Ford 6.0L Power Stroke Diesel :: Leaking / Burning Coolant But No White Smoke
Last week I noticed I was having to refill coolant in my excursion more than I should. I hae a mechanic friend now trying to diagnose the problem. he said he doesnt think its the water pump and there's no white smoke. Are there common leaking places for the coolant on 6.0s he should be looking for?
View 4 RepliesGolf IV / Jetta IV :: Overheating - Coolant Spraying Everywhere Causing White Smoke Under The Hood
I have a 2002 VW MK4 1.8t. It has 172,000 miles on it. Since i bought the car i have had to add coolant from time to time due to leaks from various plastic coolant parts so I replaced the crappy plastic connectors and flanges as they failed but it has never overheated till a couple days ago. It rose up to about 210'F but I didn't let it get to 260'F (aka the red zone).
While the temperature was up, the coolant was spraying everywhere causing white smoke under the hood. I stopped and looked under the hood and came up with the conclusion it was the coolant flange that holds the temp sensor since it was leaking coolant from the flange like a faucet hince the reason it caused it to overheat due to lost of pressure and no coolant in the system. So I replaced the part and gaskets then checked for other obvious leaks.
No leaks are shown nowhere else in the vehicle. So I added coolant to the car and let the cooling system do its magic as i left the heater on high. Let car idle with cap off and heater on for about 45 minutes. No signs of overheating. So I take the car for a spin and that's when the car starts heating up. I look under the hood and feel hoses and notice all are pressurized but top hose that leads to coolant flange is hot and the bottom hose connected to thermostat is cold.
I checked the return hose that leads up to the coolant reservoir to see if it's cycling and it appears it was. At low rpms the return hose had a steady flow and at high rpms it was flowing much rapidly. Which made me think it wasn't the water pump also this car with that many miles wouldn't have lasted with the plastic impellar this long if it wasn't already swapped out by previous owners. My question is what would cause it to still overheat? I forgot to note the fans did not turn on when the temperature was rising unless i turned the a/c on. But i still did a drive test with a/c on and it still overheated. I also did multiple burp cycles. I have invested alot of money in custom work and suck to leave it parked on the drive way.
Ford Super Duty (1999-2016) :: 2005 - Blowing White Smoke And Leaking Coolant
My truck is a 2005 6.0 with no after mods and has 73000 miles on it. It began to blow white smoke out exhaust. I changed out the egr valve and cooler. After putting back together it then blew white smoke ran it to clear out. This worked however once it warmed up it began to blow thick white smoke at 20 mph and clears up by the time it reached 30mph and white smoke shoots out at rapid acceleration. As well there is coolant leaking out under the truck from somewhere in the motor about in the center. I am looking to work on this myself as I have heard of owners taking it to shops and paying a lot of money for the prob to not get fixed.
View 7 RepliesCadillac - Cts :: Coolant Leaking / Smoke Barreling From Under The Hood
Recently my 2003 Cadillac CTS has been leaking coolant at a faster pace than I could ignore. After noticing smoke barreling from under my hood, I decided to research the problem and attempt a DIY repair job by replacing the auxiliary coolant pump. After purchasing the part online and reviewing any forums I could find, I was determined to prove the naysayers wrong by undertaking the task over a free weekend. After a couple of hours I soon realized that this was a two man job. Still alone at the 4 hour mark, I was almost resigned to having it towed to a mechanic with all sorts of wire connections still unplugged. Resigning to give it one more college try I tempted the father-in-law over with the promise of all the beer he could drink. After another 4 & 1/2 hours 'without draining the coolant beforehand :)' we had successfully accomplished the mission (almost) impossible. So all in all, this chump (myself) spent almost 9 hours to perform this complex vehicular operation. My question is, for this part (an aux. coolant pump) how long would a certified, classically trained mechanic take to make the repair?
View 5 RepliesFord 6.0L Power Stroke Diesel :: 2006 - White Stuff Around Coolant Cap - Leaking?
2006 6.0l
Just noticed yesterday during an oil change that I had white stuff around the coolant cap on the overflow bottle and that no coolant was visible. I went and got some antifreeze premix to top it off and it only took around 1 quart. Today after driving it approx 30 miles, the coolant was again missing.
When I changed the oil the other that same day there was no coolant in it, and I don't have any puddles on the ground. Whats going on?
