Ford 6.0L Power Stroke Diesel :: Engine Coolant Blowing Out Of Coolant Reservoir
I have coolant blowing out of my coolant reservoir when ever i hold it to the floor it does it with or without the banks programmer... 6.0L power stroke...
View 14 RepliesPassat (B5) :: 2004 - Coolant Reservoir Overflowing
I own a Passat 2004 V6 Wagon ATQ and I noted that the coolant reservoir was low on coolant almost empty but i did not notice any overheating issue. I took the car to the shop and the Cooling system was pressure tested no leaks no problem then after a week I found that after a 20 minutes drive I pull into a parking lot and coolant was dripping from the reservoir my a/c fan works and the fan clutch spins slow and I'm able to stop it with my hand. I just replaced the clutch fan last but the problem still present.
View 1 RepliesFord 6.0L Power Stroke Diesel :: 2004 - Coolant Reservoir Empty / Leak Coming From Rear Of Engine?
While servicing the bosses 121k 6.0, I noticed the coolant resevoir empty. It took 1 1/2 gallons to bring to proper level. Returning under truck to install drain plug, I noticed coolant coming from rear of the engine(right side). And of course Ford has changed the cooling system cap, so I wasn't able to pressure test it to pinpoint the leak. Started the engine and seen coolant coming from the left rear as well. I've been reading here to see what others have been seeing, (EGR cooler, head gaskets). With all the heat shields,not much room to look.
After work I did go and buy the adapter to test the cooling system. With any luck I will be able to see leak better.
Prius (2004-09) :: Coolant Reservoir Cracked And Leaking?
I got my oil changed and was told my coolant reservior is cracked and leaking. I have been driving 4,000 miles since then and not known or noticed anything until informed today.
Is this a high priority fix? I'm not sure exactly what it is but my car hasn't showed any signs of overheating. Also what is an estimate of price for parts and labor?
Prius (2004-09) :: Inverter Coolant Reservoir Empty
Back in February, received a light and discovered that the inverter coolant reservoir was empty. I refilled the reservoir and cleared the code. Today, only 3 months later, the same thing happened. I don't see any wet hoses, puddles, or obvious signs of leakage. Where all my coolant is going? What steps should I use to properly troubleshoot...
View 8 RepliesPrius (2004-09) :: 2008 - Coolant In Brake Fluid Reservoir
I purchased a 2008 Prius with 117,000 miles lat month. I took it to a friend's house recently. When he was looking at the car, he told me that my coolant level is low and put some coolant in the reservoir. The next day when I was driving the car I was hearing a rattling sound every time I pressed on brakes. I could not figure out what could be the reason. The sound went away after couple of days. Today I was going through the manual and noticed the place where my friend put coolant in is actually brake fluid reservoir. It looks a lot like coolant reservoir of my other car. So now I am wondering what could happen if coolant goes into brake fluid reservoir. Will it harm my brakes? It has been about 2 weeks since that incident happened.
View 19 RepliesGolf IV / Jetta IV :: 2004 Won't Start / Coolant Coming Out Of Reservoir
So this weekend my Y-fitting for the coolant hose (coming out of the reservoir) broke, literally after arriving at my friends house about 50 miles from home.
I "mended" it, and decided to try to take it home, as it is my daily. Temperature would get high, but not into the red, and drop back down. On the final rise, it got a bit too close to red for comfort. I drove about 25 miles, and my coolant light was on the majority of the time. The last 3-5 miles, my oil light came on. When I went to pull off the road, I pushed in my clutch and my car died. My first assumption was a head gasket (as I have been there before.
I open the hood and coolant is pouring out of my "mended" y-fitting. I check under the car - no oil, just coolant. The oil didn't seem to be "milky," but there seemed to be some sort of condensation on the filler cap. I checked the dipstick - not milky, just liquidy. I added some oil to the car, and had a friend bring some distilled water, and did a little bit better job of mending my fitting. I poured the distilled water in, and it started boiling almost immediately. I let the car cool for a couple hours and tried to start it, but nothing.
