush.. She must have been hitting jumps or something
Ford 7.3L Power Stroke (1999-2003) :: F350 - EBP Delete / Truck Won't Make More Than 3 PSI Of Boost
I bought a 99 f350 truck. it has a van turbo and exhaust back pressure delete. The truck wont make more than 3 PSI of boost. Ive got a p1690 wastegate actuator circuit code. unplugging the waste actuator does nothing. With the van turbo, is the actuator required? Is this code stopping the ecu from fueling and creating boost? I did a cylinder balance test, and cylinder 8 failed. Is a single injector not quite balanced enough to make it not boost past 3 psi? The turbo appears brand new (previous owner said it was), charge pipes hold pressure (tested), EBP Sensor tube is clean (shows up to 24 psi). I tested the wastegate actuator, OnDemand5 says if its over 50 ohms, its bad and replace it. its 69.5 ohms. Again, i dont want to replace it if i dont have to, as its not being used (no wastegate on van turbo), but if the ecu is preventing it from spooling because of the solenoid, ill change it.
View 14 RepliesFord 7.3L Power Stroke (1999-2003) :: Popping And Thumping Noise When Make Hard Left Turns Driving Around Town
Back in January I had my right front wheel bearing and u-joint go out, so I replaced them both. At the time I didn't realize my outer stub axle shaft was wore so I just put it back in. After a little driving the right side started to "thump" and "pop" when I would make hard left turns driving around town.
I replaced the outer front stub axle shaft and seal again because the old one was worn down. This eliminated any play in the u-joint. After a bit of driving the thumping and popping noise came back.
I decided to dig into it today so I pulled it all apart. When everything is apart it turns easily, no issue at all. When I assembled the wheel bearing, torqued it to 55 ft/lbs and installed and "locked" the hub I noticed something peculiar. I can barely turn the whole assembly by hand. I have to put a good amount of force to get the whole assembly to turn at all. When I walk to the driver side with all the same parts there i can turn the wheel bearing and locked axle shaft with one finger on the studs.
I have been in this thing 5 times and can not figure out what the heck is wrong. I can't figure out why this stupid axle shaft and wheel bearing are so hard to turn, together or separately, and I can't figure out how to get my front end to stop that thumping and popping.
Ford Super Duty (1999-2016) :: Sounds Like Tire Is Rubbing Inner Fender When Make A Slight Turn To Left
Have a problem When i make a slight turn to the left sounds like the tire is rubbing the inner fender. Don't do it all the time. The tire is not rubbing.
View 4 RepliesFord 6.0L Power Stroke Diesel :: MPGs With F350 Dually?
I know a lot depends on driving habits and load. But what MPG's should I expect to see with my F-350 dually?
With my 7.3L F-250 and Excursion in see 13-15 MPG's around town and 16-18 on the highway doing 70 mph. Towing varies with weight and wind speed.
But with the 6.0L dually and 4.10 rear, I see 10.5 - 11 MPG's at 70 mph according to the dash display. Doesn't vary much this first month I have owned the vehicle.
Ford 6.7L Power Stroke Diesel :: Rear Dually Center Cap Removal?
What is the secret to getting the rear center caps off a Dually Without scratching the hell out of them with the tire tool?
View 12 RepliesFord 7.3L Power Stroke (1999-2003) :: Power Stroke Malfunction - In Reverse / With Lights On Engine Shut Off
Last November I forgot to plug my truck in and it got down to 0, my girlfriend tried unsuccessfully to jump start it. When I got home I jumped it and got it running. I took it down to a heated shop to troubleshoot the glow plug circuit. I discovered it was not getting 12v to the glow plug relay. Also I started it and tried to back it up in the shop, when put in reverse it killed the engine, not lugged it down it was like you shut the switch off.
Also I discovered if you turn the lights on it kills the engine immediately. It will not crank with the lights on either. So far I have replaced the computer,ignition switch,batteries, and cam positioning sensor. Now comes the weird part!! I decided to get it running and pull the bulbs out of the back up lights I pulled the drivers bulb first then the passengers side bulb. When I pulled the passengers side bulb it killed the engine.
It is not my daily driver so it still sits in my shop. I have a hunch it's a ground issue but I've checked and cleaned up all the grounds I can find and it still has the problem.
Ford 7.3L Power Stroke (1999-2003) :: 2000 - No Lights With Open Door - Dome Lights On When Switch On?
I have had the PSD about 2 months. It's a 2000 Ext cab LXT.
If you open the door, no lights. If the key is in the ignition and you open the door it buzzes. If you have the light on, the light around the door locks and window controls stay on after you turn off the truck until you open the door. The dome light never comes on unless you use the switch on the light. What's up with the darkness! This truck is like a cave! No under dash lights, no door lights no dome light! As for those red lenses on the door, no wiring, no lights no nada! Do the lights com on when you open the door? Any light?