EGR is deleted with a sinister kit, temps are fine, today it was 94 degrees and the truck was running at 194 oil 192 Coolant when getting off the highway after 15 minutes doing ~75. I've got a little bit of stiction going on but besides that nothing seems wrong.
Ford 6.0L Power Stroke Diesel :: 2006 F350 - Coolant Disappearing Out Of Reservoir - White Smoke
Ok I bought a 2006 Ford F350 with 6.0 after driving for about 3 weeks I noticed a little bit of coolant was disappearing out of reservoir. So yesterday I was driving with a load Reservoir overflows replace coolant with one gallon of coolant and finish trip with no issues. I started truck today and it will not stop smoking it is also not overheating after hearing about head gaskets. I'm hoping it might be EGR cooler white smoke smells like raw diesel fuel. What to do?
View 3 RepliesFord - Taurus :: White Smoke Coming From Hood / Shutting Off And Making Knocking Noise?
My mom was driving to pick me up and she said that all of a sudden about half way here that the car started making a knocking sound and white smoke started coming from hood, the car was also trying to shut itself down while she was trying to pull over. It is a 2000 ford taurus with like 130k. I am so scared that it is the head gasket because my mom, myself and my daughter, and my 16 year old sister all share that car to get around. Is there anything else it could be besides that or is that probably what it is?
View 19 RepliesFord Ranger / B-Series :: 1997 - Breaks Down On Highway - Major White Smoke From Under The Hood
I have a 97 Ford Ranger / 2.3L / 4 cylinder (L4) / 5 speed manual / XL Supercab / 140k miles. I had been having some Check Engine issues and ran rough in town stop light to stop light. But was fine on the highway.
On several visits to the parts store, their OBD tester showed:
PO303 (Cyl 3 misfire detected)
PO141 Bank 1 Sensor 2 O2 Sensor (heater circuit malfunction)
PO171 Bank 1 Combustion Too Lean (the most recent new code to show up)
And the following would show up sometimes, but other times not:
PO 402 EGR Flow - Excessive Detected
P1409 EVR (I cant remember the exact error message for this)
Regards the PO141 code, O'Reilly's sold me a Bosch O2 Sensor (Bosch 15719) and the sales rep told me it was the sensor closer to the engine. And with the attached cable length on the sensor showed was indeed the sensor closest to the engine. But I've been advised the Sensor 2 is for the 'downstream' sensor, furthest away from the engine. And the other sensor, that I replaced is the upstream sensor. And the error continued.
Then back issues showed up and I had back surgery this past year and thus drove the vehicle sparingly. Never resolving the check engine issues. (My bad). Ran on the highway ran fairly well. But recently noticed longer acceleration times and unable to top 65 in 5th gear. I bought spark plugs and plug wires and had plans to change next week.
Yesterday as driving down the Interstate, was 90 miles into my trip, I noticed loss of power even in fourth gear. (note it was the hottest day of the year at 100F). It seemed I used more gas than usual for that distance. I stopped for gas on the Interstate and power seemed to improve. Then about 130 miles into my trip I hit some heavy stop and go traffic, and wasn't able to keep an idle and the engine died numerous times if/when I didn't give it gas at a dead stop. The heavy stop and go heavy traffic and the issues persisted for a half hour for more than five miles. Then when traffic opened up the truck seemed to have a bit more power in 4th gear again. And up to that time all my dash gauges were showing fine. Then a couple miles or so down the interstate, driving 65mph in the inside lane, the check engine light started flashing quickly. And at the same time a sudden loss of power, rough sounding engine with heavy white smoke coming under the hood. And looked back in rear view mirror, with nothing but heavy white smoke. Managed to cross three lanes in heavy traffic and was able the vehicle to the outside emergency lane, finally coming to a stop.
Looked under the hood and saw oil dripping everywhere but with all the oil everywhere I could not find a prime source. Looked like the oil came from the top end of the engine and dripped down. Measured the oil at the dipstick and it seemed like I was at least a quart plus down (I checked the oil before I left on the trip). And it didn't look like any water was in the oil. And my radiator overflow tank was at the proper level. So I figured I lost all that oil during that period of "white smoke".
So had my vehicle towed home. Today in daylight, I did some more inspection and removed the air intake system (hoses and canister) from the air filter to the throttle body. There was significant oil up to the canister piece that fits on the air filter canister (but no oil in the actual air filter), and significant oil inside all the hoses up to inside the throttle body (up to the butterfly which I could see),
When I disconnected these hoses I noticed the blow-by hose connected to the intake hose system was not connected to anything. And a tube opening on the valve cover was open without the a blow-by hose attached and, with no clamp. So I assume all that oil and came out of that blow-by tube on the valve cover, (white smoke created by hot oil hitting the engine).
