Ford 6.7L Power Stroke Diesel :: Water In Fuel Warning
I was about 2 miles from my home today when the Water In Fuel Warning appeared on the dash. I drove home and got everything read to drain the water separator. I crawled under the truck and the wiring harness was unplugged from the filter housing and wrapped around the rest of the harness. I just last week had both fuel filters changed during a routine oil change.
It appears the dealer left the wire unplugged. I drained some fuel just to be safe and as expected found no water. I plugged in the wire and started the truck. The warning went away. Here is my question: Has this event set some stupid bit or trigger in the ECM that Ford can use later to deny a claim? I called the dealership and talked to a tech who said "no". The service manager is supposed to call me tomorrow.
Ford 6.7L Power Stroke Diesel :: Water In Fuel - Warning Light Came On
Not another dumb "water in fuel" post... I had the warning light come on the other day, so I got under to drain the filter. Not much water came out before the diesel, but I let some diesel drain anyway to be sure. What was strange though, was the electrical connection was off. I must have hit something somehow and pulled it out? What I'm wondering, because of the little water that came out of the filter, would the light have come on from the plug getting pulled out?
View 14 RepliesFord 6.0L Power Stroke Diesel :: 2006 - Water In Fuel Warning Kept Coming On The Dash
On my 2006 6.0 the water in fuel warning kept coming on the dash. After going draining a few times and a few tanks later I knew something wasn't right so I bought a new sensor. When I pulled the old sensor out, it was full of gunk that was like a white jelly. I probably could have just cleaned the old sensor but I put the new one in anyway. My issue went away for a few months when the WIF alert came back. I pulled the sensor out again and sure enough it was gummed up. I've decided to pull that little panel door off and clean the inside. I have a few questions:
1) Can that oring be purchased separatly?
2) Can I just reuse my oring if it still looks good?
Ford 6.7L Power Stroke Diesel :: Water In Fuel / Drain Filter Warning Message Came On
During a heavy rain the "water in fuel, drain filter" warning came on. I drained the filter like suggested and a water bottle full of water drained out. This is less then a week after I had the titan fuel tank installed. After I drained the fluid I restarted the engin and "reduce power an water in fuel" warning came on. I am 250 miles from the nearest ford dealer. How major is this???
View 12 RepliesFord 6.7L Power Stroke Diesel :: Shuts Down While Driving - Low Oil Warning Came On?
My truck is still fairly new with 4,600 miles. I took my family on a camping trip and pulled my trailer which is about 7800 LBS. I made multiple hill climbs and mentioned to my wife how well the truck does on the hills pulling the trailer then a minute later the truck jolts and a "low oil" warning light flashed on the dash. By that time the truck had already shut down and I was coasting to the side of the road. At least I still had the ability to steer until I hit about 2 mph then the truck completely shut down. I could smell burning oil or something similar coming from the engine area.
I knew I had plenty of oil because I had just checked it hours before. I got out and checked it again and was still full. After standing there for several minutes starring at the truck I realized that our big yearly trip up North to the redwoods was over. I tried to start the truck again and it just turned over but wouldn't start. Nothing was smoking or appeared to be leaking. So I started to look for the Ford tow truck number. While looking for the number I tried to start it again and it started! I drove it about 3 minutes down the road to a gas station and called the dealer. They of course said never heard of the issue. Have the truck and trailer towed in to the nearest dealer. Well decided I wasn't going to do it since I was already in the middle of no where and the truck was driving fine. I wasn't going to ruin our big trip over this so I drove it. I figured if something failed at least they could fix it and not tell me they can't duplicate the issue after 3 days. The truck drove fine the rest of the way there.
It happened again coming home. While climbing another hill in the middle of a 2 lane canyon with no shoulder and no cell service. Luckily, I coasted a few hundred yards to the only turn out I saw in a mile stretch. Once, again it showed "Low oil". I let the truck sit for 5 minutes and it started. Drove it another 5 hours home with no issues. I monitored all my gauges during this time none showed over heating. So in summary, truck shows "low oil" warning then shuts down and restarts minutes later. I will be taking it in to the dealer soon but I'm expecting the standard can't duplicate the problem.
Ford 7.3L Power Stroke (1999-2003) :: 2001 F350 Diesel - Engine Just Randomly Shuts Off Without Warning While Driving
My 2001 F350 7.3 dually diesel Automatic has been a pretty good truck but recently it has been dying. Engine just randomly shuts off without warning while Driving. Check engine light comes on sometimes. Some of the time it will restart if I cycle the key. Once its running again I can rev the engine up without a sputter but after a few hundred yards down the road it will die again. I noticed driving on the highway when it does it my truck will buck first, then...
If I leave it in drive with the key in the run position when it dies and I'm coasting down the highway the Tach starts jumping around like its trying to restart itself, all on its own. I don't have a scanner.
The last time it died I coasted into my driveway and it wouldn't restart, went back out there 30 minutes later and it fired right up. Its only 40 degrees here if that matters, not hot by any means.
