Ford 6.7L Power Stroke Diesel :: Coolant Level In The Primary Tank Low
2012 6.7 .... Noticed my coolant level in the primary tank was low. Thought it was totally empty but it had about a half inch left in it. Topped it off and also needed about a quarter inch in the secondary. I would say about a half gallon between the two. Truck was at about 36k. Has 37.5 on it now and haven't noticed any loss. Never smelled anything, no signs of any leakage. Oil looks fine. Is this 'normal'? Owners manual says to check and add. Never had this with a gasser or any of my tractors over the past 30 years. This is my first light diesel.
View 14 RepliesFord 7.3L Power Stroke (1999-2003) :: Oil In Coolant / Oil Level Drops But Coolant Level Stays The Same
My friend bartered for a '99 F250, 2wd/auto, 4 door, 7.3, 258k miles.
It had reportedly sat for one year, though the expired registration sticker and other things point to it sitting for two.
It ran low on oil, sputtered and died. Oil in the degas tank. Filled to oil to mid way on the hatch marks on the dip stick.
I drove it 25 miles to my house, and the oil level is not reading on the dip stick.
The sludgy fluid level in the degas tank is unchanged. Where is the fluid going?
I will refill the oil to see just how much it lost in the 25 miles if it important to someone, but I prefer to not waste the oil.
My first plan is to remove, inspect and replace the oil cooler o-rings. Even though the dealership charged him for this, I don't trust that they did it right. I think it is the easiest and mostly likely place for oil getting into the coolant.
It does have a really long crank before there is enough low pressure oil for it to start. At the moment I think this is a separate issue.
The dealership also charged him for a replacement injector. No idea if they replaced the cup or not.
Ford 6.7L Power Stroke Diesel :: Charge Primary Battery Or Both?
If I had to charge the batteries, Do you charge only the primary battery or do you charge both?
View 4 RepliesFord 6.7L Power Stroke Diesel :: Primary Radiator Leak / Small Drip From Front Driver Side
I have approximately 66,000 miles on my 2013 F250 truck and noticed a small drip from the front drivers side around 40,000 miles. That random drip is now a leak and the truck will be going into the shop to replace the Primary Radiator.
I absolutely love this truck, but what a disappointment that this isn't a recall. What scares me is that my buddy who has a 2014 F250 will be going in for his second primary radiator in 3 years of ownership.
Ford 6.7L Power Stroke Diesel :: Engine Oil Level High
My engine oil level is reading three inches above the full mark on the dip stick. Do you think there could be diesel fuel or water in the oil system? Notice that the dip stick is not that easy to read. Could this be related to my poor fuel mileage? It can't be doing my engine any good.
View 14 RepliesFord 6.7L Power Stroke Diesel :: Tailgate Won't Sit Level When Opened?
I have noticed that the tailgate doesn't sit level when opened, the cables are too short for it to horizontal. The rear of the gate is 1-1/2" higher than the front. The cables need to be about a 1/2" longer for it to sit right.
View 14 RepliesFord 6.0L Power Stroke Diesel :: Engine Coolant Blowing Out Of Coolant Reservoir
I have coolant blowing out of my coolant reservoir when ever i hold it to the floor it does it with or without the banks programmer... 6.0L power stroke...
View 14 RepliesFord 6.0L Power Stroke Diesel :: Front Of Truck Covered In Coolant - No Coolant Pressure - Fix?
Well got home and the front of the truck was covered in coolant. I must have driven 2 hrs after I noticed no coolant pressure, but temperature was great so figured it was another crappy cap. Looking to get a quick turnaround. Need to go out of town for work Saturday so I have this week to get it done.
Just put a stock unit back in? I don't think I need to do anything else in that area. Belt/pulleys/radiator all done last spring.
Ford 6.0L Power Stroke Diesel :: Coolant Flush With Thermostat And Coolant Filter Install
This weekend my friend and I plan on doing a coolant flush, new Mishimoto thermostat housing with high temp thermostat and install a Mishimoto coolant filter.
Truck currently has some unknown green coolant in it and Im going to replace it with Rotella ELC. I plan on doing a couple hose water flushes then follow with about 5 distilled water flushes. I've been reading about putting some Cascade in on first flush to dissolve any silicate goo that might be in there hanging out. I might give that a try. Im sure I can manage this part from all the stuff I read about doing flushes.
This is the part that looks like a little more work involved than the flush. Doing the thermostat kind of worries me because of the tight area in there to work with the fuel line and the EBP sensor being right there. The current thermostat holds temps around 175-185 under normal driving. I bought the new Mishimoto thermostat housing with the high temp thermostat installed in it when they had their pre sale going on for the housing.