So appears to me that its not a blown head gasket or worse, which I first feared.
I have the vehicle parked at home.
QUESTIONS: So what are the suggested steps to troubleshoot and repair? Besides reattaching everything and putting a clamp on the blow by hose? And installing new spark plugs and plug wires. I previously replaced plug wires around 60k, even though the manual recommended 100k mile replacement. (And a couple yeas back I had the dealer replace the PCV, which was recommended in the manual and included in the warranty. The timing of the initial check engine lights appeared shortly thereafter).
Is there suppose to be a large amount of oil in the air intake system after an incident like this and should I try to clean/flush out the hoses and the inline canister?
When I disconnected the inline canister from the hoses in the air intake system, unfortunately I failed to document the direction which the canister goes. It has outside markings "ADP with a forward arrow with some horizontal lines, and then at the other end upside down markings with a greater sign PP less than sign. Should the forward arrow point toward the throttle body or toward the air filter (I'm thinking in the direction of air flow, toward the throttle body). I've taken some photos of the engine with air intake hose system unattached, if that might work...
Passat (B5) :: White Smoke Coming Out Of Hood When Engine Turned Off
I've got this weird problem , it started a month ago. Sometimes I would drive for half a hour, park the car, stop then engine and some white smoke comes out of the hood after a few seconds. But sometimes I can drive the same amount of time, park, stop the engine but no white smoke.
The only time I did notice it happening is when my temperature gauge isn't working properly , sometimes it will give the right reading (which is right on the middle) and while driving it will drop to 0. Also sometimes there is a smell of rubber burning I think (Doing my best here). But I've checked Google for people with my problem but all I read is either people with tail pipes issues or smoke directly in the drivers cabin. My white smoke is only when I kill the engine. There is no smoke coming out of the tail pipe nor in my cabin. Only a rubber burn kind of smell.
Elantra XD (2001-06) :: Chugging And White Smoke Coming From Under The Hood
My wife just sent me a text saying she noticed her car (2005 Elantra GT, auto, 140k) making a chugging sound and then saw white smoke coming from under the hood on her way to class.
I'm at work, so I'm trying to pinpoint the problem from my office, but I'm guessing the white smoke is the result of a coolant leak? Bad seal somewhere? What would cause the chugging that's related to a coolant leak? Or maybe it's not coolant-related at all.
Toyota - Camry :: White Smoke From Under Hood And Burning Smell
Yesterday I made a 3 hour round trip with my car, and on the last leg coming back into town, I noticed my check engine light came on, and I saw white smoke coming from underneath the hood of my car, along with a burning smell. Luckily I was able to make it home just fine. I've googled this issue, some people have suggested coolant leak.
Also, I checked the oil levels today and they appeared to be slightly below the lowest level tick, which could be why it was having issues yesterday. Last time I got an oil change was November of 2015. I'm surprised it's this low considering I normally don't commute farther than a couple miles each day.
Ford Excursion :: White Smoke All The Way - Coolant Level Never Dropped
Tonight we left baseball field and my 2005 excursion was white smoking all the way home. I Stopped Several Times And Checked Coolant Level And It Never dropped. I let it sit for a hour and coolant level is still at my black mark. So does this mean it's a injector? It poured down raining so I'll have to wait till morning. Will scanguage show any codes for injectors. If so I can program in the morning.
View 5 RepliesFord Excursion :: Coolant Loss And White Smoke From Tailpipe
I was having an issue with coolant loss and white smoke from tailpipe. Was told it was likely intake leak vs headgaskets. Changed intake gaskets, fixed the issue for a day then it started just dumping coolant from every available place in the exhaust system. Was draining a full collant bottle in about 2 minutes. Was also checking for exhaust in the coolant with the tube and blue liquid which it stayed blue. Had previously done a degas pressure test and it passed. The only test I hadn't performed was compression test which all the cylinders output was lowest 160 to the highest about 185. Did not perform a wet compression test as I was mainly looking for base compression and consistency.
