Ford 7.3L Power Stroke (1999-2003) :: 2001 F350 Diesel - Engine Just Randomly Shuts Off Without Warning While Driving
My 2001 F350 7.3 dually diesel Automatic has been a pretty good truck but recently it has been dying. Engine just randomly shuts off without warning while Driving. Check engine light comes on sometimes. Some of the time it will restart if I cycle the key. Once its running again I can rev the engine up without a sputter but after a few hundred yards down the road it will die again. I noticed driving on the highway when it does it my truck will buck first, then...
If I leave it in drive with the key in the run position when it dies and I'm coasting down the highway the Tach starts jumping around like its trying to restart itself, all on its own. I don't have a scanner.
The last time it died I coasted into my driveway and it wouldn't restart, went back out there 30 minutes later and it fired right up. Its only 40 degrees here if that matters, not hot by any means.
Ford 6.0L Power Stroke Diesel :: 2004 Truck Randomly Shuts Off While Driving
04 with 170k miles. truck runs fine. every now and then truck shuts off while driving. turn it off the it restarts every time. Only code that comes up is number 6 injector. The contribution test injector is firing right. FICM voltage is 47.5. has new ipr and hpop also 6k miles ago. Could it be number 6 shorts out or something crazy killing truck? or maybe a crank sensor.
View 14 RepliesFord 6.0L Power Stroke Diesel :: Truck Shuts Off Abruptly While Driving Or Idling
Yesterday, my truck began to shut off abruptly. Under every condition, from idling to slow running (30mph), and 70 mph, to load and no load. Wait 1 minute and it would start and run for 1 minute 15 seconds. If the batteries were disconnected, the truck would run for 13 minutes before shutting off. Have replaced the fuel filters. Still does it, but runs for between 10 and 20 minutes before shutting off.
Am seeing only two errors codes. P1000, and P0603. I was 40 miles into the Ville Vidal, when this started, and 150 miles from home. To get home, I disconnected the batteries too many times to count, and bled the HFCM numerous times. Am also seeing the moisture in fuel icon on teh dash light up when it quits, but so far as I can tell there is no moisture in the separate.
2003 F450 6.0, automatic. 150K miles.
Ford 6.7L Power Stroke Diesel :: WIF Warning While Driving In Water
Today I was on the beach and I had to drive through some standing water about 4 inches deep. I went through without a problem and noticed my WIC light came on. I unplugged the sensor, drained the filter(which had no water) and drove home. On the way home the light went off, I didn't experience any limp mode, etc...
View 14 RepliesFord 6.0L Power Stroke Diesel :: Crank And Get It Fired Then Shuts Down
I was driving home and my dash shut off and motor then came back on. Thought to my self hmm not good. Then she did it again. Then thought well that will be hard to find if it only does it two times. I will fix it when it happens more would be easier to find. Then off and coasting down the road. Now on the side of the road. But from what I can till now it seems like my pcm is not getting power. I was able to crank and get it fired then shuts down and will crank but keeps kicking the starter out.
Now it will not crank lift pump not running and injectors not doing there pretty firing sound. I don't have anything to check fuses with me just going to tow it to my shop and look at it tomorrow. But the fuse panel is not label at all so is there print out I can get of that? I'm a diesel tech so I'm not really to worried. Can't pull codes or Talk with my sct programmer so makes me think. ecm no power or fried,
Ford 6.0L Power Stroke Diesel :: 2005 F250 Shuts Off On Its Own For No Reason
This has happened twice now, both times immediately after towing. I'll start it, begin to accelerate, and it will just putter out. It'll start right back up but it'll putter out again. After 20-30 minutes it'll start (and run). I have an edge programmer and it doesn't turn on when this happens. I get a turbo warning on it that the psi is at like 43/46 even though I'm essentially at idle so it seems to be getting a faulty error thinking the turbo is under too much load.
View 6 RepliesFord 7.3L Power Stroke (1999-2003) :: 2002 - Suddenly Shuts Down While Driving
This started about 6 weeks ago. While sitting at a stop light the motor cut out. After some research I replaced the cps. Truck ran fine for about 3 weeks, then shut down again while pulling into the driveway of a store. Replaced the cps again (this time with a ford one). Ran fine for another 3 weeks, then shut down again on the freeway. No CEL on any occasion.
