Santa FE SM (2001-06) :: 2004 - Clicking Sound At Start-up
My vehicle is a 2004 XG350L with 120,900. I've got a clicking sound at start-up, especially in the cold, coming from the cam cover. It goes away after the engine is running for a while. What could possibly be causing this? How do I fix it?
View 2 RepliesSanta FE SM (2001-06) :: When Turn The Key To Start - No Cranking / Clicking And Sound
This past winter I started having trouble with my '06 Santa Fe where I would turn the key to start my car and nothing would happen. No cranking, no clicking, no sound. My lights turn on fine, radio, everything else works just fine. Sometimes it won't start for 30+ minutes, and sometimes I'll just try a second time and it'll start up right away.
Last winter when this happened my check engine light came on and so I took it to the dealership and they said it was the crank position sensor that needed replaced. For whatever reason I didn't get it fixed and have been driving my car with no problems whatsoever for 10 months or so, until this weekend when my no start issues started again. The check engine light is on again and it's the same code for the crank position sensor.
I believe I will definitely get the crank sensor fixed this time, but could the issue possibly be anything else? Bad starter? Ignition switch? My mechanic can't give me a definite answer because every time I take it to the shop it starts up just fine for him.
Santa FE SM (2001-06) :: Clicking At The Pump But It Is Not Full Yet
I found the one way valve at the filler neck that seems to be installed backwards and turn it around, now fuel flows much faster and no clicking mid fueling.
WP_20140921_005 by mpe-9, on Flickr
It was pointing in the opposite direction as it is now.
Santa FE SM (2001-06) :: AC Is Not Cooling / Loud Clicking When Turn Up The Speed Of Fan
Drove my son's '01 Santa Fe and the AC is not cooling. The compressor seems to be working but there is a clicking sound coming from under the dash on the passengers side. The clicking is louder when you turn up the speed of the fan. The coolant does not need to be charged.
View 2 RepliesSanta FE SM (2001-06) :: Cabin Fan Stops Then Starts With Audible Clicking
My 3003 Santa Fe AWD has an issue with the blower fan. It stops, then starts working and clicking can be heard behind the dash when this happens. The clicking seems to increase when the climatization switch (the one that switches the air to the front vents, foot wells, windshield, etc) is turned off. When it clicks while the switch is on the off position, the blower blows for a split second every time the click is audible. It kind of turns itself on/off. Before I start replacing parts, I suspect the fan relay to be the culprit, but I'm not sure.
View 2 RepliesSanta FE SM (2001-06) :: Clicking Coming From The Middle Coil Pack
I have a 2004 Hyundai Santa Fe 3.5. I just changed the spark plugs and wires and now I hear a clicking coming from the middle coil pack. At first I could see it arcing on the bottom to the metal part that holds the plug wire. I removed it and added some dielectric grease and the arcing seemed to stop, but the clicking noise is still happening. Does this indicate a bad ignition coil or do I just need to add more dielectric grease? The idle is still a little rougher than I would like, but I don't want to just throw parts at it.
View 21 RepliesSanta FE SM (2001-06) :: 2004 - Clicking Noise From Blower Relay / Fan Turns Off Then Comes Back On
I replaced blower switch last year a couple of years ago. I recently starting to get clicking noise from blower relay, and fan turns off then comes back on.
Question:
1- Problem more likely to be from the relay or the fan switch? Should I just replace the relay?
2- I can see and touch the fan relay, but how do I get to it to replace it? What dis-assembly is required?
Santa FE SM (2001-06) :: 2002 - Clicking Noise From Passenger Side Rear Tire
I'm driving a 2002 Hyundai Santa Fe with 83,000 miles on it.
Had it in the shop (dealer) a couple of weeks back for some work on the transmission. While there, I had the dealer perform the work for Recall 090 (corrosion of rear trailing arm). Since that time, there has been a clicking noise coming from what I believe to be the right rear wheel (it is definitely coming from the right [passenger] side). The noise sounds like metal rubbing up against metal, for lack of a better description. The noise is directly correlated to wheel rotation... the faster I drive the vehicle, the more frequently it occurs; the slower I drive, the less frequently it occurs.
The noise is very noticeable, and I am certain that it did not exist prior to my latest visit to the dealer. I am considering taking the vehicle to an independent mechanic this time, as the dealer repeatedly tells me that they aren't to blame, or I end up leaving the dealership with more problems than I arrived with.
Santa Fe (CM - 2007-12) :: 2010 V6 Can't Start / Clicking Noise With Dimming Lights
Our 2010 Santa Fe SE V6 just developed a problem where when we turned the key, the car wouldn't start, and there was a loud clicking sound during start attempt. Battery tested 100% OK.
This often points to a starter problem, but a telling symptom was than the headlights would dim, almost going out, along with the dash lights and most any other lamp. If it was just the starter, unless dead short, this associated dimming would not happen. I also put a volt meter on the battery and watched battery voltage during cranking attempt, and the voltage showed minimal drop, so once again the battery was not the problem.
Traced the problem to the ground strap from the battery which terminates to the driver side front wheel well. Two bolts hold the strap to the wheel well, and they are oxide coated and the contact point on the wheel well is painted. This means all the current returning to the battery is essentially passing through the bolt threads and cap where the oxide has been scratched enough to be conductive.
I sanded underside of the bolt heads to remove oxide, sanded the ground strap itself which seemed to have some sort of clear coating, and sanded the paint away from the wheel well where the strap makes contact. I didn't have star washers, but if I did they would have been a good addition.
Car now starts with no problem.
I am concerned with the possibility of corrosion under the strap where I sanded away the paint, but will monitor this. I think the contact between the strap and fender wall is tight enough with the two screws to seal out moisture and oxygen.
I am also going to locate and check any other chassis to engine ground straps so I don't have any new problems in the future.
