Prius (2004-09) :: Coolant Is Always Overflowing To Reservoir - Air Bubbles Coming Out Of Radiator
I have a 2007 Prius, my coolant is always overflowing to my reservoir. It doesn't have any overheating problem, if I will fill up the radiator I could see bubbles coming out, How can I resolve this problem?
View 8 RepliesNissan - Murano :: 2003 - Overflowing Coolant Reservoir?
.My Nissan Murano, 2003 is acting up after a ton of diagnostics and repair . We replaced thermostat, flushed heat core, replaced coolant pipe which had rusted and leaked out fluid, and ran air bubbles out forever, it seemed. The heater does not work now on lower rpm's and the car was gurgling the other day when i stopped at mailbox. I have been driving it for a few weeks since we had it repaired.When i pulled in into garage, it was overflowing at reservoir for coolant. We have not driven it and our mechanic is perplexed. He ruled out head gasket problems with chemical test and another diagnostic test. . . .he is perplexed. He added coolant and what else. . .. .that is all i can think of . should we get it towed to dealer which is 100 miles away? we've already spent 1500 or so with this and it seems we could be back at square one. Our mechanic is very honest, and he does think it could be in the engine, like a warped plastic piece. . . i don't know what he said exactly, but he's just guessing.We have 128k on this engine.
[URL]
Honda - Cr-v :: 1999 - Radiator Overflowing Coolant Fluid
1999 Honda CRV. Took it in for an oil change last month, then next day took a long road trip. After the first half of the trip, I opened the hood and saw colored fluid sprayed all over the front of the engine. It seemed to be coming from the top of the radiator. I assumed the common failure mode of these radiators, ie that the joint between the plastic top piece and the aluminum radiator body was beginning to fail. The overflow tank was empty, but the radiator was still full.
But before I drove the return trip home, I replaced the radiator cap with a new one just in case. When I got home, I checked the engine compartment again. No more coolant spray. So I thought the new radiator cap had solved the problem.
So I added fluid to the overflow reservoir, up to the "minimum" line. A few days later after some local driving, checked again. Again, coolant sprayed around, seemed to be coming from around the cap, overflow reservoir empty, but radiator still full.
Now I just leave the reservoir empty, instead of filled to the "minimum" line. The radiator is not leaking, because I've checked the level several times since and coolant is always near the top of the neck. The only problem is when I add fluid to the "minimum" line in the reservoir, which results in coolant being sprayed out (apparently through the radiator cap, both the old cap and the new one). Now I suspect the oil change mechanic also checked my fluid levels and added coolant to the overflow reservoir, which resulted in the original "spray" episode during my highway trip.
So the question is, why is this happening all of a sudden? Never did this before. Now I just leave the reservoir empty and check radiator level occasionally. But I would like to know why any fluid added to the reservoir when cold causes the radiator cap (apparently) to blow out the excess coolant (it is NOT leaking from the overflow reservoir).
Passat (B5) :: Oil In Coolant Reservoir
I checked the oil it does not have coolant in it, so that eliminates the headgasket.
View 3 RepliesFord 7.3L Power Stroke (1999-2003) :: Coolant Overflowing Through The Cap
I have a 2002 excursion and every time I try to put the coolant at the min level cold, it overflows through the cap until it is about 1.5-2 inches below the min level. Then it stops. I just did the oil cooler seals last night because I had a little oil in the coolant. Same thing happened this morning - overflowed again.
View 10 RepliesPassat (B5) :: 2000 1.8T - Oil In Coolant Reservoir
My buddy has a 2000 1.8T Passat and he has oil in coolant reservoir. It does not blow out any smoke. It runs fine, and does NOT have coolant in the oil. We pulled off the oil/coolant heat exchanger on the oil filter and it appears to be good. We blocked off one end and filled it with coolant and put compressed air to the other end. Nothing came out. He took it to the shop and they said the turbo seals were good. I can't verify that though.
Head gasket? Worse yet cracked head or block? The car does have 170,000 miles.
Passat (B5) :: Coolant Boiling - Oil In Reservoir
Long story short, I got a 2001.5 1.8t M5 Passat with 63k miles 2 weeks ago.
This weekend I was driving around and pulled into the driveway and noticed the coolant was boiling in the coolant reservoir. It also looked like there was some oil in the reservoir. Take it to the shop, turns out that the plastic impeller on the water pump broke at 64k miles. This is wierd because the car never actually overheated. The mechanic doesn't think that the head gasket is blown or i have a cracked/warped head because the car still runs fine. He suggests I replace the water pump, timing belt, coolant reservoir, thermostat and obviously flush the coolant. I go ahead with the repair since its almost time for the TB anyway.