Ford 7.3L Power Stroke (1999-2003) :: How To Turn Off Water In Fuel Light Warning
I have a 2001 F250 (Platinum Edition). I purchased about a year ago. The water in fuel light came on. I ran an additive to remove water and changed the fuel filter several times. Light still on. How to turn it off? I missing something? Only fuel filter I see sits on top of engine...
View 14 RepliesFord 6.7L Power Stroke Diesel :: What Water And Oil Temp Is Too Hot
I recently observed coolant temps of up to 217 degrees as reported by my mini max and oil of 230 as reported by the dash while towing 9000 pounds from San Diego to Las Vegas on the 15 going up the 16 mile mountain grade. My temp gauge on the dash never moved a bit, it stayed in the same spot from 199 to 217 so I assume its not too hot. My mini max defuel setting has the coolant temp at 220? I slowed down and tried to keep it under 210.
View 8 RepliesFord 6.0L Power Stroke Diesel :: How To Remove Water Pump
I'm replacing my water pump and was wondering how to remove this.
View 3 RepliesFord 6.7L Power Stroke Diesel :: Water In Fuel Sensor
Tonight I changed my fuel filters for the first time. Went well. However, when I was hooking up the WIF sensor connector, it wasn't pushing in very well. I looked and the pins were straight, I kept messing with it. I noticed that the sensor was loose in the housing. It looks like there are about 4 tabs that hold the end of the sensor in the housing. When the end of the sensor came off, one of the two springs and 0-ring popped out. I managed to find them and re-assemble it. Is this a normal occurrence? Do I need to order a new housing? If it falls apart and I get a WIF message, is there any type of de-rate that happens or can I keep driving?
View 1 RepliesFord 6.7L Power Stroke Diesel :: Checking Water In Fuel?
How do you tell if there is water fuel drain plug check area ? Fuel always looks the same to me.
View 14 RepliesFord 6.0L Power Stroke Diesel :: Water / EOT And ECT Temp Difference
Looking at another 6.0. It's an 2005 with 156k. When test driving it on the scan gauge water temp stayed around 160 and don't believe it ever went above 170 if it even made that. Bad t-stat? Or a more significant issue? The other issue I seen that concerned me, is cruising at 65 for 10 minutes plus to check deltas their was up to a 20 degree difference so I'm thinking plugged oil cooler and bad egr cooler. Temps were 190 eot and maybe 170 ECT. Wasn't sure if the water temp issue affected the results on this reading or not.
View 14 RepliesFord 6.7L Power Stroke Diesel :: Disposing Of Fuel / Water Mix
OK, after I drain the fuel/water dohickey, what do I do with the waste? Pour it in my neighbors garden, on the railroad tracks, in my waste oil container or other (be specific)? Also what should I use as this collector, a small piece of Tupperware?
View 6 RepliesFord 6.7L Power Stroke Diesel :: Water In Fuel Indicator Is On
The dreaded "water in fuel" indicator is on! I'm traveling an hour south of me in the blizzard and the WIF indicator goes on. I immediately pull over and crawl under the truck to find the wiring to the sensor disconnected!!!(I just had Ford service the vehicle Monday!) I plug it back in and no change. After 50 miles or so the truck goes into reduced power mode. I get home and ride out the storm. After cleaning up the snow I get under the truck and disconnect, clean, and re-install connector on the sensor. Drain fuel from bowl.....not a drop of water. Restart truck...still no change. I know there's no water but now what?
View 14 RepliesFord 6.0L Power Stroke Diesel :: Water In Fuel Light Came On?
My water in the fuel light came on for the first time since I have owned the Excursion, which is a little over a year. Only thing i have done different is Monday this week i put in some hot shot diesel fuel additive to try with stiction. Dothe additive is the cause of the light to come on?
View 2 RepliesFord 6.0L Power Stroke Diesel :: Water Separator Light Has Been Coming On And Going Off
Well, my water separator light has been coming on and going off for the past week. Today, I finally thought about it while drinking a beer, and decided I'd pull the plug to see what I can catch.
As you can see from the pictures, this brownish color crap comes flowing out, followed by clean fuel. What it is? I've drained the separator in the past, but never have I seen this come out.
Ford 6.7L Power Stroke Diesel :: 2013 - Water Pump Leaking?
2013 6.7..46k miles.
I know we have crappy radiators. that's why I bought the premiumcare plan. had that replaced at 45k..200 miles later smelling coolant. take it in they say the water pump is leaking from a "weap hole"...great...get it back..still smell coolant. very fricken frustrated. Not what I expect from a 45,000 dollar truck. especially a 2013....
Ford 6.7L Power Stroke Diesel :: Draining Fuel Water Separator
Anyway, Just bought a used 2015 F350. I want to drain the water separator as the dealer can't tell me when it was done last. Anyway, I read how to do it, but once you drain it, what do you do with the diesel that drains out with?
View 14 RepliesFord 6.0L Power Stroke Diesel :: 2004 - Water In Fuel Light
2004 6.0 and I put in a new WIF sensor and took off the cover and cleaned the junk out but it still comes on after a minute or 2. What am I missing??
View 3 Replies