Santa FE SM (2001-06) :: 2004 - Front Driver Side Coil Spring Broken
The driver's side coil spring broke, but here's the story.
When I found out there was a recall on my 2004, I called the dealership. They told me that they were not replacing the coils springs, they were only going to attach a brace or bracket in case the coil springs would fail.
Well, last night the coil broke and it was in the parking lot and not at 50mph on the road.
What about bracket fix? It was told to me that it would only prevent the coil from cutting into the tire, not fix it.
I am going to call Hyundai HQ this morning, but what should I expect? Is it unreasonable to expect to get a set of springs and have someone local do the work?
Ford F-150 (2004-2008) :: Broken Coil-on-plug Wire Clip?
2007 F-150 Screw 5.4... Successful spark plug change. Well, sort of. I disconnected some of the coil clips/wires from the coils during the operation. Upon installation of the wires/clips, one of the clips did not 'click' into place.
Thinking the clip needed to be pushed/pulled, I bent the clip a bit and it snapped off! Being the slow learner that I am, a second clip also did not 'click' in place, and you know where this is going: I have two broken clips out of 8. After those two, I was much more gentle.
So, can these clips be replaced and/or spliced in? I'm thinking about just using nylon ties to hold them in place. So far, they are staying put just by being pushed in place, but these two do not seem very secure.
In the future, what is the correct way to make sure these things 'snap' back into place if they seem to not want to cooperate?
Here's a picture of the two 'press clips' that broke off....
Ford 6.0L Power Stroke Diesel :: 2005 Coil Front End To 2003 F350 Leaf Spring Front Diff Swap?
Any success story on converting 2003 or 2004 f350 with leaf spring front end to the 2005-2007 f350 coil front end is it possible?
View 8 RepliesFord Super Duty (1999-2016) :: Conversion Of Leaf Spring To Coil Spring?
Conversion from the dana 50 to the newer dana 60 with coil spring? My Dana 50 has called it quits so while my front end is already off the vehicle already why not make improvements. Ford used the 50 for 1999 to 2002 then upgraded to the 60, I'm guessing it was for a reason!
I've read this article on a similar project but the dana 60 had leaf springs as well: Dana 60 Conversion for F250 years 1986-1996 .: Articles I'd prefer coil spring, nothing more then personal preference with a bit of better ride quality. The donor vehicle is a 06 SRW F250 This is not what I'll be getting but just as an example of the parts I would get.
Ford Brakes/Suspension :: 2004 - Coil Spring Broke At 120k Miles?
Ok I have an f 150 04 fx4. 120k miles. I was checking a drip on the transmission cooler, and noticed my passenger side coil spring is broken 2nd coil from the bottom. Truck rides well, but obviously this needs to be addressed. Break looks old since it is rusted over, I probably relocated from new England to Florida driving this down 95 with this break, scary.
View 6 RepliesGolf IV R32 :: Front End Noise Like A Broken Spring
I have a noise like a broken spring, changed strut insert, top mount, checked for loose brake shield and pads. Removed both sway bar links. [URL] .....
View 3 RepliesFord Super Duty (1999-2016) :: 2000 F350 - Front Passenger Leaf Spring Just Broken
My front passenger leaf spring just broke on my 2000 f-350. My front springs are T code, but I was wondering if a could replace the broken one with a code X spring as a temp fix until I get a leaf spring replacement delivered?
View 1 RepliesCamry :: Broken Spring On Driver Side Front Tire
Boston winter roads got the best of my 2009 Camry LE, and now I have a broken spring on the driver's side front tire. I have yet to find a trusted mechanic in the area. Do I need to go to a dealer, or is it basic enough to do?
View 5 RepliesFord Excursion :: Replaced Coil Spring But No Cruise?
Here is my current situation. No cruise, Replaced clock spring because the air bag light was also on. Still no cruise, checked fuses, they are fine, replaced bulb in gauge cluster. Still no light coming on at all, so I can't do the self test. Do you think my steering wheel switches are bad? Is there anything else I can check?
View 14 RepliesLexus RX 2004-09 :: 2007 - Ignition Coil Lock Tabs Broken
I just completed the spark plug change on my wife's '07 RX350. As the numerous threads on this topic point out, this is one serious undertaking. I'm not claiming to be a mechanic but have done my share of DIY's including changing the usual oil/filter, brake discs/pads, serpentine belt, rear hatch switch and now the spark plugs on my wife's car and the same or similar on all of my other cars. This has got to be the single most difficult project that I've tackled recently. I did fail to do the front Mac struts but this was because I didn't appear to have the right spring compressor. Go figure.
Anyhow, I found that I needed to remove the front windshield cowl to get access to that infamous third stay bolt.
To my question ... I managed to break off the tabs that lock the connector to the ignition coil on about three spark plugs. I'm concerned about these eventually vibrating off. Should I be concerned about this? Do I need to now go in and change these? Or, tie-wrap then in place?