I decided to just go with the whole thing because of all the stuff I read about people having issues with the thermostat not fitting the older housing correctly since Im certain I have the original housing from 2004, like everything else that's still original on my truck. I plan on removing the thermostat before doing the flushes and then installing the new housing and thermostat and coolant filter before I add the ELC.
The coolant filter install looks fairly simple to do so I should be ok with that.
Ford 6.7L Power Stroke Diesel :: High DEF Usage / Low Level Warning
I now have about 39k miles on 2011. Along the way I think I have added six 2.5gal jugs of DEF. About 1k miles ago I got the low DEF notice and added a 2.5gal jug and am already back down to 250 miles of DEF! I don't see any signs of a leak with the engine running or not. Dropped it off at the dealership this eve for an AM service appointment.
View 14 RepliesFord 6.0L Power Stroke Diesel :: Checking Oil Level - Napkin Not Wet But Dipstick Is?
I know checking your oil level is a pretty easy thing but I am having a serious issue right now. I checked my oil and my dipstick has oil on it but it isn't leaving the napkin wet. Like there is oil on the dip stick but it just doesn't seem right. Nothing on the ground were I stopped at before I got home. How long will it run without causing damage?
View 14 RepliesFord 6.7L Power Stroke Diesel :: How To Check DEF Level Or DPF Filling Status
OK, I've had this truck one month now, and I like it. I think a full-blown analog DEF gauge (a la Dodge) is silly - it doesn't change that much. But I would like to go into a menu somewhere and simply be able to get a reading (90% remaining, 77% remaining, 15% remaining, etc., etc.) From what I understand the 'system check' function will tell you if the level is below half, or just about empty, and nothing else.
Finally, the DPF. Why can't we see EGT on the "gauge" screen which shows tranny and oil temps? Why can't it tell us what % the DPF is filled? When a passive regen is happening? And at the very least, when an active regen is finished?
As a side question, can the high idle control (SEIC) be actuated in any way other than the upfitter switches, which my truck does not have? I understand RAM trucks can press and hold the cruise control or something to activate it.
Ford 6.0L Power Stroke Diesel :: Brake Fluid Level Sensor
About a week after my wreck I got the Parking brake light and the message brake fluid level low. The fluid level is fine and I read some other threads where people said the vacuum system was connected somehow. I knew the ESOF didn't work so I replaced the broken line and nothing changed, except the ESOF works now.
Anyway I can't for the life of me find a replacement sensor, part number or anything.
Ford 6.7L Power Stroke Diesel :: Remote Start Option Level?
What option level has remote start as standard?
Or is it an add on option?
Ford 6.7L Power Stroke Diesel :: Install 65 Gal Titan Tank Level Sensor Not Working?
Installed a 65 Gal Titan Tank the other day. I Finally got a chance to fill her up all the way.. well as much as i could.
My Level sensor is not functioning and I was only able to put in a total of 160 Liters when it should have been right around 246L.
My question is this : I need to syphon my tank now. Is there anything preventing me from doing that or will a 1/2 hose work?
Ford 6.7L Power Stroke Diesel :: Exhaust System Cleaning Message / DEF Level Is Not Being Depleted
In the last year I've had a NOX sensor fault (dealer repaired) and a DEF heater fault (I replaced). I'm now getting an EGT sensor fail. Every fault is with the same system.
I'm also realizing that while I'm getting the exhaust system cleaning message, my DEF level is not being depleted.
All the dealership wants to do is change out fault codes but I think the true issue is elsewhere.
2011 F250 SD FX4 6.7L (stock)
Ford 6.0L Power Stroke Diesel :: 2007 - Raise Front To Make Closer To Level?
Like the title says, I want to raise the front of my 07 F350 about 2.5 inches to get it closer to level with the rear with out throwing the alignment out of wack if that's possible. Maybe some blocks to go on the front coils? or will I need new front coils that are a bit longer?
'm talking about the FRONT of my F350.
Ford 6.0L Power Stroke Diesel :: 2005 - Fuel Level Back Light And Oil Pressure Gauge Out?
The backlight for my fuel level and oil pressure dash gauges are out. Would that require a simple bulb replacement or if there is something more difficult to replace, i.e. entire panel? The red needles illuminate, it's just the gauges themselves that are dark. The truck is my 05 Super Duty in the siggy.
View 3 RepliesFord 6.7L Power Stroke Diesel :: 2015 F250 Hard To Start When Fuel Level Reached 1/4 Tank
I recently bought a used 2015 F250. When the fuel level reached 1/4 tank it became hard to start. Sometimes up to 6 seconds of cranking to get it to start. I filled it up with fresh diesel and it fired up as soon as I turned the key. A week later the problem returned, this time I was above 1/2 tank. I run the recommended additives, I changed both fuel filters, but it didn't work. I have only had the truck 3 weeks, and it still has a warranty. There are no fault codes, and the truck run great once started. What could be wrong.
View 7 Replies