Ford 7.3L Power Stroke (1999-2003) :: Replacement Of Throttle Position Sensor?
Ford catalog does not list the TPS for a 1999 7.3 Super Duty as a separate replaceable part which leads to replacing the whole throttle pedal assembly. I found this to be incorrect. If you have a throttle pedal assembly with separate TPS (separate 3 wire connector) and IVS (Idle Validation Switch 2 wire connector) just the TPS can be replaced.
This is a pic of my 99 with new TPS installed : [URL] .....
Without removing the whole assembly you only need to remove the 2 T25 screws and the connector to replace.
Since this part is listed for more then 20 Ford trucks I figured it would work in my 99 7.3. I bought a brand new TPS from Pete (F250_) that he could not use. He has a 2002 with one 5 wire connector. It works perfectly in my 99. Not sure if it will work in a 2000 or 2001 but if the TPS and IVS each have their own connector it should. Make a visual inspection to be sure.
Part DY-967 or F4SZ-9B989-AA - Potentiometer
I was going to go with a Dorman TPS but like PartsGuyED likes to say "OEM Baby". The OEM TPS through Ed is actually cheaper then the Dorman.
Side-by-side pic of the old and new TPS. Only the center rotating part is different but it fits and works just fine. It also has a better fit so there is less slop and almost immediate response.
NewOldTPS.jpg?t=1269362105
By the way, the original TPS was working fine so I have no idea what the symptoms of a bad TPS are. Since it was available I replaced it to have a spare and to see if this one would work. Both Pete and I thought it would and we were right.
Ford 6.0L Power Stroke Diesel :: Running Rough / Crank Position Sensor Codes
It's an 04 F250 with the 6.0, and has been there about five months now. The backstory I have been given is that it drove in running rough, gave crank position sensor codes, and the CPS was replaced. That was the last time it ran. Since then, it has had the CPS replaced five times, the FICM rebuilt then replaced three times, the engine harness replaced, and spent some time at Ford. It would only show about 30rpm while cranking. The engineer came and looked at it, said it must be the tone ring on the crank and that's it.
Here's where it's at for me: Cranking RPM peaked out at 57, but the fan rpm was about 180 while cranking and it sounded like it was cranking pretty quick. I disconnected the glow plug module, had another guy crank it while I gave it a quick shot of starting fluid, which it caught and started to run on. It sounded like it was running on fuel for a second, then shut back off and now cranks unevenly.
According to the owner this thing has seen lots of starting fluid in the course of diagnosing it, and there were no odd noises before it shut down so I suspect stuck valves from sitting so long. It did give me a whole bunch of codes which I will post tomorrow, including injector #4 high. I tried to do a buzz test but just got a message saying "unknown code, please wait" and then nothing.
Ford 6.0L Power Stroke Diesel :: Oil Leaking - Cam Sensor Replacement
What is the best way to change the cam sensor on these engines? I believe mine is leaking oil based on some general wetness below it and oil dripping off of the bell housing but I can't find an angle where I can see it clearly let alone replace it. Have to remove the power steering pump?
View 3 RepliesFord 6.0L Power Stroke Diesel :: 2005 F350 - No Start / Crank Position And Cam Portion Sensor Codes
I have an 05 f350 6.0 that I recently bought. It was fine until a few weeks ago when it died while I was driving down the road. I pulled to the side and it started right back up like nothing happened and kept driving like normal. Skip to last weekend it did it to me twice but the second time it would not start so I plugged my programmer in and it showed p0336 crank position sensor and cam portion sensor codes (I can't remember the number of the second code) I have read a few posts that said maybe it's the icp sensor so I went ahead and replaced that with no luck. The batteries went dead from excessive cranking which I know isn't very good for my starter but I was getting a little upset.
View 11 RepliesFord 6.0L Power Stroke Diesel :: 2006 - Power Steering Pump Replacement
When replacing the power steering pump on my 2006 should I go OEM on the pump or save some money and get a Napa or aftermarket remaned unit with the pulley installed? Also, whar is the fluid capacity of the power steering system?
View 14 RepliesFord 6.0L Power Stroke Diesel :: Steering Stabilizer Removal / Replacement
Trying to replace my steering stabilizer and in the process I broke the nut close to the steering box. Would not budge so used a bar and well I broke it. Now I can't pop it out am I doing something wrong? Here are a few pics. I'm totally bummed nothing seems to be working for me.
View 14 RepliesFord 6.0L Power Stroke Diesel :: Steering Wheel Shaking?
Was on the way home today and was taking a long sweeping left-hand curve at 60 and got a horrible shake in the steering wheel. Kinda scared me a bit and let out of the throttle a bit. Didn't happen after and never has before. I'm under the impression it is more shocks maybe then steering, Reason I say that although I don't get a lot of bounce if the road isn't perfectly smooth I can really tell it. What do ya'll think?
View 14 RepliesFord 6.0L Power Stroke Diesel :: Float Feeling In Steering Wheel
I've got a 'new to me' 4" Lift 6.0L PSD Diesel, 2005. At 60 mph, especially 75 mph, there's some 'play' or float feeling in the steering wheel. Is that a normal thing for a 4" lift? and nothing to worry about? (the dealer that sold it said they put new ball joints in it. No cheap shock problem, right?)