After bending over and taking it from the shop on a timing belt and water pump repair, I think I am all good. Today I open everything up after a few days of driving around just to check up on stuff. I open the coolant reservoir and there is telltale signs of oil in the coolant. Now i think this was an issue before the water pump went. Searching the archives I see that the oil cooler is a common failure. This could have also contributed to the failure of the water pump and maybe the thermostat, I don't know.
So instead of bending over for the mechanic for a second time in a week , I think I'm going to replace the oil cooler and flush the coolant system again and change the oil myself. Poked around looking at the oil cooler and it seems as if there is the slightest sign of an oil leak on the outside, which could mean there is a leak inside. I don't have compressed air so I'm not sure how I can test the oil cooler for leaks.
I am thinking i need:
-Oil cooler (some suggest S4, some suggest TDI one?)
-Oil cooler gasket
-Feed and return lines
-Hose clamps
-g12 coolant
-Oil filter
-Synthetic oil
Should I replace the upper and lower radiator hoses while I've got the coolant out? What else should I replace while the coolant is out. I see people suggest flushing the system several times. Should i use G12 everytime or can I just use water to flush until its clean and fill with G12?
Passat (B5) :: Coolant Seems Boiling Inside The Reservoir
been working on my passat for the last year oil cooler went bad and also my CCM fried. Anyways got the car running good or so i thought drove the car up the road today and my coolant sounds like it's boiling inside the reservoir.
View 11 RepliesPassat (B5) :: Mystery Leak In The Coolant Reservoir
So I started the car today, proceeded to back out, and the STOP: check coolant light message comes on. I check the coolant reservoir, and its near empty. Then I notice a puddle. Filled it back up and let it run for a bit. No leak. Looked at the front of the engine and didn't see any leaks.
View 11 RepliesPassat (B5) :: Coolant Reservoir Color Is Pink / Orange
I'm kind of worried about the coolant in my 03 2.8 passat. it is a pinkish/orangish color, but im worried they topped it off with dexcool at the dealer. is it okay to mix g12 and dexcool or am i looking at a gelled up mess?
With that note, can you run g12+? or do you recommend to stick with the oem g12?
Passat (B5) :: 2000 - Loosing Coolant Through Reservoir Overflow
I have a 2000 passat tdi, over the past months ive noticed that I have been loosing coolant through my coolant reservoir overflow, my car has been running perfectly, my mechanic told me that its likely to be a head gasket problem and he put ceramic sealer in the coolant system, which was a disaster, the coolant pressure became much worse and told he me I needed a new radiator, which he fitted, but there was no improvement, whilst my mechanic was working on the car he noticed that when my car was running if he removed the oil filler cap the engine breathed heavily, my mechanic told me that the engine would need replacing,so I should sell the car as soon as possible.
I found it difficult to believe my trusty VW was in such a bad state, as it has only done 87000s mile and has full service history and starts and runs like a dream. Today I went for a second opinion, they told me that the coolant problem was because of a defected water pump, with most likely the plastic impellers failing, and the engine breathing problem could be down to a blocked breather at the top of the engine.
Passat (B5) :: 2003 - Coolant Pushed Out Of Reservoir When It Warms Up
I purchase an 03 passat v6 2.8l today. After it warms up it will push the coolant out of the reservoir. Note, it's not overheating. The guy I bought it from said the coolant reservoir exploded on thursday. He said his local mechanic said it needs head gasket. What's ur take on it? When I remove the over flow hose from the reservoir and increase the rpm, very little coolant comes out. After I let go of the pedal, the coolant gushes out on the over flow hose. Thermostat is opening. Guy said the water pump, thermostat and belts were replaced last year. The problem started Thursday when the old reservoir exploded. I was thing of replacing the belts , water pump and thermostat with oem.
View 5 RepliesPassat (B5) :: Coolant Reservoir Empty And Has Brown Residue All Over Inside
Today, I was greeted by a big red STOP! warning from my 2000 Passat 6 cylinder. The car drove fine last night. The coolant reservoir appears empty and has brown residue all over the inside. I notice for the first time that there is pink fluid on the floor -- I'm assuming this is the G12 coolant.
It's not a hot day, so I put in distilled water, turn up the heat and drive my Passat (trying to stay under 2k rpm) down to the dealer. They say that the coolant from the oil cooler leaked into the oil (and presumably, vice-versa).
