Ford 6.7L Power Stroke Diesel :: Battery Status Indicator Red?
In the past I've had truck batteries last close up to 9 years but at 59 months one of my batteries is not looking that great. The battery status indicator is red. I checked the level of the side that appears to be leaking and it's ok. I've had no issues with starting and it seems to crank over just as fast as when new.
View 14 RepliesFord 6.0L Power Stroke Diesel :: Filling Up Oil Cooler After Replacement
Is there a way to fill up the reservoir for hpop and cooler after replacement? I didn't want to burn down the starter and kill batteries cranking all day until everything is full. I did the usual upgrades on the motor and about ready to try and get it started up. Where does the oil drain to when filter is removed?
View 3 RepliesFord 6.0L Power Stroke Diesel :: Low Fuel Message After Filling Up At Pump
After filling up today at the pump, the low fuel message is still coming on. My gauge is correct though. How to clear the message. I keep on trying to reset it with the reset button but it doesn't go away.
View 8 RepliesFord 6.0L Power Stroke Diesel :: Truck Struggled To Start After Filling Up - Low ICP
Today the truck struggled to start after filling up, even harder the next time, and now it's in my driveway dead and I have a job at work that requires me to go to Michigan next week that I can't afford to lose. On to the issue...
When cranking, my icp won't go above 400psi now, and I understand I need Atleast 500 to fire off. I'm mechanically inclined but new to diesels, so don't be afraid to dumb it down...can't be cocky when your learning. Where should I start my troubleshooting?
Ford 6.7L Power Stroke Diesel :: Coolant Flush - Additives Required After Filling?
I'm planning on doing the regular scheduled coolant flush but not sure if it can be done without any special equipment.
One dealer said they don't do many diesels but have a machine to do the refill and quoted ~200$. The other does more diesels but hasn't done a flush in a while and quoted ~500$ and said he does it old school by draining everything out and then water flush followed by refilling the systems.
Which one is right? Can it be done in the driveway? Which is the correct coolant for the refill and are any additives required after filling?
Ford 6.0L Power Stroke Diesel :: Truck Will Start Running Really Rough After Filling Gas Then It Will Clear Up
I have an 04 F2 50 with 6.0 with approximately 225,000 miles. I filled up with gas last Wednesday and every so often the truck will start running really rough and then it will clear up. Is it possible to of gotten some bad gas if so what products are out there to clear that up. Could've been injector going bad what are the best products for cleaning injectors. No check engine light on, gauges are good, nothing different on the scan gauge.
View 3 RepliesFord 6.7L Power Stroke Diesel :: 2003 - Fuel Gauge Reads Empty Even After Filling?
Fuel gauge goes back to empty when I fill the truck all the way up. It goes back to full once I have used up 2 gallons ( from 36 gal to 34 ) on my 2012 F350. I also had a similar issues years ago with my 2003 6.0L .....
View 4 RepliesFord 6.7L Power Stroke Diesel :: Engine Oil Level High
My engine oil level is reading three inches above the full mark on the dip stick. Do you think there could be diesel fuel or water in the oil system? Notice that the dip stick is not that easy to read. Could this be related to my poor fuel mileage? It can't be doing my engine any good.
View 14 RepliesFord 6.7L Power Stroke Diesel :: Low Primary Coolant Level
I recently noticed a small bead of coolant on the driver's side of my tie rod coupled with low primary coolant level, so I took it to the dealer expecting to face a radiator issue (50k miles). Instead they said that the lower radiator hose was leaking and recommended replacement. Thinking that we were still headed down the radiator path, I had them do the job.
Upon inspecting the removed hose, I could find no obvious fault, so I inquired further. They clarified that it was the seal which had failed (I guess replacing the entire hose is the fix for this?), that it was contaminants that build up in the coolant which attack the seals, and that I should expect it to happen again if I don't flush the coolant every 10,000 miles (yes, ten thousand).
I asked if he meant to say that I should check the 'coolant additive level' every 10k (instead of 15k) and he again stated that a full flush was necessary every 10k miles and that it was a "maintenance intensive engine." This can't be right.
