Ford Excursion :: 2000 - Leak At Fuel Filler Pipe
Just drove home a 2000 Limited from a used car dealer in NH to MA. Half way home, I stopped to gas up and noticed I was losing a small amount of fuel while pumping. It appears to be leaking from the filler pipe just before the tank, but there was too much splatter to tell for sure. No leak when not pumping, but the tank was only half full.
The dealer "guarantees" that the truck will pass MA state inspection. I'm sure a rusted out filler hose would result in a failure. The "guarantee" really means that he will buy the truck back should it fail, which is not really doing me any good b/c I'll have to start looking for a new truck all over again.
I'm unable to find a part # or pic of a filler neck for the Excursion. Is it the same as other Super Duty necks? Is this thing welded to the tank? That sounds like an involved, difficult fix.
Accent LC (2000-05) :: Leak In Power Steering System
2002 Accent GS, automatic 1.6L engine ... Have a leak in the Power Steering system and I was wondering if it was safe to take the Power steering pump belt off just to get to my mechanic (who is about 18 miles (27 Km) away). I would rather not get towed, but I don't want to do any damage either. I am not all that mechanically capable but think I can get the belt off myself.
View 4 RepliesFord F-150 - 1997-2003 :: 2000 - Coolant Leak On Right Side Of Cross Over Pipe
I have a leak on the right side of the cross over pipe. I removed one long bolt from the right side and two long bolts from the left side that go through the thermostat housing, and three bolts from the back of the alternator, but the pipe doesn't seem to want to move. I don't want to break anything.
View 2 RepliesFord Excursion :: 2000 V10 - Overheating / Gasket Leak Into Cooling System
I borrowed a friends 2000 Excursion with the Triton V10, along with his 3300lb, 28' trailer to tow a car from Ashland, OR to Reno, NV to begin a restoration project. His Excursion has 175,000 miles on it and made the trip down flawlessly, but as they say, "No good deed goes unpunished." When attempting to return last Sunday, had to turn around due to overheating problems. Analysis at a local automotive shop concluded a bad radiator cap. Attempted the return trip Tuesday and the same thing happened (only got farther due to the new cap and ability to hold pressure longer).
Finally got into a Ford dealer and have been informed that the truck has a bad head gasket causing pressure to leak into the cooling system. They suggest replacement of with a remanufactureded engine as opposed to replacing head gaskets, due to the time on the entire engine (who knows what else might be bad?). The vehicle can be driven around town for miles with no problems. But put that heavy load on it and grades and it spews out nearly "all" of the coolant.
Accent LC (2000-05) :: 2003 - All Metal High Pressure Power Steering Line Has A Leak
I have an 03 Accent. The all metal high pressure power steering line had a leak. So I bought a new one for around 70 dollars from Hyundai. This part has a curved shape and fits around the radiator. The old one was difficult to get off, but the new one is proving impossible to get on. I cant get it into place.
View 2 RepliesVenture :: 2004 Chevy - Power Steering Cooler Line Leaking
I picked up this 2004 Chevy Venture for my daughter and it has a power steering fluid leak coming out of the power steering cooler line that runs along the frame in front. I know that the procedure to replace this line calls for disconnecting the intermediate shaft of the steering and lowering the subframe to gain access to the line connections on the rack. My question is, is it possible to replace that line without lowering the subframe? I ordered the new line and it's on its way. I wanna do the job right.
View 3 RepliesFord 6.0L Power Stroke Diesel :: Installing Y Pipe - Bad Exhaust Leak
Over the weekend I replaced the passenger side up pipe with one that doesn't have a spot for the EGR cooler. After putting the turbo back in it has a pretty bad exhaust leak. Sounds like it is on the drivers side somewhere near the Y pipe. When replacing the passenger up pipe I didn't loosen any manifold bolts or anything and I am thinking that the Y pipe is out of alignment with the turbo. What is the proper procedure to loosen everything up and get it aligned on the turbo? My guess is remove turbo, loosen drivers side manifold, loosen passenger side manifold, loosen passenger up pipe and tighten it again now that everything isn't under tension, install turbo and clamp to Y pipe, tighten manifolds. Is that the right idea?
