Ford 6.0L Power Stroke Diesel :: 2006 F250 - Water In Fuel / Check Engine Light Came On
I have a 2006 f250 with 120k. I am having trouble getting the water in fuel light off. I drainned the water out and replaced both filters and the fuel water sensor. The check engine light is now on and the water in fuel light is as well. I'm stumped and can't figure out what to do next. Will the check engine light come on as well with the water in fuel light or is it two different problems?
View 2 RepliesFord 6.0L Power Stroke Diesel :: Water In Fuel Light On After Changing Fuel Filter?
Changed fuel filters today. Now my water in fuel light is coming on. But the truck is not running any different no sputtering or anything. ????? Could this be human error
View 14 RepliesFord 6.0L Power Stroke Diesel :: Water In Fuel Light Came On?
My water in the fuel light came on for the first time since I have owned the Excursion, which is a little over a year. Only thing i have done different is Monday this week i put in some hot shot diesel fuel additive to try with stiction. Dothe additive is the cause of the light to come on?
View 2 RepliesFord 6.7L Power Stroke Diesel :: Water In Fuel - Warning Light Came On
Not another dumb "water in fuel" post... I had the warning light come on the other day, so I got under to drain the filter. Not much water came out before the diesel, but I let some diesel drain anyway to be sure. What was strange though, was the electrical connection was off. I must have hit something somehow and pulled it out? What I'm wondering, because of the little water that came out of the filter, would the light have come on from the plug getting pulled out?
View 14 RepliesFord 6.0L Power Stroke Diesel :: 2004 - Water In Fuel Light
2004 6.0 and I put in a new WIF sensor and took off the cover and cleaned the junk out but it still comes on after a minute or 2. What am I missing??
View 3 RepliesFord 7.3L Power Stroke (1999-2003) :: New Fuel Bowl Drain / Water Separator Failure After 3 Weeks?
Had the ole factory fuel separator/bowl drain start leaking on me about a month back. So i ordered and installed a new one, issue fixed. Well last night the fuel leak started again, I looked everywhere and i cant see anywhere else it may be leaking at. I felt the underside of said piece and it didn't feel wet, but the valley is full of fuel.
I got in there and tightened the 4 bolts down some more, they were tight but i got a some turns on em and am hoping i either didn't tighten it down enough or they maybe backed out some. Now just gotta see if that solves the problem, again.... the replacement is a doorman, the o-rings were bigger/thicker than the factory orings on the old part, of which the o-rings were shot.
Like I said once i replaced the part the leak stopped for 3 weeks until last night. If the tightening of the bolts doesn't solve it where should I look next? I have an FRX mod but i checked all that and its dry as a bone around all the fittings by the bowl and the heads. No indications of leaks anywhere around any of the FRX assembly.
Ford 6.0L Power Stroke Diesel :: 2004 F350 - Low Fuel And Water In Fuel Lights Came On
For the last four months my 04 F350 has been having the same problem every now and then. Cruising down the highway at a decent speed and the fuel pedal/fuel shuts off. Only lasts seconds then re-engages. Two lights come on. Low fuel and water in fuel. I changed the internal fuel pump last week and it did it again tonight. The truck runs great otherwise except for an occasional death shake while stopped at a light. No codes came up and FICM is at 54.
View 14 RepliesFord 6.7L Power Stroke Diesel :: Low Fuel / Power Message Then Check Engine Light On
My low fuel light came on tonight. I drove about 2 miles, stopped and shut the truck off. When I restarted it and began to drive off to the fuel station a notice came on that isaid power reduced then a check engine light came on. I was about a mile or less from the fuel station so I filled up. I cycled the key but the engine light is still on. No low power message tho. The power is fine.
I came home and drained the water drain on the filter, didn't see any water but hoped it would solve the problem. I cycled the key a few times and started the truck but the light is still on. My truck is a 2013 f350 6.7 and has 211500 ish miles on it. I bought it a month ago with 18500 miles and haven't had any issue until tonight. My only thought is maybe the fuel filters need changed. I don't know if or when the previous owner changed them.
Ford 6.7L Power Stroke Diesel :: Water In Fuel Sensor
Tonight I changed my fuel filters for the first time. Went well. However, when I was hooking up the WIF sensor connector, it wasn't pushing in very well. I looked and the pins were straight, I kept messing with it. I noticed that the sensor was loose in the housing. It looks like there are about 4 tabs that hold the end of the sensor in the housing. When the end of the sensor came off, one of the two springs and 0-ring popped out. I managed to find them and re-assemble it. Is this a normal occurrence? Do I need to order a new housing? If it falls apart and I get a WIF message, is there any type of de-rate that happens or can I keep driving?