There's no white smoke, but the car just "puts" for a few cranks, and then it goes back to cranking. Looking around the engine housing, there doesn't seem to be any oil; but my car has a lot of grease on the block, so it's hard to say.
I did some searching, and it seems that it could be the oil cooler? I don't have the tools for a compression test, and the car was towed to a gas station, which is about 30 mins from my house.
The car is a 2004 Jetta, 1.8T Manual with the 5-speed.
Prius (2004-09) :: Coolant Is Always Overflowing To Reservoir - Air Bubbles Coming Out Of Radiator
I have a 2007 Prius, my coolant is always overflowing to my reservoir. It doesn't have any overheating problem, if I will fill up the radiator I could see bubbles coming out, How can I resolve this problem?
View 8 RepliesFord - Freestar :: 2004 - Misfire / Computer Code Is P0302
My 2004 Ford Freestar SEL (the 4.2L version, 123,000 miles) is missing. The computer code is P0302 which, from what I can find, indicates a misfire in cylinder 2. I had this same code at 99,000 miles and ended up having the spark plugs and wires replaced around 100K miles. It was all running fine until about a month ago and started misfiring again, badly. I thought it was related to the rain but it is doing it all the time now. At times it gets so bad, I have no power and the computer disengages my A/C (bad at this time of the year). I tried a running a fuel system cleaner that specifically mentioned cleaning the injectors, hoping the problem was simply a clogged injector, to no avail (I know I probably wasted my $10 here). I have a couple of questions:
1. Am I doing damage to the engine or transmission by continuing to drive it? I really don't have a choice but need to know how urgent it is.
2. Does this thing have a traditional distributor cap & rotor or is there an electronic ignition module the plug wires connect to?
3. Where would I find the illusive distributor or ignition module, in theory?
4. Any other theories as to the cause of the misfire (cheapest first)?
Prius (2004-09) Fuel :: How To Determine If Inverter Pump / Coolant Reservoir Is Not Working Properly
How do you know if the inverter coolant pump/reservoir is bad after the recall was performed?Since it doesn't produce any codes but can reduce the electric-drive if getting too hot, how do you convince Toyota to give it a second look?
View 5 RepliesFord - Mustang :: Coolant Spill Out Through The Cap Of Reservoir After Driving
I have a 2006 Ford Mustang V6. Recently after driving and turning the car off the coolant has been spilling out through the cap of the coolant reservoir. The car drives fine and does not overheat so it appears the cooling system works while driving. I have not identified any visible leaks and the heat inside the car works. I have replaced the coolant reservoir cap, thermostat, and thermostat casing.
View 4 RepliesFord - Taurus :: 1999 - Coolant Reservoir Cracked / Swelling Out
Two autumns ago I lost heat and discovered I had no coolant because the reservoir had cracked. Replaced the reservoir and life was warm again. The following autumn, same thing. Replaced the reservoir AGAIN. The mechanic showed me where it had bulged out on the side, and said if this new one looks like it is swelling out also, then there is a deeper problem, like maybe a leaking head gasket. Well, it is definitely bulging on the side again. I mentioned this problem to my male co-workers and they were puzzled and also thought the mechanic's suggestion was incorrect.
View 11 RepliesFord Excursion :: Antifreeze Leak - Coolant Plastic Reservoir On MIN
Noticed this leak today a few days after parking the Ex (V10) -- not a daily driver. Crawled under the Ex and checked under the hood but I could not find an obvious sign of where the leak is coming from.
I checked the coolant plastic reservoir and its on MIN -- I believe that where it should be when the engine is cold. I noticed that these trucks do not have a cap directly on the radiator. That plastic reservoir, is that where I would top off the coolant?
Is there a spot on these engines where it would commonly leak? Should I try to put some dye on the coolant and/or possibly pressure test it?