Ford Super Duty (1999-2016) :: 2003 2WD F250 Coil Spring Retaining Bolt Won't Budge
So I went to install a front end leveling kit in my 2003 2WD F250, looked like a simple task, except the bolt that holds the lower coil spring mount won't budge! I tried heating the nut, I soaked it with WD-40, tried a 200lb impact and a 30" breaker bar with all my weight. Is there something I am missing?
View 5 RepliesFord - Explorer :: Driver Side Door Latch Spring Broken
I found a broken spring hanging in my drivers side door latch.The power lock is now inoperatable, my question is can I buy just the spring or do I have to buy the whole latch-? I'm new here and can't find the answer,also will door need to be disassembled to install the spring.
View 14 RepliesPrius (Gen 2) :: 2005 - Cracked Rear Coil Spring After Oil Change
So, I got my oil changed at the dealer and they said that I have a cracked rear coil spring. They quoted $350. So I took it to my real mechanic and he looked at it, said it's fine for now but I do have inspection next month. He said my struts feel fine. I'm having trouble finding just the spring since the Moog ones are out of stock. I did see Unity quick struts but I don't know if they're any good whatsoever. Whether to just go with springs (and a link to some) or get the complete struts and lend an opinion on good ones. Also, it has 122k miles. A0001 ?
View 9 RepliesFord F-150 (2004-2008) :: Coil Going Bad / Breaking Down?
I hate it when this happens, but I have a coil breaking down, and I've been advised multiple times to not replace all 8 coils. So how do I figure out which one it is? I am almost sure its a coil, as the plugs do not have enough miles on them to be bad already, and the truck has plenty of power it just has a slight shudder under a load, and the engine light will occasionally flash. Seems to go away after a bit. However, I can't get it to throw a code for whatever is causing the issue. 2004 Ford F150 146k miles on it
View 10 RepliesMalibu - Chevrolet :: 2000 - Pieces Of Rear Coil Spring On Ground?
I just went into my garage and noticed pieces of my rear coil spring on the ground. 2000 Chevy Malibu LS. Question is, do I have to replace both rear coil springs? They seem to sell them in pairs.
View 2 RepliesFord 6.7L Power Stroke Diesel :: Center Console Glove Box Latch Spring Broken
It appears the spring that keeps pressure on the handle has broken, now the console lid won't stay latched.
View 4 RepliesPrius (2010-12) :: Rear Seat Belt Retractor Coil Spring Vibration
I pinpointed a consistent vibration in the rear L & R pillars! Using a rubber mallet on the tires you can hear the recoil springs vibration s and for me, I hear the back center seat retractor recoil spring vibrating! Going address this with the dealership for updated fixes, or I have to fix this myself. I have taken the rear seat apart and welded reinforcement bracket to stabilize the retractor, but the coil spring vibrates.even w the JBL system turn up I can hear the retractor coil spring vibrating distorting the music!
View 4 RepliesFord F-150 (2004-2008) :: Plug Connector On Coil 3 No Longer Snaps On
I changed out my plugs. The plug connector on the #3 coil no longer snaps on. My only option is to use a small ziptie to hold it in place. Can cut it off and wired a new plug end on..
View 3 RepliesFord F-150 (2004-2008) :: 2006 - Rough Idle After Replacing Ignition Coil
completely stock 2006 4.6, 230,000 miles, I purchased and can vouch for everything after 106,000.
Two separate issues...have had a slight ticking noise growing for about the last two years. Seems to get slightly worse near an oil change but that could be my imagination. It has finally gotten loud enough that my wife (who drives with the delicacy and observational skills of a Sherman tank driver) actually mentioned it to me the other day. It is directly related to engine speed whether the truck is in gear or not. I kind of think it might be a manifold gasket going out but am not sure. Am not very worried about it but...felt like I needed to mention it because of my bigger problem....
Truck has gotten very "cranky" on startup in the last week. Has a rough time finding an idle speed but typically sorts itself out after about 5-10 seconds. This afternoon it started idling rough at a stoplight. It got steadily worse and noticeable even at speed. Four stoplights and nine miles later it threw a code and coincidentally, I was in front of an Advance Auto. They read it and said the #3 cylinder was not firing. I bought an ignition coil, drove 15 miles home and changed it. From everywhere I looked online, this is the second cylinder from the firewall on the passenger side.
Had a little trouble getting it in and am not entirely sure it is fully seated in the slot, but I can't get it to go any further. Seems as tight as a couple of the others. I disconnected the battery to clear the codes, cranked it up and it seems to run "better", but still has a rough idle. Just test drove it about 12 miles and no check engine light but the idle has not cleared up. I think coil must be working fine because I have no issues at highway speed. Earlier, when I backed off the gas you would feel the miss very badly, but not as much when under a load.