View 1 RepliesFord 6.7L Power Stroke Diesel :: Checking Water In Fuel?
How do you tell if there is water fuel drain plug check area ? Fuel always looks the same to me.
View 14 RepliesFord 6.7L Power Stroke Diesel :: Disposing Of Fuel / Water Mix
OK, after I drain the fuel/water dohickey, what do I do with the waste? Pour it in my neighbors garden, on the railroad tracks, in my waste oil container or other (be specific)? Also what should I use as this collector, a small piece of Tupperware?
View 6 RepliesFord 6.7L Power Stroke Diesel :: Water In Fuel Indicator Is On
The dreaded "water in fuel" indicator is on! I'm traveling an hour south of me in the blizzard and the WIF indicator goes on. I immediately pull over and crawl under the truck to find the wiring to the sensor disconnected!!!(I just had Ford service the vehicle Monday!) I plug it back in and no change. After 50 miles or so the truck goes into reduced power mode. I get home and ride out the storm. After cleaning up the snow I get under the truck and disconnect, clean, and re-install connector on the sensor. Drain fuel from bowl.....not a drop of water. Restart truck...still no change. I know there's no water but now what?
View 14 RepliesFord 6.7L Power Stroke Diesel :: Water In Fuel Warning
I was about 2 miles from my home today when the Water In Fuel Warning appeared on the dash. I drove home and got everything read to drain the water separator. I crawled under the truck and the wiring harness was unplugged from the filter housing and wrapped around the rest of the harness. I just last week had both fuel filters changed during a routine oil change.
It appears the dealer left the wire unplugged. I drained some fuel just to be safe and as expected found no water. I plugged in the wire and started the truck. The warning went away. Here is my question: Has this event set some stupid bit or trigger in the ECM that Ford can use later to deny a claim? I called the dealership and talked to a tech who said "no". The service manager is supposed to call me tomorrow.
Ford 6.0L Power Stroke Diesel :: 2005 - Fuel System Codes / Glow Plug Circuit Failure
So i just finished putting in new high pressure oil rail cup seals in and a new #2 injector. Truck was running great for about 5 miles and then just shut off. When I had it towed home I plugged in the super chips tuner "no tunes installed" and I have a p0460, p0463, p2290, p2291. I also have a #7 glow plug circuit failure Ive been a little neglectful in getting done.
View 6 RepliesFord 6.7L Power Stroke Diesel :: Draining Fuel Water Separator
Anyway, Just bought a used 2015 F350. I want to drain the water separator as the dealer can't tell me when it was done last. Anyway, I read how to do it, but once you drain it, what do you do with the diesel that drains out with?
View 14 RepliesFord 6.0L Power Stroke Diesel :: 2003 - Gasket For Fuel Water Separator?
What is the part number for the gasket that goes on the water separator on a 2003 6.0 diesel.
View 6 RepliesFord 6.0L Power Stroke Diesel :: EGR Failure - Wrench Light Comes On
So I have a 2006 Ford F-250 6.0 that broke down about 2 months ago due to an EGR failure. Took it to the dealership got it fixed along with a new injector everything has been running fine only thing I notice is a big split in EOT and fW(218 EOT and 192 fWT). Well yesterday on the way home my wrench light comes on I tried to scan it with the scan gauge but it said no codes found and when I got home and turned the truck off and back on the light went off. What could cause this?
View 11 RepliesFord 6.0L Power Stroke Diesel :: 2006 - Water In Fuel Warning Kept Coming On The Dash
On my 2006 6.0 the water in fuel warning kept coming on the dash. After going draining a few times and a few tanks later I knew something wasn't right so I bought a new sensor. When I pulled the old sensor out, it was full of gunk that was like a white jelly. I probably could have just cleaned the old sensor but I put the new one in anyway. My issue went away for a few months when the WIF alert came back. I pulled the sensor out again and sure enough it was gummed up. I've decided to pull that little panel door off and clean the inside. I have a few questions:
1) Can that oring be purchased separatly?
2) Can I just reuse my oring if it still looks good?
Ford 6.7L Power Stroke Diesel :: Water In Fuel / Drain Filter Warning Message Came On
During a heavy rain the "water in fuel, drain filter" warning came on. I drained the filter like suggested and a water bottle full of water drained out. This is less then a week after I had the titan fuel tank installed. After I drained the fluid I restarted the engin and "reduce power an water in fuel" warning came on. I am 250 miles from the nearest ford dealer. How major is this???
View 12 Replies