View 8 RepliesChevrolet - Venture :: 2001 - Burned Cooling Fans Connector
2001 Chevy Venture: Pins to 2nd fan in 4 pin connector burned and melting to connector. Fan seemed to work when wiggling connector. Bypassed connector and now does not work unless A/C is turned on Full Speed. Is connector important? What controls fans? Computer controlled? Seems to be larger gauge wire in one side than the other.
View 2 RepliesVenture :: 2004 - Power Steering Feels Tight / Fuel Level Is Good
I have a 2004 Venture where the power steering feels tight. Fluid level is good. No leaks (had it repaired a year ago where line was leaking, and now repaired).
Turning the wheel under most circumstances feels pretty normal. However, say, doing parking maneuvers SOMETIMES feels like I have non-power steering for maybe a quarter turn, and then it picks up again.
Venture :: 2000 Power Sliding Door Stopped Working
Long story short it stopped working. I have tried the reset method with no luck and I can't seem to get it to give me the codes per the factory service manual. This is what I do know when you release the door it unlatches but won't open, I can hear the motor trying to run but it won't pull the door open and it sounds like it immediately reverses but the door does not move.
View 14 RepliesFord 7.3L Power Stroke (1999-2003) :: Oil Leak Near Driver Side Up Pipe
Small oil leak looks like coming down by drivers side up pipe. I don't think it's the turbo o rings. Better not be. But could be I guess. Anyways. It runs down somewhere by the up pipe down onto transmission. I'm not loosing tremendous oil or anything.
View 14 RepliesFord 7.3L Power Stroke (1999-2003) :: Exhaust Leak At Passenger Side Up-pipe To Manifold - P1211 And P1280
I just finished installing a new turbo (shaft play and lots of oil in the compressor side), RR up-pipes, and T500 (250k and once had a very long crank to get the ICP up to start).
Anyway, except for another exhaust leak at the pass side up-pipe to manifold, it seemed to run okay but with lots of white smoke. I only have about 50 miles after the install, when it suddenly starting surging and made a lot of loud knocking noises. This then went away and came back again rather quickly. I was close to home, so I made back under power. I also received the two codes listed. My IPR is original, but two summers ago I installed the IPR re-seal kit. Everything on the IPR looked good when it came off for the T500.
After reading around, I saw that low fuel pressure / air in fuel can cause problems. I connected a pressure gauge to the pre-filter port on the filter housing, and got 40psi at idle. I then took a diesel shower and blew out the fuel line into the tank. After re-connecting it, the fuel pressure stayed the same but the engines idles much better, but still has blue smoke. It's the original fuel pump (to me anyway) and original fuel line connections.
I have about 3/4 tank, and no place to put it, so I'd need to run it out for the Hutch mod, or least to get in there and inspect. Would eliminating the Ford connections at the pump be worthwhile for now, and is 40psi at idle adequate? Wondering if it's time for a fuel pump?
Ford 6.7L Power Stroke Diesel :: Secondary Cooling System Leak / Dripping From Center Of Engine Bay
Turns out I've lost nearly all of the coolant from my secondary cooling system and am trying to diagnose the problem.
Things I noticed:
-All of the hoses appear to be in good condition.
-Coolant is dripping from the center of the engine bay.
-After inspecting the turbo area, it appears the valley below the turbo is wet.
The intake manifold is still on the truck, so I haven't been able to get a better look. Is there anything else near the area I am describing that has coolant? My guess is the turbo water inlet?
Perhaps this : Coolant leak on the 6.7 Powerstroke diesel - YouTube...
Celica :: 2002 - Power Steering Cooling Loop Cracked And Leaking
I have a 2002 Celica GT and the cooling loop on the power steering that runs out in front of the radiator (or AC condenser) is cracked and leaking. I need to replace it, I have a few questions:
- Where to get a replacement, likely Toyota?
- Find out how much work it is to replace myself?
- Does the system auto bleed any air or will I have to bleed it?
Passat (B7) :: 2012 - Loud Whine While Turning Steering - Power Steering Leak?
I noticed over the last week that there was a pretty loud whine associated with turning the steering wheel. I checked the fluid level and it didn't seem low. I added a touch just to make sure. Took it into the dealership today and they called back and told me there's a bunch of fluid on the bottom splash pan. They haven't said what the culprit is yet. 46k miles on the car.