Ford - Freestar :: 2004 - Reservoir Too Low On Coolant
My wife has a 2004 Freestar and a few weeks ago it all of a sudden went to red on the temp gauge and there was some steam. So I checked the reservoir and it was too low on coolant. I added the coolant but it still had a tendency to run towards red but turning on the heater full blast made it go down drastically (below 50%). ALso, the heater was blowing cold air. So I changed the thermostat and watched it. It continued to inch up to 70%-80% and then finally drop back down to 40%.
I also had to start adding coolant every other day. I took it in and had a flush done. It eventually blew the reservoir cap off and all the coolant out while my wife was on the highway. I had it towed to a shop and the mechanic said he couldn't find anything wrong with it except the cap. He did a pressure check with the old cap and it wouldn't hold. He replaced the cap and it held pressure. He assumed that was the problem. That was a week ago.
Today it ran up to 80%-90% and then all of a sudden it dropped down to 40%. When we got home I let it cool for 4 hours and then checked the level. It was at the bottom of the reservoir roughly 3-4 inches below the fill line. We don't see any signs of leaking on our driveway. What could the problem be? I checked the oil to see if it may have coolant in it but didn't see any sign.
Prius (2004-09) :: Coolant Reservoir Cracked And Leaking?
I got my oil changed and was told my coolant reservior is cracked and leaking. I have been driving 4,000 miles since then and not known or noticed anything until informed today.
Is this a high priority fix? I'm not sure exactly what it is but my car hasn't showed any signs of overheating. Also what is an estimate of price for parts and labor?
Prius (2004-09) :: Inverter Coolant Reservoir Empty
Back in February, received a light and discovered that the inverter coolant reservoir was empty. I refilled the reservoir and cleared the code. Today, only 3 months later, the same thing happened. I don't see any wet hoses, puddles, or obvious signs of leakage. Where all my coolant is going? What steps should I use to properly troubleshoot...
View 8 RepliesPrius (2004-09) :: 2008 - Coolant In Brake Fluid Reservoir
I purchased a 2008 Prius with 117,000 miles lat month. I took it to a friend's house recently. When he was looking at the car, he told me that my coolant level is low and put some coolant in the reservoir. The next day when I was driving the car I was hearing a rattling sound every time I pressed on brakes. I could not figure out what could be the reason. The sound went away after couple of days. Today I was going through the manual and noticed the place where my friend put coolant in is actually brake fluid reservoir. It looks a lot like coolant reservoir of my other car. So now I am wondering what could happen if coolant goes into brake fluid reservoir. Will it harm my brakes? It has been about 2 weeks since that incident happened.
View 19 RepliesGolf IV / Jetta IV :: 2004 Won't Start / Coolant Coming Out Of Reservoir
So this weekend my Y-fitting for the coolant hose (coming out of the reservoir) broke, literally after arriving at my friends house about 50 miles from home.
I "mended" it, and decided to try to take it home, as it is my daily. Temperature would get high, but not into the red, and drop back down. On the final rise, it got a bit too close to red for comfort. I drove about 25 miles, and my coolant light was on the majority of the time. The last 3-5 miles, my oil light came on. When I went to pull off the road, I pushed in my clutch and my car died. My first assumption was a head gasket (as I have been there before.
I open the hood and coolant is pouring out of my "mended" y-fitting. I check under the car - no oil, just coolant. The oil didn't seem to be "milky," but there seemed to be some sort of condensation on the filler cap. I checked the dipstick - not milky, just liquidy. I added some oil to the car, and had a friend bring some distilled water, and did a little bit better job of mending my fitting. I poured the distilled water in, and it started boiling almost immediately. I let the car cool for a couple hours and tried to start it, but nothing.
There's no white smoke, but the car just "puts" for a few cranks, and then it goes back to cranking. Looking around the engine housing, there doesn't seem to be any oil; but my car has a lot of grease on the block, so it's hard to say.
I did some searching, and it seems that it could be the oil cooler? I don't have the tools for a compression test, and the car was towed to a gas station, which is about 30 mins from my house.
The car is a 2004 Jetta, 1.8T Manual with the 5-speed.
Prius (2004-09) Fuel :: How To Determine If Inverter Pump / Coolant Reservoir Is Not Working Properly
How do you know if the inverter coolant pump/reservoir is bad after the recall was performed?Since it doesn't produce any codes but can reduce the electric-drive if getting too hot, how do you convince Toyota to give it a second look?
View 5 Replies