Ford 6.0L Power Stroke Diesel :: Fan Clutch Stuck In Engaged Position
06 6.0 fan clutch stuck in engaged position. So I changed the fan clutch it doesn't stay engaged anymore. comes on during startup and gives the appearance that the batteries are dying. Stays on for about 10 minutes when first driving then goes off. If I run ac it comes on at every light and it doesn't matter what engine coolant temp or oil temp and they are all within 6 degrees of each other. I'm thinking maybe the AC is a issue or bad sensor somewhere. No codes everything seems to be functioning. When I say comes on it's on high speed roaring.
View 14 RepliesFord 6.7L Power Stroke Diesel :: 2015 F450 - Gauge Not Moving - Tie Rods And Ball Joints Making Noise?
Pulled into the yard today after about a 20 mile haul with my 2015 f450 6.7.
I shut it down after pulling in, from what i knew everything was fine. 20 minutes later i started it codes and lights went off like the four of july. A wrench light, oil light, temp light and maybe even an obama light. The gauges did not even move. I shut it down, let it cool then after starting it only the CEL came on. I bought two new trucks in 2015 and both had front end alignments off. The f450 doors fill up with water when it rains.
One day after a rain I put my seat belt on and the seat belt was soaking wet. The cab corner where the seat belt spools up was full of water. The tie rods and ball joints started making sounds after 20k miles so i checked them to find they didn't have ANY grease in them!!!! The def fill tube broke off driving through a small dip in the road (i heard it pop). My first new truck....glad l have my 96 7.3.
Lexus LX 2008+ :: Third Row Seat Rattle When In Stored Position
I have a rattle coming from the third row seats when they are in the stored position. It is mainly when I hit rough roads and uneven terrain.
View 7 RepliesFord 6.0L Power Stroke Diesel :: Loss Of Power When Driving Or Leaving From A Stopped Position
I have searched and the only thing close is bad sensor for water in fuel light but it does not say they lost power. When driving or leaving from a stopped position, if I put any extra load on engine by pressing on accelerator pedal fast the water in fuel light comes on and the glow plug light comes on and the truck loses all power. Not 12V power just engine power. I have to let off the pedal and the lights go out and I have power again. Until I press the pedal hard again and it does it again. I have drained the filters and replaced them and still the same.
View 14 RepliesFord 6.0L Power Stroke Diesel :: Engine Will Not Shut Off When Key Is In Off Position
I am working on a 2007 F350 ambulance for a volunteer fire department. It run great, even with the key turned off sometimes. This is an intermittent problem. About every 10 times it is used the engine will not shut off when you turn the key off. The instrument cluster turns on and off as normal. The other odd part is if you leave the key in the off position when the engine does not turn off the RPM starts going up. I have not left it in off long enough to see how high it would go. It does not have a remote start and never has.
View 6 RepliesFord 6.7L Power Stroke Diesel :: Steering Wheel Position Sensor Replacement?
Replacing Steering Wheel position sensor. How hard of job is it?
View 6 RepliesFord 6.0L Power Stroke Diesel :: Backup Warning Beeper Staying In The Off Position?
Having problems with warning beeper staying in the "off" position?? i am going to try and unhook the battery, but if that doesnt work, then what to do...
View 12 RepliesFord 6.0L Power Stroke Diesel :: FICM And Throttle Position Actuator Faults
Been starting get some faults that seems unrelated other than (I think is the) harness. Intermittent low voltage to the FICM and Throttle position actuator faults (I have a 04). All voltages and battery power is solid as a rock. Watching the throttle during key on and it too will do it's self test intermittently. Looking at the cable and noticed that it seemed to be repaired with black tape in the chaffing areas. Knowing that it went threw the recall of that cable, I was under the impression that it was replaced not repaired. Anyway I would like to know how hard it is to change it and any part numbers would be useful.
View 14 RepliesFord 6.7L Power Stroke Diesel :: All Gauges Sweep Across And Then Go To Normal Position When Turn The Key
I had a '11 and when I turned the key on all the gauges would sweep across and then go to normal position. My '14 does not is that normal ?
View 1 RepliesFord 6.0L Power Stroke Diesel :: Running Rough / Crank Position Sensor Codes
It's an 04 F250 with the 6.0, and has been there about five months now. The backstory I have been given is that it drove in running rough, gave crank position sensor codes, and the CPS was replaced. That was the last time it ran. Since then, it has had the CPS replaced five times, the FICM rebuilt then replaced three times, the engine harness replaced, and spent some time at Ford. It would only show about 30rpm while cranking. The engineer came and looked at it, said it must be the tone ring on the crank and that's it.
Here's where it's at for me: Cranking RPM peaked out at 57, but the fan rpm was about 180 while cranking and it sounded like it was cranking pretty quick. I disconnected the glow plug module, had another guy crank it while I gave it a quick shot of starting fluid, which it caught and started to run on. It sounded like it was running on fuel for a second, then shut back off and now cranks unevenly.