View 4 RepliesFord 6.7L Power Stroke Diesel :: Turn On / Off Heated Steering Wheel?
I have a 2015 Platinum Superduty that came with a heated steering wheel but cannot figure how to turn it on and off. I have looked for a dash switch and in the climate portion of the touch screen with no luck. My wife's car has a simple dash mounted switch and also a temp sensor that cuts it on automatically when cold. No such luck with truck.
View 14 RepliesFord 6.7L Power Stroke Diesel :: Lariat Leather-wrapped Steering Wheel Fit In XLT?
Looking to swap out the vinyl wheel with a leather-wrapped one from a Lariat. I assume that this will be a direct swap but wanted to poll the audience to make sure I'm not overlooking anything.
View 6 RepliesFord 6.7L Power Stroke Diesel :: 2013 F250 - Disintegrating Steering Wheel?
2013 F250 with 36K miles. Just in the past 2 months I've noticed my steering wheel is disintegrating at about the 12:30 position. No possibility of diesel/chemical transfer to the surface.
View 12 RepliesFord 6.0L Power Stroke Diesel :: Slight Aggravating Shake In The Steering Wheel
I have been ignoring a slight aggravating shake in the steering wheel for quite some time. I just assumed tire out of balance or slightly warped front rotor or some ball joint work due to approaching 80,000 miles. Well the slightly warped rotor became much worse so i dove into the front brakes. Long story short it ended up being the rear brake rotor/caliper sticking transferring the vibration to the steering wheel. With two other vehicles to maintain i missed/neglected the rear hardware on the truck. So keep the rear brake hardware on your radar for a front end shimmy. Its gone now and a pleasure to drive again. I do have the crew cab and 8' bed which gives the rear end a long lever.
View 1 RepliesFord 6.7L Power Stroke Diesel :: Lower Knee Panel Removal Under The Steering Wheel
I know that to remove the lower knee panel under the steering wheel all that has to be done is to pull it off and the attachment snaps will pop free. However, How do I go about removal of the dash panel to the left of the steering wheel? This would be the narrow panel that also houses an ac vent, headlight and I believe it is the adjustable pedal control.
View 5 RepliesFord 6.0L Power Stroke Diesel :: 2004 - Steering Wheel Won't Turn With Brake Pedal Down?
I have an 04 6.0 psd and if I am stopped in drive with the brake pedal down I can't turn my steering wheel at all. If the truck is in park and my foot off the brake pedal I can turn the steering wheel both ways just fine. When I am driving I don't have any problems with the steering. I have checked the power steering fluid and it is full. This makes it kind of hard when I am trying to pull in and out of parking spots. What could be causing this and what the solution would be to fix it?
View 10 RepliesFord 6.7L Power Stroke Diesel :: Swap Cruise And Stereo Controls On Steering Wheel
This may sound petty, but I would like to have the radio controls on the left side of the steering wheel of my 2012, instead of the cruise control. I guess the main question is how the wire harness is set up. Do the wiring can be re-routed to accommodate the switch?
Also, I want to smooth out the ride a tad so as to lessen the amount of griping from from the passenger seat. What is acceptable in lowering the tire pressure to allow a better ride without compromising tire wear? The factory specs are 65 psi. My truck is a 2012 fx4 Lariat with the 6.7
Ford 6.0L Power Stroke Diesel :: Hard Steering / Can Barely Turn The Wheel When Stopped
I have an 8 inch lift with 37x13.5 inch tires and dual front steering stabilizers. when I'm stopped I can barely turn the wheel. my buddy has a 6 inch lifted excursion with 35 inch tires in his is easy, one hand no problem. Would the difference in tire size really make that big of a difference or am I having a steering pump issue?
View 9 RepliesFord 6.7L Power Stroke Diesel :: Sync / Radio - Steering Wheel Control Not Working?
Issues with your sync/radio that in the lower right corner it says to "connection error-see delear"?
My controls on my steering wheel will no longer change the channel or adjust the volume. When it does change the channel it goes crazy and changes multiple channels.
I have also noticed my GPS arrow seems to drift off the road I'm traveling on and then will jump back to where I'm driving.
Ford 6.7L Power Stroke Diesel :: Steering And Front Wheel Vibrations And Oscillations After Traveling Over A Bump
4450 - Literature Program 09L02: Customer Maintenance Reminder
Some owners of certain F-Super Duty 250/350 4x4 vehicles have experienced severe steering and front wheel vibrations and oscillations after traveling over a bump or dip in the road. As a result of a study with NHTSA regarding shimmy, Ford sent a Customer Maintenance Reminder letter to owners back in March of 2009. In addition, Ford agreed to send reminder letter to owners.
Although there is no service action required by the dealer, customers will be informed if after setting the tire pressures on their truck to the Ford specified levels, they believe the vehicle needs additional service, to contact their local Ford dealer. Letters will be mailed starting the week of 12/09/13 and may result in increased customer service inquiries.
Ford 6.7L Power Stroke Diesel :: Vibrating Sound When Turned Steering Wheel Slightly To The Right On Highway
For the past month or so I have had something strange going on. When driving between 65 to 70 on the highway, I've turned my steering wheel slightly to the right and if there is a cross wind or head wind there is a vibrating sound. And it does get loud. I don't really feel it in the steering wheel. Only when there is a wind. I haven't done anything new to the truck since winter.
View 4 Replies