Ford 6.7L Power Stroke Diesel :: Tailgate Won't Sit Level When Opened?
I have noticed that the tailgate doesn't sit level when opened, the cables are too short for it to horizontal. The rear of the gate is 1-1/2" higher than the front. The cables need to be about a 1/2" longer for it to sit right.
View 14 RepliesFord 6.7L Power Stroke Diesel :: Coolant Level In The Primary Tank Low
2012 6.7 .... Noticed my coolant level in the primary tank was low. Thought it was totally empty but it had about a half inch left in it. Topped it off and also needed about a quarter inch in the secondary. I would say about a half gallon between the two. Truck was at about 36k. Has 37.5 on it now and haven't noticed any loss. Never smelled anything, no signs of any leakage. Oil looks fine. Is this 'normal'? Owners manual says to check and add. Never had this with a gasser or any of my tractors over the past 30 years. This is my first light diesel.
View 14 RepliesFord 6.7L Power Stroke Diesel :: High DEF Usage / Low Level Warning
I now have about 39k miles on 2011. Along the way I think I have added six 2.5gal jugs of DEF. About 1k miles ago I got the low DEF notice and added a 2.5gal jug and am already back down to 250 miles of DEF! I don't see any signs of a leak with the engine running or not. Dropped it off at the dealership this eve for an AM service appointment.
View 14 RepliesFord 6.0L Power Stroke Diesel :: Checking Oil Level - Napkin Not Wet But Dipstick Is?
I know checking your oil level is a pretty easy thing but I am having a serious issue right now. I checked my oil and my dipstick has oil on it but it isn't leaving the napkin wet. Like there is oil on the dip stick but it just doesn't seem right. Nothing on the ground were I stopped at before I got home. How long will it run without causing damage?
View 14 RepliesFord 6.0L Power Stroke Diesel :: Brake Fluid Level Sensor
About a week after my wreck I got the Parking brake light and the message brake fluid level low. The fluid level is fine and I read some other threads where people said the vacuum system was connected somehow. I knew the ESOF didn't work so I replaced the broken line and nothing changed, except the ESOF works now.
Anyway I can't for the life of me find a replacement sensor, part number or anything.
Ford 6.7L Power Stroke Diesel :: Remote Start Option Level?
What option level has remote start as standard?
Or is it an add on option?
Ford 6.7L Power Stroke Diesel :: Install 65 Gal Titan Tank Level Sensor Not Working?
Installed a 65 Gal Titan Tank the other day. I Finally got a chance to fill her up all the way.. well as much as i could.
My Level sensor is not functioning and I was only able to put in a total of 160 Liters when it should have been right around 246L.
My question is this : I need to syphon my tank now. Is there anything preventing me from doing that or will a 1/2 hose work?
Ford 6.7L Power Stroke Diesel :: Exhaust System Cleaning Message / DEF Level Is Not Being Depleted
In the last year I've had a NOX sensor fault (dealer repaired) and a DEF heater fault (I replaced). I'm now getting an EGT sensor fail. Every fault is with the same system.
I'm also realizing that while I'm getting the exhaust system cleaning message, my DEF level is not being depleted.
All the dealership wants to do is change out fault codes but I think the true issue is elsewhere.
2011 F250 SD FX4 6.7L (stock)
Ford 6.0L Power Stroke Diesel :: 2007 - Raise Front To Make Closer To Level?
Like the title says, I want to raise the front of my 07 F350 about 2.5 inches to get it closer to level with the rear with out throwing the alignment out of wack if that's possible. Maybe some blocks to go on the front coils? or will I need new front coils that are a bit longer?
'm talking about the FRONT of my F350.
Ford 6.0L Power Stroke Diesel :: 2005 - Fuel Level Back Light And Oil Pressure Gauge Out?
The backlight for my fuel level and oil pressure dash gauges are out. Would that require a simple bulb replacement or if there is something more difficult to replace, i.e. entire panel? The red needles illuminate, it's just the gauges themselves that are dark. The truck is my 05 Super Duty in the siggy.
View 3 Replies