According to the owner this thing has seen lots of starting fluid in the course of diagnosing it, and there were no odd noises before it shut down so I suspect stuck valves from sitting so long. It did give me a whole bunch of codes which I will post tomorrow, including injector #4 high. I tried to do a buzz test but just got a message saying "unknown code, please wait" and then nothing.
Ford 6.0L Power Stroke Diesel :: Coolant Cap Is Stuck And Won't Come Off
My coolant cap is stuck and won't come off? How can I get it off?
View 6 RepliesFord 6.0L Power Stroke Diesel :: 2005 F350 - No Start / Crank Position And Cam Portion Sensor Codes
I have an 05 f350 6.0 that I recently bought. It was fine until a few weeks ago when it died while I was driving down the road. I pulled to the side and it started right back up like nothing happened and kept driving like normal. Skip to last weekend it did it to me twice but the second time it would not start so I plugged my programmer in and it showed p0336 crank position sensor and cam portion sensor codes (I can't remember the number of the second code) I have read a few posts that said maybe it's the icp sensor so I went ahead and replaced that with no luck. The batteries went dead from excessive cranking which I know isn't very good for my starter but I was getting a little upset.
View 11 RepliesFord 6.0L Power Stroke Diesel :: No Power - IPR % Stuck On 89
Yesterday truck starts running like it gas no power and I look and th IPR % is stuck on 89. I finally shut it off started back up and all is well. This sensor was replaced 2 months ago and it's a factory item. What would cause this?
View 2 RepliesFord 6.0L Power Stroke Diesel :: AC Blower Stuck On Full?
I have a lariat (auto climate control) and I just finished reassembling the engine and I noticed that the AC blower goes on full whenever you turn the key on.
According to the AC panel it seems to be off. Where should I start looking? AC is very important here... its already regularly over 100 degrees here.
Ford 6.0L Power Stroke Diesel :: Dash Gauges Are Not Moving / Stuck
2004 f350. Trucks starts, runs, normal. But just noticed the gauges are not moving. Speedo stuck at 50, tach is at idle. Lights up just fine.
Have a code for the fuel sender, had that issue for awhile now, but also have u1262.
Ford 6.0L Power Stroke Diesel :: Stuck On Road / No Start / No Fuel
New to me 05 6L. I bought it out of town and they delivered it today, I picked it up and noticed the fuel gauge was way past empty, no fuel warning light or anything on.
So I mistakenly decided the fuel gauge wasn't working right (they just drove it 200 miles) as theres no way the seller would cut it that close on fuel.
I drove it to insurance place did another errand before I got fuel. Shut it off and it wouldn't start again. Tried it a couple times before it clicked it was out of fuel.
Borrowed a truck and went for fuel. Still no start , took the top off fuel filter , nothing in it. Recycled key 10 times still no fuel?
Ford 6.0L Power Stroke Diesel :: 2006 F350 4x4 Getting Stuck In Snow
I was just wondering, is it normal when plowing to get stuck in the snow? Last year I got stuck and had to get pulled out, yesterday I got stuck again and when I have it in 4x4 hi, one front and one rear wheel spins. 4x4 low, the opposite front and opposite rear spin from hi. I want ALL 4 WHEELS TO SPIN! I'd NEVER get stuck if that happened! How do I get that to happen? I hear of a detroit locker. Do you need one for each wheel? I always thought as I was flying past everyone in the snow with a huge smile on my face, that all of my wheels were powered.
View 14 RepliesFord 6.0L Power Stroke Diesel :: Code P2623 For Stuck IPR Valve
My son is joining the site as we try to diagnose his first diesel. We checked fuel flow, and the bubble test. We held the valve down in the oil filter and watched it fill up in about 10 seconds and see it register on the dash gauge.
My Scan Gauge say it pushes 180 RPM while cranking, but it only gets about 225 on the ICP sensor and the IPR instantly maxes out at 84. It has thrown a code P2623 for a stuck IPR valve.
I hear a hiccup in the crank, but I'll let y'all listen and tell me. Will post YouTube link of it.
What are the chances of it being just a hole in the IPR screen or bad valve? I'm afraid we have a HP leak and need to do the air test to find it. I've never done that test and barely hear (rock concerts), my son hears but doesn't know what to listen for.
Ford 6.7L Power Stroke Diesel :: Tailgate Latch Handle Stuck?
Backed up into a bush and it seems it was a little bit more stout than expected. There was a large branch that pushed my tailgate latch so far up now it's stuck. If you look at the pics below, there's a tab on the right hand side that was over extended and now stuck/holding the handle up. I'm a little reluctant to just try hitting it as hard as i can out of fear that I'll snap something.
View 5 Replies