Ford Super Duty (1999-2016) :: 2003 - Dually Pickup Bed Fit In A Cab And Chassis?
ive heard that it will on the newer style trucks but will a pickup dually bed fit on a cab and chassis style truck? It's a 2003 so I've heard it's different.
View 14 RepliesFord F-150 - 1997-2003 :: Signal Lights Will Not Blink Normally When Hazard Lights Turned On
My passenger side front signal light works properly, but when I turn my hazard lights on it will not blink normally (the other 3 blink). Inside my truck when looking at my dash I see the small green blinking arrow for the left signal, but not for the right when the hazards are on. When using the signal normally, I see the small blinking green arrow for the right signal though.
1997 F150 Supercab, 4.6L V8
Ford 7.3L Power Stroke (1999-2003) :: 2001 - New Batteries Started Once And No Power Or Lights
Thought batteries were bad and replaced batteries truck started and ran. Shut it off and went to restart 30 minutes later and had no power what so ever like no batteries were in it. Put new batteries on charger the were full so hooked batteries back up and it starts. 10 minutes later same as before like there was no batteries in it. 2001 7.3 464,000 miles
View 4 RepliesFord 7.3L Power Stroke (1999-2003) :: Tap Into Interior Light Power For Step And Bed Lights?
I have some LED strips i bought, some i am going to install under the door sills to light my nerf bars/steps. The rest i am installing under the bed rail to light the inside of the bed. I want them to come on with the interior lights. So when i hit the unlock button on my key fob, or open the door said lights will come on.
View 7 RepliesFord 7.3L Power Stroke (1999-2003) :: Brake Lights Went Out
I was told today my brake lights were out. I checked and sure enough none of the 3 worked. I checked bulbs. Good. I checked all fuses. Good. I replaced brake switch on the pedal. Still no lights. What's next?
View 13 RepliesFord 7.3L Power Stroke (1999-2003) :: Running Lights Not Working
A little background information is that I was towing a large gooseneck trailer about a year ago when half way to the destination the lights quit. Not just the trailer but the truck tail lights, turn signals and everything except the headlights. Well after getting there and unplugging everything it stayed the same. Well on the way home without the trailer the lights began working again. All the truck lights acted as it never happened. No blown fuses or anything.
Well things are are going ok since then but I can never get running lights to any of my 3 trailers to work. Turns and brake lights are fine. What gives? All the fuses are fine and the truck running lights work just fine. One thing I have noticed is that on my horse trailer I have the little led lights on the sides operational... I would have assumed these to be the same as the tail running lights.
Ford 7.3L Power Stroke (1999-2003) :: Dashboard Lights Not Working?
I have looked all over the Internet, but I can't find out how to change the lights on the dashboard. I have checked all the fuses. I have no clue have to check the dimmer switch. Though, the over head light does come on when I turn on the switch. All the lights for the check engine and such light up. The dash will not light up during the night. Someone told me that there should be a youtube video or a how to steps. I am very new to fixing my new to me truck. I have checked the how to steps on this forum and a few others.
View 4 RepliesFord 7.3L Power Stroke (1999-2003) :: No Flashers / Brake Lights Or Directional
I have checked all fuses, and swapped flasher from another truck. Could it be combination switch?
View 10 RepliesFord 7.3L Power Stroke (1999-2003) :: Fuse Keeps Blowing Out - No Parking Lights?
i have a 99 f350 psd, my problem is i don't have normal; FONT-SIZE: 100%; COLOR: dark green; FONT-FAMILY: inherit">parking</NOBR> and instrument lights, it blows fuse number 8 as soon as i turn the switch on. i checked all the wiring on my tail lights and the trailer hookups. i even disconnected the wiring harness going my tail lights and trailer hookups and it still blows the switch. #8 fuse is trailer tow electronic brake, illumination, park lamps, trailer tow park lamp relay coil. it also blows #4 fuse which is trailer tow backup lamps, trailer tow park lamps.
View 14 RepliesFord 7.3L Power Stroke (1999-2003) :: +12v Source That Turns On With Reverse Lights?
I'm wiring a backup camera and I need to energize a wire with +12v source that turns on when the truck is placed into reverse.
If I can connect the wire to 12v which automatically energizes when the truck is shifted into reverse, the backup camera will turn on automatically.
Surely I could pull the signal from the reverse lights, but I'd like to find something in the fuse panel because that is where the wire terminates and I'd rather not extend it all the way to the reverse lights on the back of the truck.
Where's a +12v source in the fuse box area under dash that energizes when the truck is put into reverse?