View 6 RepliesFord 7.3L Power Stroke (1999-2003) :: 2000 F550 Turns Over / Black Smoke From Tail Pipe But No Start
Ok I'm working on a 2000 7.3 on a F550 truck was running but had no power so we changed out all the injectors and glow plugs and rebuilt the turbo now there is no start it turns over and were getting black smoke from the tail pipe. What is going on with it?
View 2 RepliesVenture :: Coolant Leak At Very Slow Rate
Van has 144k miles on it. It's been well maintained (see my other posts). I have had it since new (7 miles). The LIM was done preventively at about 75k miles (5 years ago).
Two to three years ago it started using/leaking etc coolant at a very slow rate. I would estimate somewhere in the 8-10 fl oz per 3-4 month range. As time has gone on it has been progressively using more. Now it is about 12-14 fl oz in about a month or 6 weeks. My "low coolant" indicator came on the other night. It had been a while since I added any coolant mix. 3-4 months anyway. It took about 1/2 gallon (US). There has been no "real" visible leak,up to now. I noticed yesterday when I was under it doing an oil change, that there was a "film" on the bottom of the trans pan. I followed the trail as best I could and it led me to the rear of the engine near the drivers front wheel. It was a small drop of coolant. (I tasted it). Don't try this at home... From the top of the engine looking in, I followed the upper radiator hose to the thermostat housing "pipe". It is very difficult to see in there. I took a few pix. [URL] ....
It looks like there is a little pool of coolant sitting near or under the thermostat housing that pools on top of where the transaxle bell housing meets the engine block. It's very hard to to see in the pix. Some of what looks to be damp, is actually shadow. This pool I believe runs down the back of the engine/trans, and then is blown on top the trans pan and undercarriage.
The van runs great, I want to keep it for the next 9 years. There is no coolant in the oil, or oil in the coolant. Unless the fix is fairly easy, the leak is still small enough that I am not going to bother with it until it becomes a large leak. The car runs cool even in the hot summer pulling a load. The only issue is the leak and that I have to add coolant every once in a while.
Chevrolet - Venture :: 1999 - Antifreeze Leak - Overheating
My 99' Venture is leaking antifreeze and was overheating. Ok, so I figure it's something as simple as replace the radiator cap or something. My mechanic says it looks like my manifold gasket is due to be changed AGAIN. If I had one going into the other then I could see why we're talking oil when I'm talking antifreeze. I parked the car cause I have a second car. So the Van sits for 3 months and leaks into the pan I put to protect my driveway.
I could probably have filled a quart container with the puddle created. It looks Orange so yes it's antifreeze and yes it's SLIGHTLY milky when you shake it around. It doesn't show any sign of oil. BUT when I check the oil on the dipstick it's perfectly fine. The car wouldn't start so you'd say jump it right? Did that and nothing, bought a brand new battery still nothing. So I had it towed to a Mechanic. If he can't find it I'm going to plan B, let the dealer diagnose it, get a quote and take it from there.
Jetta - Volkswagen :: 2000 - Steering Rack Keeps On Failing - Coolant Leak?
Here are my questions.
1. What can cause repeated steering rack failures, which I am trying to dianose?
2. I found yellow spots in the snow that would come from the center of the vehicle (as opposed to near the wheels), could this be from the coolant system?
If you got that far, here is the relevant history. My wife drives my 2000 Jetta, its a nice car with repeated problems. One such problem is with the steering rack. 1. The steering rack failed in 2006, it was an expensive fix. It was leaking for a while, but I just topped off the fluid every couple of weeks. 2. Within a year the steering rack failed again, it was still under warranty. 3. 2 years later, the rack failed for a third time. I wrangled with the shop and they agreed to reduce my price for the fix even though the part was no longer under warranty. They had the car for a week trying to diagnose the problem, they said they found nothing out of the ordinary. I took the car to another mechanic a week later for some other issue, and he saw leaking from the fill plug--back to the dealer again. They said they cleaned the washers around the plug to fix the problem. No problems since then. Now its almost two years later and I have found a couple yellow spots in the snow, although near the center of the car and not near the wheels. This makes me think it may actually be a coolant leak, but I don't know right now.