Elantra XD (2001-06) :: Power Steering Leak / Fluid Below Passenger Side Of Rack
My power steering seems to have sprung a leak. There is quite a bit of fluid below the passenger side of the steering rack. The leak seems to be right below where the power steering hose comes down off the pump, gets secured to the chassis and changes to metal line from rubber. The metal line then goes into an L bend and is routed towards the driver side right where the leak apparently is.
I haven't had a chance to have a good look, as it was 10:30 at night when I parked it and looked (12km of careful city driving since it started to act up)
Is this a high pressure or return line?
The leak seems to be forward of the steering rack, so hopefully I wont have to replace it.
Passat (B5) :: Power Steering High Pressure Line Replacement?
How do you get the line back on to the rack? There is absolutely no room and I have experimented with a variety of tools with no luck. What's the trick?
View 1 RepliesHonda - Accord :: 1993 - Replacing High Pressure Steering Line?
So, I just found out that the noise my car has been making is related to the power steering. The mechanic said I need to replace the pump, two belts and the high pressure line. The car is a 1993 Honda Accord LX. I can't afford to have the mechanic fix it, so I'm going to have to do it myself. My questions are:1) how long should it take me? I'm not experienced at all. I was thinking of just doing the high pressure line as a 'warm up' to start. Is half a day wishful thinking? Any tips?
2) The mechanic said the hose is leaking all over the belts. He said it was "squirting and pouring out". I tried to duplicate the squirting by turning the wheel all the way and revving the engine. What I saw was a very small leak at the joint. So small it wasn't falling, but I'm sure it would if I waited long enough. The belts appeared dry to me, but I'm not really sure what they are supposed to look like. The mechanic said that they are getting soaked in fluid and that I might throw a belt. Anyway, so my question is how can I tell if the belts are "soaked in" steering fluid.
3) I've been told that if the belts are getting steering fluid on them they might be responsible for the loud squealing noise when turning. If I clean the belts with degreaser, and the noise stops, does this mean that replacing the leaking hose would be sufficient?
I'm making a long road trip in about a week (ca to wa). I'd prefer to deal with the replacement when I get to wa, but I also don't want to make things worse.
Accent LC (2000-05) :: 2003 - All Metal High Pressure Power Steering Line Has A Leak
I have an 03 Accent. The all metal high pressure power steering line had a leak. So I bought a new one for around 70 dollars from Hyundai. This part has a curved shape and fits around the radiator. The old one was difficult to get off, but the new one is proving impossible to get on. I cant get it into place.
View 2 RepliesFord Ranger / B-Series :: Power Steering Leak / Sensor On High Pressure Line?
I think I've tracked my power steering leak to some type of sensor on the pressure line, close to where it connects to the steering box:
I assume this is a pressure sensor? I got no CEL or anything like that when the fluid had leaked down to the level that the pump started whining pretty badly though. As far as I can tell by looking at pictures, the parts store replacement pressure lines do not have this sensor, or any provision to connect a sensor to it: Advance Auto Parts: Power Steering Pressure Hose by Powercraft - Part 71878
I may just put a replacement line on there and leave the sensor plug hanging and see what happens...
Santa FE SM (2001-06) :: Power Steering Return Line Replacement
I have a 2003 Santa Fe that had a corroded leaking power steering return line. I want to replace both the high pressure and the low pressure lines coming from the steering box. The high pressure removed quite easily. I cannot get the low pressure out. Everything is broken free. Is there a trick to this? I want to see how it comes out so I can put the new one in same way.
View 3 RepliesFord 7.3L Power Stroke (1999-2003) :: High Pressure Power Steering Line Blown?
I just replaced my 3rd HP power steering line last night( 3rd in 300K, always blows the same point....fitting comes apart where it attaches to the pump.
I'll start, mine have gone about 100K plus or minus 10K, almost thinking about making it a 100K maintenance item.
Santa FE SM (2001-06) :: Power Steering Lower Return Line Replacement
Looking for the instructions on how to remove the lower power steering belt and replace it. We recently discovered the leak and I can't find any information on it.
View 1 RepliesSonata NF (2006-10) :: 2009 2.4L - Steering Rack Leaking PS Fluid
2009 Sonata 2.4L ... About 60 000km ago, the complete steering rack was replaced under warranty. Now I notice the PS fluid going down in the PS reservoir. I checked for any loose fittings, all look OK. But I did notice PS droplets hanging from the steering rack boots. So today I replaced the PSF4 fluid with Amsoil PS fluid. I suspect maybe some seals are leaking. Any good product I can use to maybe stop the leaks?
View 1 RepliesGolf IV / Jetta IV :: One Of High-pressure Lines On The Back Of Rack Has Rotted Out?
One of the high-pressure lines on the back of the rack, close to the exhaust, has rotted out. It was smoking as it leaked right under the exhaust pipe and burned off. The rest of the freshly filled fluid was all over the ground. I crawled under and got a good look at the high pressure line, but where to source these, and if they are even replaceable? I have not tried to remove it yet, but perhaps a shop could bend a new one as a cheap alternative to a new rack. I was also thinking of checking out the pick n pull for a line.
View 2 RepliesPassat (B5) :: Power Steering Fluid Leak Coming From The Rack On Driver Side
Replace the seals in a power steering rack on a Passat? I recently noticed I had a fluid leak after seeing spots on my driveway. After discovering it was power steering fluid when I checked the reservoir, I checked all the lines and found the leak coming from the rack on the drivers side. The boot on the steering rack had come loose and there was fluid leaking from the side of the rack. Is there a fix for this or am I looking at a expensive repair?
View 6 RepliesSanta FE SM (2001-06) :: Power Steering Fluid Leaking
I noticed that the power steering fluid is leaking bad from a weird spot under the car, it looks like it is coming directly under the drivers seat but I can see any lines. It's an 02 Santa fe ....
