Ford - Explorer :: 2000 XLS V6 Freeze Plugs Are Leaking Coolant
Mine has a 4.0 V6, the freeze plugs are leaking coolant, the guy at the shop said it will require pulling the engine to replace them. Is there an easy ( less expensive ) fix ? I was told I could use block sealer, is that an option? She has appox.160,000 miles...
View 2 RepliesFord Excursion :: Leaking Coolant Whether Engine Is Running Or Not
This guy started as a slow leak. Now leaks down entire coolant res whether engine is running.or not. Appears the connection to the rest leg isn't sealed. Not sure if available from factory, or if I should cut it out and replace with barbed tee and hose clamps. That's my inclination. Not a ton of room to work with. I think it's an excursion specific thing, from pics I don't think super duty has a t there. Guessing it's where rear coolant line tees off?
View 7 RepliesFord A/C :: 1986 - Coolant May Be Leaking Somewhere By Heater Blower
I am talking about those two hoses going into the firewall by my Blower Motor assembly that may be leaking and wanted to know if i can bypass or plug up these two hoses, since i no longer have ARA A/C and heater.
1986 140 CID GAS Ford Ranger 2.3, 5-speed manual
After market ARA A/C - No longer working
Blower motor heating coil element caught on fire - heater no longer working either.
Most days, before I drive somewhere, even just a few miles or less, I have to put in a little coolant, about one or two cups, So I know there is a leak coming from somewhere, it's just not visible, but strangely dripping from my right side front fender wall, just below the air filter, seems strange. Did not see any tiny leaks from my radiator.
What I have done was to check hoses from the radiator to the engine and noticed no leaks. Is there anything else I could do without a major repair? I even used that stop leak a while ago, but that didn't work.
A few days later.. Ok, when I got home today, I noticed antifreeze dripping from that shield over the right side passengers wheel well. I crawled underneath and on the other side of the tire, and did not see anything as the source. I would think that it would be in the area of the radiator, either upper or lower hoses, or that short hose to the block near the water pump. I will check the heater core hoses going from engine area into Firewall again. But I did not see anything leaking from that right side firewall. I have an aftermarket ARA AC, bit that hasn't worked for years.
If the leak is not coming from the head gasket, upper or lower radiator hoses, or those two hoses going into the firewall, where else could it be coning from? Very strange it's not anywhere near the radiator or engine, but on the right side passenger's side, above the tires wheel well. Some have said it has to be from either those two heater core water hoses going into the firewall.
I have neither a working air conditioner (after marker ARA) or a working heater (leaves found their way from the outside hood vents into the Blower motor and EVAP core and the heating element caught some leaves on fire and burned mostly everything inside this box. I have not replaced that, nor would I at this point,but just want to fix the leak)
A friend suggested that I could just BYPASS the water hoses going into the firewall....is this plausible? Do I do next to the inlet/outlet hoses bt the water pump. or somewhere else?
Ford - Explorer :: 1993 - Leaking Transmission Fluid
I took my 1993 Ford Explorer for an oil change they told me I also needed a rear differential service and a transmission service, so I told them to go ahead (this was on a wednesday). On friday the car broke down leaking transmission fluid (reddish oil). The clutch was making a sound when pushed in and we were not able to shift. I towed it back to the place where the oil was changed the gentelman open something under the car and he said that it had transmission fluid. He got on the car turned on and push the clutch when he did that a lot of fluid began coming out (reddish oil). He said it was the clutch that went out. We think they messed up the transmission. I towed the truck to a garage and the guy mentioned something about a plug related to the transmission. Could the oil people have done something wrong to the transmission that made the car break down???
View 4 RepliesFord - Windstar :: Small Metal Tube Is Leaking Coolant?
1999 Ford Windstar started overheating. I discovered coolant leaking from a small metal tube coming out the top of the rear right (drivers side) of the engine. There are two similar small tubes. This one appears to be corroded through. I tried to pull it off, but if felt like it would break off.It's pretty far back and somewhat difficult to access. I'm wondering if this can easily be replaced and if so, how would I go about it.
View 7 RepliesFord A/C :: 1992 F250 Truck Overheating And Leaking Coolant
I have a 92 f250 4x4 351 windsor, so I had a hose bust the other day that ran from one side of the intake to the other, I mean completely split down the side. The engine overheated when this happened so i replaced the hose and everything seemed fine until i was heading home and it started to overheat. Being frustrated and angry i noticed that the heater was blowing out cold air when it was overheating and that the top radiator hose would run flat when i popped the hood, but no coolant would run thru it until it overheated and sucked it back up or something. But I then changed the water pump thinking it was that but it wasn't, so then i suspected a stuck closed thermostat. I changed that and coolant still isn't running thru top radiator hose and now I am leaking coolant from what could be the thermostat gasket or somewhere else im scared and want to fix this problem.