It's just like someone turned the key off. No rough idling at all. No smoke during starting or driving. When it shuts down, it will not start again for 20-30 minutes, no matter how many time you crank it. It will just turn over, no sputter. When it fires up again there is no air in the lines either, it runs like nothing happened.
I'm now thinking it might be a ipr issue...is there a way I can check myself or does it need to go to the mechanic? Or is it something completely different? This is my mother in laws daily driver, 178k. She does not drive on the freeway, 80% of the mileage is city driving. What could be going on?
Ford 6.0L Power Stroke Diesel :: 2006 Truck Shuts Off In A Hard Pull
I have a 2006 that shuts off in a hard pull, if I wait 3 minutes it starts again. I hooked up my scan tool and when it dies and I crank it it only builds 200psi oil pressure, let it sit it builds enough pressure to run fine. If I dont push it over 3500psi for more than minute it wont die pull a hill it dies again. Is it the hpop or an o-ring.
View 10 RepliesFord 6.0L Power Stroke Diesel :: 2004 F350 - Buzzing After Truck Shuts Off
2004 f350 after i shut the truck off something was buzzing. So I popped the hood and found its the injector harness or injectors.Is this normal or something I need to look into?
View 3 RepliesFord 6.0L Power Stroke Diesel :: 2003 F250 Turns Over / Starts And Immediately Shuts Off
I have an 03 f250 that i think is getting air in the fuel line when it sits. It turns over starts and immediately shuts off. Then i have to crank it for a minute or so before it will start. After that it is good all day. Next day it might sputter on start but stays on. More than a day it shuts off immediately and needs cranking for a minute...
View 13 RepliesFord 6.0L Power Stroke Diesel :: 2005 F250 - Battery Light Comes On / Engine Shuts Off Seconds Later
Last week my battery light came on for the first time in years. I have a 185 amp DC Power alternator after dealing with so many bad oem ones.
Anyways, battery light came on when i pulled up to a stop sign. I proceeded to plug my sct x4 in to see what the voltage was, with the battery light it was 11.50. I shut the truck off started it back up, no light and voltage was 13.7. Went through the stop sign got into some more traffic, started to accelerate again and this is when the truck shuts off for the first time. Put it in neutral, and it started right back up.
Several days later it shut off on me two times back to back. It was a cold start, and both times the battery light was on and the truck would die within 30 seconds. Third start it kept running fine.
This past Saturday morning battery light was on, let it idle for awhile then as i tried to park it in the garage it shut off. Started it up, no light so it ran fine. Later when i started the truck it shut off again. So it has shut off on me 5 times in the last week.
Some more background on the truck:
2005, 199k miles
Well maintained (T6 every 5k, filters every 15k, etc.)
The injectors are going bad, it started running rough saturday 1/9/16, just a couple days before it started shutting off.
I used to a sct x4 to pull codes, i have p2237 (if i remember right) which is an intermittent icp signal. I replaced the pigtail and icp less than a year ago because of the same code.
And three codes for glow plug solenoid open on 5, 6, and 7.
No ipr codes
Ford 6.0L Power Stroke Diesel :: 2005 F250 - Truck Shuts Off For No Reason / Codes P0606 And P0341
I have a 2005 f250 just hit 180k last week and it has the 6.0 in it, egr deleted, sinister diesel oil cooler, stc livewire tuner with street tune installed, air raid air intake. Wicked wheel 2 in the turbo. Its throwing codes P0606 and P0341. Cam sensor has been replaced and the other code is a mystery to me. Its been randomly shutting off like you turned off the ignition all day today.
When it stalls it takes 3-4 times to get it fire back up. When you first go to start it the pressure gauge reads 0 but once it fires up it says theres pressure. Also some of the days it never stalls and runs like a champ but other days i cant drive more the 10 feet and then it stalls. I have no idea whats going on with this truck and ive put lots of money into it doing customization and stuff like that so I am hoping that its not on its last leg....