Ford F-150 - 1997-2003 :: 1999 - Smells Like Oil In Coolant Reservoir
I have a 99 Ford F-150 Lariat. I am smelling oil in my coolant reservoir. I have looked all over the engine and do not see any leaks. I do not see any oil on the ground. The truck does not overheat so I don't know how it is getting in. My engine runs great. What can be causing this problem?
View 2 RepliesFord - Exporer :: 1996 - Overheating / Coolant Reservoir Is Super Low To Empty
Had overheating issue with the wife (she doesn't monitor fluid levels like she should). Now you can't operate it for more than a day or two before the reservoir is super low to empty. Mechanic coolant is going into the engine, probably through the intake manifold. Says investigating further will cost a ton. What can I do cheaply to figure out what's going on before I give up? I followed her when the engine was started from cold & could see water vapor (more than I would expect) in the exhaust until when I figure the engine reached full operating temp. It has about 225k and is the 6 cyl engine, btw.
View 1 RepliesFord - Fusion :: Coolant Reservoir Leaking At Top / Squeak When Start Driving
I've had a issue since I've owned my 2015 purchased new that I didn't get a chance to take in again until recently. I have a little fluid that leaks out of the Hybrid coolant reservoir. This is not the one attached to the radiator for the ICE, I have an issue with the hybrid component one. When I first received my car the fluid was above the full level. After a few times wiping it up I stopped by and had the dealer remove the excess fluid from the reservoir until it was at the MAX line. After a little while I noticed some fluid continued to seep/leak out and I'm at the low line now. I recently took my car in again to take care of a few things before the bumper to bumper expires. When I received the car back I didn't fully review my paperwork until I got home. I saw the comment that "Normal characteristics of the Hybrid cooling system" ...
A second issue I have is I get a squeak sometimes when I start driving the car. Sounds like it's coming from the front wheel, it's not a constant squeak, but one that happens with each rotation of the wheel. They were unable to recreate the issue as it's random. Brakes were checked and no issue found. I'll have to see if I can get it to show the issue for the service rep.
Ford 6.0L Power Stroke Diesel :: Engine Does Not Crank - No Coolant In Reservoir
I did not run the truck for 5 months and the engine will not crank. I charged the batteries but when I turn the key nothing happen, I hear the glow plug system going but nothing else, starter does not click at all.
One thing that scares me is that there is no coolant left in the reservoir and I am scared that it went in the engine. I did have to add coolant last summer.
How can I first test the starter? Can I turn the engine by hand? If I push the truck, does the engine turn and can I tow it without damaging the engine if it is hydrolocked?
Ford Super Duty (1999-2016) :: F250 - Coolant Reservoir Was A Bit Low
I just purchased a 2007 Ford F250 5.4l V8. I noticed the coolant reservoir was a bit low so I went out and bought some Prestone extended life universal coolant, distilled water and a hydrometer. The current Coolant I have is a yellow/gold colour, which I believe is motocraft brand. I added 150ml 1:1 of distilled water and coolant. After that I tested the temperature rating and it was off the gauge (the previous owner obviously added just coolant and no water). My plan was to drain the radiator half way and refill with distilled water. But, how to do that I came across a lot of forums saying you can't mix Prestone ELT with Motocraft coolant or it will eat away at your engine as well as create a thick goo. Is this true? Will such a small amount (75ml) cause this effect? Do I have to do a radiator flush now, or can I just continue with my plan of draining it half way? The old coolant looked pretty clean. Do you think the Prestone anti freeze has already done any damage?
View 14 RepliesFord 6.0L Power Stroke Diesel :: 2007 - Oil In Coolant Reservoir - Getting CEL Intermittently?
Have been working on military diesels for years. I have a 2007 Ford F-250 6.0. I am currently waiting for a new oil cooler as I have oil coming from my coolant reservoir and no coolant in my crank. My question is I have been having my engine light coming on and off intermittently since deleting my EGR cooler.
View 6 Replies