View 10 RepliesFord Excursion :: Coolant Leaking Right Behind The Front Passenger Fender Well
Alright, yesterday while I am at work, wife calls me up and tells me the Ex is leaking coolant. I got home a little before dark and looked at it. Right behind the front passenger fender well, it appears that either a bolt came out of a bracket, or someone took it off for something and was too lazy to put it on, allowing the metal elbows to swing over and rub on a bracket. So now I have a hole in that elbow, and I need to the excursion for our trip over Christmas leave. Where I might get an elbow to replace that one? Also, need to know the bolt size for that heater hose bracket to keep it from happening again? If I can't find one pretty soon, I will have to JBWeld or something it temporarily to hold us through until after Christmas.
View 6 RepliesFord F-150 - 1997-2003 :: 2000 - Coolant Started Leaking?
My 2000 F150 started leaking from a small pin hole in the coolant bypass pipe that is located on the top / front of the intake manifold, it is the pipe that flows toward the heater core. I decided to remove it without pulling the intake "being lazy". I almost had it and it snapped, while trying to retrieve the piece that was still in the hole It broke and part fell into the intake, I assume into the head in one of the coolant ports. I have removed the intake and still cant seem to see it or retrieve it. I have tried a shop vac, and a magnet wand, still nothing. While pulling a vacuum I noticed that I had flow / suctions from all my cooling ports on both heads, the line from the heater core, and even my top radiator hose.
So I guess my question is, If I cant get this out and it fell into one of the water jackets in my block will it hurt anything??? I know rust and other things end up in there anyway. I still haven't given up on removing, I am really in need of answers,, in case I cant remove it. I do know the flow of coolant is up through the pipe I was trying to replace, and either through the heater core (hose), thermostat, or maybe the bypass back to pump.
Ford 7.3L Power Stroke (1999-2003) :: Oil / Coolant Leaking Down
So just a couple hundred miles ago I changed the oil and oil filter in my 99 7.3 ... It wasn't till today I noticed an oil/coolant leak ... It is on the driver side of the engine by the oil cooler ... "It isn't the oil cooler leaking already checked"... It seems to be behind the water pump to the driver side of the hpop... Where the thermostat is it is like right behind that but I can't think of what it is .... Its not the oil pump leaking ... It is leaking down and being blown back across my oil pan and oil filter... That is the oil cooler it has residue but its not the problem
View 5 RepliesFord Excursion :: Coolant Leaking Above Passenger Rear Tire
I'm 650 miles from home in WV and the truck overheated and I saw coolant leaking from the area above the passenger side rear tire.
View 9 RepliesFord F-150 - 1997-2003 :: 2001 - Coolant Started Leaking
I have a 2001 F150 5.4 triton. It recently started leaking coolant so i stopped driving it until i could get it to the shop. The day i took it to the shop, i stopped 3 times and checked the coolant level and i kept it full while driving it to the shop. The mechanic that was fixing it kept putting it off and had an excuse every day why the truck wasn't ready yet. It stayed in the shop almost a month for him to put a new intake on the truck. The truck ran fine on the way to the shop. I finally got tired of excuses and delays so i went to the shop and asked him if it was ready. He told me now the motor is rurnt and water is getting in the oil.
I checked the oil before and after i got there and the oil had no water in it. He cranked it up and the motor had a loud rattle in it. He wants to rebuild it. I want everybody's honest opinion about this deal. Do yall think the motor just burnt up or do y'all think he could of screwed the engine up on purpose to make more money because i always pay on time? Like i said, the truck had 200,000 miles on the motor but i never once had a lick of engine probs. I just think he could have accidentally or purposefully messed the engine up.
Ford - Explorer :: 2003 - Water Leaking From Dome Light?
My 03 explorer leaks water from the dome light and from the mounting bracket for the sunvisor on drivers side when we have a heavy rain. I have had back to the dealer 4 times. They have resealed luggage racks twice and cleaned drain holes for sunroof twice. The body shop manager has told me he has fixed hundreds of these and he has also told me that all sunroofs leak. The most recent visit I was told not to park on an incline. If I knew that this vehicle could only be driven when the sun was out , I would have never bought it.
View 11 RepliesFord - Fusion :: Coolant Reservoir Leaking At Top / Squeak When Start Driving
I've had a issue since I've owned my 2015 purchased new that I didn't get a chance to take in again until recently. I have a little fluid that leaks out of the Hybrid coolant reservoir. This is not the one attached to the radiator for the ICE, I have an issue with the hybrid component one. When I first received my car the fluid was above the full level. After a few times wiping it up I stopped by and had the dealer remove the excess fluid from the reservoir until it was at the MAX line. After a little while I noticed some fluid continued to seep/leak out and I'm at the low line now. I recently took my car in again to take care of a few things before the bumper to bumper expires. When I received the car back I didn't fully review my paperwork until I got home. I saw the comment that "Normal characteristics of the Hybrid cooling system" ...
