Ford 7.3L Power Stroke (1999-2003) :: Coolant Leak / Dripping Down Onto Passenger Side Front Leaf Spring
2003 F250 7.3... I noticed a water leak dripping down onto passenger side front leaf spring. I saw this before but attributed it to the AC (which kicks butt) but haven't used the AC. No scent to the clear fluid, temps all look good. Running fine. Where does the AC discharge go? Could AC be on (not on AC but set in blue zone on dial)? Reservoir looks ok but could e small volume of drips.
View 12 RepliesFord Super Duty (1999-2016) :: 2000 F350 - Front Passenger Leaf Spring Just Broken
My front passenger leaf spring just broke on my 2000 f-350. My front springs are T code, but I was wondering if a could replace the broken one with a code X spring as a temp fix until I get a leaf spring replacement delivered?
View 1 RepliesFord Super Duty (1999-2016) :: Conversion Of Leaf Spring To Coil Spring?
Conversion from the dana 50 to the newer dana 60 with coil spring? My Dana 50 has called it quits so while my front end is already off the vehicle already why not make improvements. Ford used the 50 for 1999 to 2002 then upgraded to the 60, I'm guessing it was for a reason!
I've read this article on a similar project but the dana 60 had leaf springs as well: Dana 60 Conversion for F250 years 1986-1996 .: Articles I'd prefer coil spring, nothing more then personal preference with a bit of better ride quality. The donor vehicle is a 06 SRW F250 This is not what I'll be getting but just as an example of the parts I would get.
Ford 6.7L Power Stroke Diesel :: Leak Coming From Front Of Rear Diff
I have a pretty good leak coming from the front of the rear diff. is this a common problem on the 10.5 ? How hard are these to do without a lift? I still have warranty left but will have to swap out exhaust so its almost a toss up whether I do the seal myself. Also was considering a new posi unit because seems like the original is about toast, might be a good excuse to swap a new one in. 2009 with 95,000 on it. Bought it a year ago with 70,000 on it, the rear was dry till at least 90,000. I serviced the fluid at about 90,000 and didn't have a leak so now a couple thousand miles and its gushing???????
View 7 RepliesFord 7.3L Power Stroke (1999-2003) :: Replacing Front Leaf Springs?
I tried to replace the rear spring bushing of the drivers side front leaf spring.
Got the nutz off the shackle... The lower bolt was bumping into the front drive shaft and would not come out all the way.
Biggest problem I was having seemed to be I could not get the axle to drop far enough to release the pressure on the bolts in the shackle.
NOTE: I was trying to do this without unbolting the U-Bolts from the axle.
I was under the impression you could do this without unbolting the u-bolts. I have all new hyperflex suspension bushings and would like to get them on.
Ford 6.0L Power Stroke Diesel :: 2003 F350 - Fuel Leak From Blue Spring Regulator
I have a 2003 F350 6.0 Lariat Crew Cab long bed. I have had a fuel leak issues for about 2 weeks now. The first fuel leak issue was from the blue spring regulator. I was going to change the part this friday. Well i just drove to get food and back to the house was only gone for 15 to 20 minutes amd never cut the truck off. So i got back home and parked the truck and i cut it off and got out and all of a sudden i here this noise like you hear when a tire has a hole in it and its leaking air out then all of a sudden I hear fuel just pouring out and smoke coming out of the hood. Its night time here where i live so i cant get up under the truck to see exactly what is going on. But I did check to see if it was the regulator housing and it didn't look like any of the fuel lines was leaking that i could see.
View 4 RepliesFord Excursion :: Leaf Spring Swap - Wheel / Tire Size
My leaf spring swap is almost complete... its been almost 3 weeks with all the conflicts of life but its getting near completion. Just have to do front passenger side now.. Tomorrow and it should all be done.. hopefully... Any ways... my preliminary numbers are 40" front (ground to fender) and 41.5" rear.. Might be 1/2" to 1" off since I haven't finished the job AND the truck is sitting on dirt. Any ways, What size wheel/tires can I fit on there now? And will I need a spacer with that size?
View 1 RepliesFord 6.0L Power Stroke Diesel :: 2005 Turbo And Pedestal On 2003 Swap?
Need to know if you can mount a 04+ turbo on a 03 engine without changing the intake with the cross in the back ? Or does the intake have to be changed. If the intake does need to be changed will the egr need to be change as well ?
View 4 RepliesFord Super Duty (1999-2016) :: 2002 - Driver Side Front Leaf Spring Snapped?
I just realized my driver's side front leaf spring on my 2002 F250 has snapped. I checked the weight sticker on my truck and it weighs 5200lbs in the front. My question is the heaviest springs I found only support 2630lbs a piece, so being a 7.3 is 5200lbs a correct weight for the front of this truck? also why would Ford make springs that support only 60lbs more than the front weight? Hell I weight more than 60lbs.... Did I snap the damn thing just by climbing into the cab?!?!
View 6 RepliesFord Super Duty (1999-2016) :: Width Between The Spring Perches On Leaf Sprung Front Axle?
What is the width between the spring perches on leaf sprung 99-04 front axle. I searched and cant seem to find a dimension listed anywhere. i tried the dana60 bible on the pirate site as well, but it doesn't list the spring perch dimensions, only for the pre 99 styles
View 2 RepliesFord F-150 (2004-2008) :: Front Coil Spring Was Broken?