Not sure what healthy is on these vehicles but considering they were all running pretty close I call it good. Also it idles just as smooth. Pulled intake a 2nd time and rechecked my previous work. Everything looked fine so I put it back together. Ran smoke free for about 50 miles now I'm back to smoke after it sits a bit but it clears up after a short drive. What am I missing? I will note that I had a small coolant leak from drivers side rear of engine that I noticed while it was parked in the shop. I'm assuming that would be the oil cooler? But oil is clean so it's not mixing. What other avenues on these engines can coolant make it into the exhaust? Drives perfect with no power loss.
Hyundai - Sonata :: 2004 - Possible Oil Leak And Now Noticing White Smoke From The Hood
I drive a 2004 Hyundai sonata. Last time i had an oil change they told me there is a small oil leak. I have yet to fix the leak due to lack of funds. I drove to work today and a co worker noticed after i got out of the vehicle that there was white smoke coming from the hood. I have checked my oil and my coolant and both seem to be fine. I have not checked the resivour yet( should i? ) My question is do you think the oil leak is what is causing the white smoke along with a slight burning smell? Or possibly another issue? I am having it check this weekend however until then i wondered what i could do to avoid overheating if you think that may be the cause of the smoke as well?
View 3 RepliesMazda6 :: 2004 - White Smoke From Under The Hood And Temp Gauge Spiked
2004 Mazda6 V6 auto with 220,000 miles on it. Yesterday, in rush hour traffic on the highway, saw a puff of white smoke from under the hood. Tried to get over to the right- by the time I got over, I'd passed the last exist before the Baltimore Harbor Tunnel.so had to keep driving till I could find a safe spot to pull over.
Temperature gauge spiked, so I turned on the heat, on full- and got cold air coming out. Temp gauge then dropped to cold, and all dashboard warning lights lit up. Small antifreeze puddle under car.....had it towed home. Truck driver was able to get it started long enough to roll it off the truck into parking area.
How badly I damaged engine by continuing to drive the 2 miles through tunnel?
Prius (Gen 2) :: 2005 Stalled - Clicking Sound And White Smoke Coming From Under Hood
I have a 2005 gen 2 Prius, 106k miles. Recently in Florida, we had a heavy rainstorm, and I happened to drive it through a flash flooded road. Water was deep enough to reach my headlights. I was out within 10 seconds, then had my car towed. There was a clicking sound and white smoke (steam?) coming from under the hood. The car would start, and I could drive it if I wanted to. After talking to a mechanic, he said to let it sit for 30 minutes with the engine on. Like magic, it started to work like normal, check engine light went away.
Drove fine for 2 days, then the check engine light came back on. Had the codes read at autozone: P0103, and P0031. One day later, my car stalled out while I was driving, and the dashboard lit up like a Christmas tree. Red triangle, yellow exclamation, brake, abs, "problem" on mfd, etc. This site has saved me before, so I came on and thought it could be the MAF sensor. I cleaned it with MAF cleaner, but no luck. I order a new sensor, still no luck. My car stalls out seconds after starting it up. I cleaned my throttle body, still nothing.
Impala - Chevrolet :: 2001 - White Smoke And Pop Noise From Under The Hood On Driver Side
I am having a problem with rough starts/ normal starts. This issue is intermittent. Once in a while when turning on the car I'll get white smoke and a pop noise from under the hood on the driver side. It smells electrical in nature. Other times like 80% of the time it starts normal. Also I have an issue with some of the cluster panel being lit while other are dimmed slightly. What is the cause of this problem? Where should I start to look to fix these issues? 2001 Impala LS 3.8L .........
View 4 RepliesFord Excursion :: Smoke Started Coming Out From Under The Hood - Trans Fluid Leaking
I have a 2000 2wd with the 5.4 in it. I tow a travel trailer and loaded is 6500lbs. Today leaving the campground I had to climb an extremely steep hill as soon as you left the campground. No time to build speed. The old Ex made it, but I was definitely worried. The truck ran fine the rest of the 2 hours home. I went to back my camper into its spot to store, and smoke started coming out from under the hood. When I crawled under it, tranny fluid was leaking on the ground. A pretty steady drip. I let it cool down, added fluid and drove around. Didn't leak anymore. Did the tranny just get hot and had to burp? The drip was coming from where the tranny connects to the motor.
View 8 RepliesLexus ES 2007-12 :: ES350 Antifreeze Red Fluid Leakage - White Smoke From Right Side Of Hood
Light film of white smoke from the right side of the hood wheel underneath the passenger wheel an slightly from the front no antifreeze in vehicle at the moment car parked an not driven since the altercation.
View 12 Replies