Passat (B5) :: Clicking Noise When Start 2001 Wagon GLS V6
2001 Passat Wagon GLS v6 - 83k
Just replaced the drivers-side taillight and hood strut. Been a week or so since the vehicle has last been started as it is sitting in the garage. When I start the vehicle, it will turn over a bit, cranking away, then start clicking (pretty quickly).
If I pay careful attention while it is turning over, I can hear the door locks making some noise, kinda like they are trying to decide whether to lock or not. I will also get dash light flickering on/off. turn-turn-turn / click-click-click
I know it is not the battery. All power works fine when the key is just in the on position, no dimming, etc. Though it seems to be something electrical with the weird noises I get while trying to start.
Sierra :: 2001 2WD - Only Hear Clicking Noise When Key Turned To Start
2001 sierra 2wd ext. cab. over 300 km. 5.3 motor auto .... Battery charged, everything is working when key is on, but nothing happens when key is turned to start. Clicking noise can be heard in 5 pin fuse relay located on left side dash fuse panel.. How do I check it? Could have something to do with anti theft system?
View 3 RepliesElantra XD (2001-06) :: Occasional Non Start Situation - No Clicking Or Crank
Dealing with mother in law's 01 Elantra GT. 175k miles, unknown history for the most part except for recent maintenance.
Having some issues now. The car will not start..the battery is fine and that is ruled out. The car will intermittently not crank...it could be days, but luckily I have the car today and the situation is currently happening. All my dash lights and electricals work fine.
It is an automatic car.
Brake lights work when pressing the pedal. I looked at the switch near the pedal and it appears to function properly but see below.
When I turn the key, I can hear noise from the cruise control module underneath the hood, but nothing else. No clicking, no crank. Dash lights don't change except the clock fades out, but turns back on when key is off the start position.
I thought maybe something with shifter. In the Run key position, I can sometimes shift it out of park and into another gear...but sometimes not. It seems that changing how I press the brake pedal affects whether I can get it out of park.
The car was perfectly fine earlier today and that is why this is so strange. Sometimes it would leave her stranded, sometimes it works fine.
When I do shift out of gear, the dashboard reflects the proper gear on the digital display.
Passat - Volkswagen :: 2001 - At Start Up Clicking / Clanking Noise?
So it only happens when I start the car, I'm thinking its the starting needing to be replace. The car starts everytime, Just when it cranks it makes a the noise, but fires up right away. The noise is gone once the car is started.
View 3 RepliesFord Excursion :: 2001 - Really Loud Clicking Noise And Won't Start
I have an 01 Excursion. I tried to start it this morning and the radio and lights came on, but all it would do is make a really loud clicking noise. If the battery was dead would the lights come on? My friend who picked me up to take me to work also told me my battery connections needed cleaned...
View 7 RepliesSanta FE SM (2001-06) :: Will Not Start After Pumping Gas
I have a 2004 Santa Fe and every time after I pump gas into it it will not start. I try to start it five to six times and it finally starts but chugs and stalls unless I pump the gas. This lasts until I've driven for a few minutes.
View 6 RepliesSanta FE SM (2001-06) :: 2.7 Won't Start After Fueling Up
My '05 Sante Fe 2.7 doesn't want to start after fueling up. I have to hold the accelerator pedal down, like we used to on the old rods when we flooded the engine, to get it to start. I replaced the gas cap thinking that was the issue, but didn't fix it. I get no check engine light and with 340k miles, it sent out several codes a while back at the dealer. Could it be the fuel filter or pump?
View 2 RepliesSanta FE SM (2001-06) :: Won't Go Into Park Or Start
I have been getting a 2006 Santa Fe GLS A/T back on the road for friend who let it sit for almost 2 years because the bumper had gotten knocked off. I charged the battery to get the car to start and it started up OK, but the front brakes were shot completely. I then proceeded to replace the front brake pads and rotors, and when I went to start the car again I noticed something peculiar.
The car wouldn't start, or even attempt to (didn't here it cranking at all). I know the battery is good, and all the other components in the car turn on when I turn the key to A/C setting. I have the shift lever in what would seem to be Park, but the light on the console shows it is Reverse. It shows the car is in reverse when I have it in Park or Reverse, and shows Neutral when I have it in Neutral.
Before I did the brakes (which I don't believe to be related) it was being a bit fussy about switching gears and going into park, but it was definitely working.
Santa FE SM (2001-06) :: Clunk On Take Off From A Start
I have a 2004 Santa fe with the 3.5 auto transmission. It has developed a clunk on take off from a start. It will usually clunk two or three times like it is shifting hard, but it is not. I have had a mechanic ride with me (he was not sure what the cause was), a check with a transmission shop said they had never heard of an issue like that with this model, and had it checked for diagnostic codes (there are none).
They are not sure whether it is in the transmission or the AWD, and want to send it to a transmission shop to check it out (feels like exploratory surgery to me).
Hyundai TSBs indicate numerous Power Train issues, including TSB 195729 reprogramming shifting. The clunk will happen two or three times on take off and sometimes when accelerating from about 30 mph. The transmission does not seem to slip. Power is good. Acceleration is good. Shifting to selectronic works well.
Some forums have indicated similar sounds coming from the axels or bushings.
Santa FE SM (2001-06) :: V6 Won't Start After Filling Up With Gas
I drive a Sante fe 2002 V6 24V front wheel drive. The issue is that the car will not start after it gets filled up with gas unless I press and old the gas pedal, any other times the car starts with no issues. It was suggested that I change the gas cap which I did and no change, I tried living the cap loose but the the engine wouldn't shut off even with the keys out of the ignition and in my hand had to stall it in order for it to shut off. I purchased a ODB2 plugged it in and no codes appeared.
View 3 Replies