View 8 RepliesSanta FE SM (2001-06) :: Power Steering Fluid Disappearing
I have very good question. My 2001 Santa Fe has 200k miles, I think the car is great. Regular maintenance, and the car drives still drives strong and comfortable.
Here is my problem: The power steering fluid is disappearing. There is no puddle under the car, I got under the car and everything is dry. However about once a week (+/- 200 miles) I have to add power steering fluid. I have cleaned the reservoir twice and confirmed that the top of the reservoir is also dry ( so is not bubbling off the top of the reservoir).
I have put newspapers under the car while parked overnight to see if there is a leak and the news paper is dry in the morning without a stain.
Fluids do not disappear. Could it be leaking while driving (high pressure hose) and its leaking from a location that I cannot see? Where is the "banjo connector" that I have heard referred to ?
Santa FE SM (2001-06) :: 2004 - Power Steering Fluid Leak From Cap
I have a leak coming from the top of my reservoir from the under the cap for some reason. I bought a new cap and it seem to stop for a day and now it leaking out from under the cap again. What is the reason it would be coming out of there. Am I going to have to replace the reservoir??
View 1 RepliesSanta FE SM (2001-06) :: Power Steering Fluid Slow Leak
2004 XG350 with the Sigma engine, 133,xxx miles.
In the picture I attached, the large silver bolt is leaking. Its a slow leak: yesterday morning I wiped it off, and then we I got home from work there was a bead of power steering fluid, but not enough to drip.
What is the best way to fix this? Is it as simple as tightening it?
Santa FE SM (2001-06) :: 2004 GLS Power Steering Fluid Leaked Out The Top Of Reservoir
I have an issue with my 2004 GLS 3.5 L w/ 68000 miles. After the SUV warms up for a few minutes I can hear a whine or rattle on the passenger side. I noticed a little power steering fluid leaked out the top of the reservoir (a few little bubbles in the oil). Then reading on the HMA website it says the filter in the reservoir can get clogged and restrict the flow. I took the reservoir off and flushed it out then replaced with new oil.
Unfortunately this did not fix the issue the noise is still there. It's most prevalent when you turn but the noise also picks up a little when you hit the gas. I have checked for hose leaks but cannot find one. My next step is to have the steering pump changed out. While the mechanics in there I am going to have him check the hoses/pulleys really close and look around for another leaks anywhere. Noise is annoying but the steering works fine.
Santa FE SM (2001-06) :: Power Steering Fluid Boiling / Foaming Leaking Out At Reservoir Cap
2.7 Power Steering Fluid boiling/foaming leaking out a reservoir cap!
1) Recently had Timing Belt/Water Pump and spark plugs/wires replaced.
2) Issue started immediately after.
3) Removed most of old PS fluid, cleaned out reservoir w/brake cleaner. NOTE: nothing appeared to be clogging reservoir. Refilled with new PS fluid. Repeated these steps a second time. This appeared to immediately resolve the issues for several weeks.
4) Now the power steering is getting rough and noisy again. Also, the PS reservoir is leaking out of the cap worse than before. It looks like the fluid may be "boiling", but it is definitely foaming up pretty badly.
What my issue(s) may be?
Santa FE SM (2001-06) :: Whine Noise Only When Turning Right - Power Steering Reservoir Leaks Fluid
I have a 2004 Santa Fe 3.5L with 85K miles. TB, WP and all belts changed at 75K. Have had this whine noise when I turn right, very high pitch noise. On top of this there is now Power Steering fluid leaking from the reservoir and base and brackets are full of fluid... Needless to say I assume it is the reservoir seals giving up but why the noise only when I turn right? No noise when I turn left.
What could it be? Also where can I find parts online that are cheaper than the stealership? I called them and they quoted me $72.00 for this piece of plastic!!
What else should I change? There is also some "oil/fluid" coming down a pressure hose but I believe this is due to the oil dripping from the reservoir...
Any manuals I could use to view this? I bought the Haynes manual and it's worthless!
Santa FE SM (2001-06) :: Hum Noise When Speed Reduced - Power Steering Fluid Leak From Reservoir
2005 Santa Fe (88K, 2.7 V6).
For a month or two, after the car got warmed up, I'd hear a whine/hum noise when I slowed to turn or reduced speed. The noise was much more noticeable when the car had been running at least 15-20 minutes, but I did occasionally hear it when the car was somewhat cool still. Never had a problem steering during this time, even with the noise... but I eventually figured out that slowing down and/or turning brought it on. So I took it to a mechanic.
They showed me bubbles coming from the power steering reservoir, and said I needed a new PS pump and pressure hose, along with a flush/new fluid. I paid for all of that.
Next day: The car would become hard to turn when I made a tight turn into a parking spot... again, not a constant thing, but only when turning to park and going slow. The noise APPEARED to be gone, but this new issue worried me so I took it back. They put a different pump on (no charge), thinking the other may have been defective.
Next Day: I hear the whine again on my way home from work. When I get home, I park, leave it running, and pop the hood. There's a fast drip bubbling from beneath the reservoir cap and running down to the pavement. First thing the next morning I return to mechanic. He says the first two pumps were the same brand and both "remanufactured" so he switches to a different brand -- this one brand new, not "remanufactured" -- and installs that one.
A half hour later, I get home. Hearing that same whine/hum, I lift the hood. Fluid is pouring out from beneath the cap in a steady, unbroken stream (not a drip, but a stream). So I took it back to the mechanic (who to his credit, has charged me nothing since the initial new pump installation). What could cause the power steering fluid to gush out from the reservoir cap when the car gets hot? I have a brand new pump and pressure hose. What could cause this condition..