Ford 6.7L Power Stroke Diesel :: DEF Warning Will Not Go Out
I have searched this problem and seen where some have vapor locked or whatever. Tried banging on the tank squeezing the hose etc. Last time warning came on I pulled in and tried to fill it up and it only took between 2 and 2.5 gallons. However the warning went away. This time same thing I know it has not been long enough for another fill maybe 2k miles. So I pulled in again and got just under two gallons in it.
Warning did not go out came home got on here and learned about above mentioned problem and solutions so went to Walmart and got a bottle. Tried to force feed it while tapping on tank and squeezing hose but probably not even a half gallon and still have the warning. I drive a lot so the 455 miles I have left wont last me long. I picked it up 10/23 with30 miles on it and I am right at 30k now. So am I stuck going to the stealership?
Ford 6.7L Power Stroke Diesel :: Reduced Engine Power Warning Message Pop Up
I have seen this pop up on the truck I think 3 times now over the first 4000 miles on the truck.
Usually it's when I'm on the highway around 70mph or so.
It comes on for a few seconds, then goes away. I do have an exhaust / tune on the car.
Ford 6.7L Power Stroke Diesel :: Reduced Engine Power Warning
Getting reduced engine power warning with no other lights on the dash and what is probably causing it. The truck is a 14 f450 cab and chassis model. I had just had it to the dealer for this problem and the check engine light was on and the said there were two sensors going bad on the exhaust so they changed them out and sent me on my way. Well after driving the truck around all day and not one issue it had just decided to set the rep warning again but did not set off any lights...
View 7 RepliesFord 6.7L Power Stroke Diesel :: Reduced Engine Power - Warning
Reduced Engine Power warning and fuel leak? While towing our 37 Fiver uphill a couple of days ago, the warning popped up along with the CEL. Indeed, the truck did lose a tremendous amount of power. When I found a safe place to stop, the diesel smell was terrible. Further inspection revealed that fuel was dripping down the side of the engine from somewhere above the oil filter. I limped along another 15 miles to the campground and unloaded the 5<SUP>th</SUP> wheel and brought the truck in to the dealer this morning. They aren't giving many details of their findings thus far. They say that they've talked to Ford engineers and that they'll have to put a dye into the fuel to detect the origin of the leak. They suspect the high pressure fuel pump, but by the time they remove enough "stuff" to get to the pump, they can't run the engine to witness the leak. This is my first Ford in 30 years behind the wheel and my first diesel. After 8k miles on the truck.....
View 14 RepliesFord 6.7L Power Stroke Diesel :: CEL / Low Fuel Pressure Along With Reduced Engine Power Warning
I just had my first fuel filter change (about 9,000 miles). After the shop changed both fuel filters with factory Ford ones, a check engine light came on and a "low fuel pressure" warning, along with a "reduced engine power" warning. It also stalls a lot and takes a long time to restart.
Obviously, they didn't do it right. I suppose there is air in the lines or something didn't go back together correctly.
My '06 seemed to purge itself, but this truck obviously won't. It is not even driveable to get it back to the station, to see if they can correct the problem.
The thing is, I watched them do it, so if someone can ask me the right questions as far as what I saw, maybe I can lick the issue in the driveway myself.
Ford 6.7L Power Stroke Diesel :: Changed Fuel Filters - Reduced Power And Low Pressure Warning
Changed the fuel filters. No issues in replacing.
Primed them by the book - key on 30 seconds 6 times
Now I have low pressure warning and reduced power.
All parts were FOMOCO...
Ford 6.7L Power Stroke Diesel :: DEF Warning Not Resetting
I purchased a 2011 F350 with the 6.7 with 65000 miles on it about a couple of months ago. I have put about 3000 miles on it so far about 600 of those pulling a 30' 5th wheel. Today my 800 mile DEF warning came on so I picked up a 2.5 gallon jug and it took all of it. The last little bit went really slow so I figured it was full. I had some running around to do and the warning did not reset after about 15 miles and 3 start and stops on the engine. I read that they really need to be topped off completely do I grabbed another 2.5 gallon jug and was able to get about another gallon in. I then drove it for about 10 more miles stooping and starting 2 more times. The warning has still not gone away. Do I just need to wait a little longer or is this an indication of something I need to be worried about?
View 10 Replies