A second issue I have is I get a squeak sometimes when I start driving the car. Sounds like it's coming from the front wheel, it's not a constant squeak, but one that happens with each rotation of the wheel. They were unable to recreate the issue as it's random. Brakes were checked and no issue found. I'll have to see if I can get it to show the issue for the service rep.
Ford - Mustang :: 2006 - Coolant Leaking / White Smoke Come From Under The Hood
I have a 2006 v6 ford mustang and just developed this problem yesterday.
When I drive the car, the temp guage stay right in the middle, but when I park I get white smoke come from under the hood. I popped the hood and saw coolant leaking from where the top radiator hose meets the engine block. This was producing the smoke. When I checked the hoses, the top hose was hot and hard, the bottom hose was cool and soft.
Extra info:1. I did not touch the radiator to see if there were cool or warm spots2. The overflow bottle looked empty or close to it, but the engine was still hot from driving to work
Thinking this could be one of the following:
1. bad thermostat
2. clogged radiator
3. Air bubble somewhere blocking the coolant flow
Ford Ranger / B-Series :: 1991 - Bad Head Gasket - Leaking And Coolant In Oil
I have a 91 Ranger V6 4WD with 150K that has been sitting for 7 years. The last time I drove it (7 years ago) to a mechanic, who diagnosed it with a bad head gasket - leaking coolant and coolant in the oil.
What am I looking at as far as a project: besides redoing the head gasket, what else will I most likely need to do given that its been sitting 7 years?
Ford 6.0L Power Stroke Diesel :: 2004 - Fuel Leaking Into Coolant
I recently was informed by my local mechanic that fuel was leaking into my coolant. He said I had a cracked head based on this and it would give soon. Well, he was right, and now I need to do a head job. I found new heads, but would like to know how many book hours this should take before I proceed. He gives me a wide range of time, and don't want to get taken advantage of.
View 4 RepliesFord A/C :: 1997 E350 - Rear Heater Line Leaking Coolant
I just purchased an 97 E350 (15 Passenger) and I notice that the two rear heater lines (along the driver side) are rotted and is showing sign of minor leakage. Can I simply replace them with rubber heater hoses or do I need to get the factory heater lines?
View 6 RepliesFord A/C :: 2008 Ranger - Coolant Low / Heater Control Valve Leaking
Bought my Ranger brand new, and I try to maintain it well. Most of the 90,000 miles are highway. Anyway, the OEM coolant was supposed to be good for 100K miles, but since I hadn't done anything in 89K, i have a lengthy commute and the coolant was getting discolored, I figured that no harm would come in having a drain/refill. This was approx. The heat worked flawlessly. Fast forward two weeks, and my local shop performed an oil change (not the quick lube that did the coolant replacement). I was informed of three things:
1) my coolant was low,
2) my heater control valve was leaking (which I was shown), and
3) when hoisted I was shown that a slight residue of coolant -- not necessarily fresh -- was on my water pump.
I was told that 'down the road sometime a water pump could be in my future'. Again, the heat worked flawlessly, and I didn't want to be out-and-about in winter and run out of coolant. So, the shop replaced my heater control valve and topped off the coolant (approx. 1/2 - 1 gallon). Heat worked flawlessly. The last couple days, I noticed two things.
First, heat trickles out on low and medium setting, and second, it takes a long time to warm the vehicle. So, my limited research tells me two things. If coolant is present, and I have heat (of some sort), then, the water pump and heater core are probably fine. Diagnosis says to check the thermostat first, correct?
Ford Excursion :: 2000 V8 - Whirling Noise / Radiator Leaking Coolant?
Today while I was working I walked back to my truck after finishing the job and saw a red fluid leaking from behind the front bumper, I crawled underneath and saw that it was leaking from somewhere between the plastic cover for the fan and the radiator but I couldn't find exactly where it was coming from, I drove 30 miles before I got to the job site with my ac on, and my ac was making a noise that seemed like a whirling noise but I kinda brushed it off as the condenser going bad or whatever. After I found my truck leaking I decided to drive 20 miles to the next job site but this time I left the ac off and nothing happened the temperature gauge didn't even go up, I checked underneath when I finished driving and there was no more coolant leaking from the radiator. I drove it an additional 50 miles before I got home and still no leaks. Could the bad ac system cause coolant to leak? I have a 2000 excursion 5.4L V8
View 14 Replies