So I have had my FX4 for almost 10 years now. I have an xtra cab, bought new summer 2004 in Connecticut. Bought it had 5 miles on odometer, as of today has almost 117k miles. We just relocated this past weekend from CT to Manatee County, Florida, my wife followed me down in her 2010 Escape. Both trucks ran perfect..easy driving cruise control on 70 most of the way except for VA where there seemed to be a state trooper every 5 miles
anyway so overall I am satisfied with my truck since I've owned it. Changed oil every 4000-4500 miles without fail, 5-20 Motorcraft semi synthetic and FL-820 S filter is all it has ever seen. Engine doesnt burn/leak a drop of oil. As far as maintenace items and repairs, I looked through my records, here's what I've done:
1) rear axle rebuilt under warranty, clutch packs were shot at 60k.
2) brakes/rotors all around at about 50k, they still as of now have plenty of meat left
3) pinion seal went at about 90k
4) fly wheel had to be replaced at about 95k that was an expensive repair
5) replaced both front window regulators
6) replaced sliding rear window, under warranty, was leaking badly.
7) idler pulley replacement
8) exhaust rotted from just in front of muffler to tailpipe, replaced.
Also was told before we left CT that front coil spring was broken? I don't know about that truck suspension seems fine but will have it looked at.
Also normal maintenance did tranny flush 4x so far, fuel filter 4x so far, on 3rd set of tires, came with BFG rugged terrain, replaced at 62k with TOYO open country, they lasted 40k, now have Goodyear Wrangler LT's, so far excellent. Air filters, a light bulb here and there, and replaced battery after 6 years just to do it.
I have NOT changed the plugs yet truck does run great but I know what can and probably will happen, I feel comfortable with a dealer doing it, I'm not mechanically inclined enough to do it. I will have a little bit of a commute to work here, so I will probably get a ford Fiesta or a focus for the drive, but no way am I getting rid of this truck!
Ford 6.7L Power Stroke Diesel :: 2011 F350 - Squeak / Chirp From Front
2011 Ford F350, 69K miles... Just started, at about 30mph. I am hearing a Chirp from the front, speeds up when I speed up and goes away with brakes or slow below 30.
Friend thinks its the brake warning telling me its time for new. Bugging me. Just started. Never changed brakes.
Ford 6.0L Power Stroke Diesel :: 2006 F350 2WD - Creaking Sound In The Front End
I am trying to track down a creaking sound in the front end. Happens when turning mainly left but occasionally right or slow speed turning the steering wheel. I've rebuilt the front end (not because of the creak) ball joints, tie rod ends both inner and outer, sway bar bushings, power steering pump, shocks, steering shock etc. what's left? All parts have been greased good but still can't find it.
View 2 RepliesFord Excursion :: Back End Lower Than Front And Drops Dramatically While Towing - Spring Swap On A Lift
So this may be a really dumb question, but here goes. I have a new to me 2001 v10 gas 4x4 ex. It has obviously been lifted in the past. The springs seem totally shot as the back end is quite a bit lower than the front and drops dramatically while towing. I am adding a helwig and have a wd hitch but have not set it up yet. So my question is can i do the spring swap? It would seem that i would need to address whatever changes are made from the stock ride but im not sure. I like the current lift and would be fine keeping it and adding the lift from the new springs.
View 14 RepliesFord 6.0L Power Stroke Diesel :: 2006 F350 4X4 Front Hub Bearing Part Number?
Can't seem to find a number for just the bearing and snap ring. All I can find are the dang assemblies.
View 11 RepliesFord 6.7L Power Stroke Diesel :: 2016 F350 - Brake Dust On Front Wheels
I have a 2016 F350 4x4 that has brake dust on the front wheels after only 3000 miles. I have tried to find ceramic pads to replace the semi-metalic pads that are causing the issue. There is no listing for replacement pads that I can find. My question is will 2015 pads fit the 2016? What is the actual part numbers to see if they are the same. This is just one of the problems with having an early build vehicle.
View 14 RepliesFord 6.7L Power Stroke Diesel :: 2012 F350 - Making Clonk Sound In Front?
I have a f350 2012 that makes a strange clonk sound in the front when I go over bumps the problem is that we dont have too many us ford dealers here.
View 2 RepliesFord 6.0L Power Stroke Diesel :: 2006 F350 - Front Right Caliper Won't Slide Off Pads / Stuck
Replacing remaining three calipers on my 2006 F-350 2wd as a preventative measure after I had a drag on the left front. Passenger side front being difficult. Caliper won't slide off pads. I believe pins are stuck but it doesn't seem they've got the caliper stuck - appears that I can't get pistons to stay compressed enough to clear pads. Caliper has some wiggle on pads - just not enough.
I tried multiple C-clamp iterations but can't get there just yet. I'd rather not fool with the bracket and removal won't fix my problem, just allow me to work it on the bench. I do have a replacement caliper, so damaging it to get it off is an option. I have sprayed Kroil into the piston seals in a Hail Mary when I pick this up tomorrow.
Ford 6.7L Power Stroke Diesel :: 2011 F350 - Front And Rear Passenger Side Pulling Only In 4WD?
Got stuck, noticed when in four wheel drive only the front passenger side and rear passenger side was pulling. Is that normal? Or should both fronts be pulling?
2011 f350 dually 4x4 6.7.....