Santa FE SM (2001-06) :: 2002 - Hard To Start After Filling Up
Just bought a used but in pretty decent shape, 2002 Santa Fe, with 6 cylinder engine, 112K miles. I read the post about the vehicle that was hard to start after filling up - but this one is hard to start all the time - every time. Cranks fine, but once cranking, have to pump the gas pedal several times, and then it chugs just a second and then starts running. Slilght smell of gas if the hood is up, just after starting. Once running however, it runs perfectly on city and hwy. I have one mech that tells me "definitely the fuel pump" and another that tells me "definitely the purge valve" - this of course just from me describing the conditions, they have not actually seen it.
View 3 RepliesSanta FE SM (2001-06) :: Smell Of Raw Fuel When Filling Up
The last 2 times I have filled up at the pump and started driving from the station there is the strong smell of raw fuel in the cabin while driving and on the highway as well even with the windows down. It slowly dissipates after driving 5 miles or so and does not occur again until the next time I fill up. What it can be?
View 1 RepliesSanta FE SM (2001-06) :: 2005 - Gas Overflow While Filling
I recently purchased a 2005 SantaFe LX with a 3.5L engine (4x4). The gas tank had been replaced prior to me buying it. The problem I have is when I am filling the gas tank, the gas pump never shuts off until the gas overflows out of the top of the filler neck. If I stop with approximately a couple of gallons left to go and wait a couple of seconds and then finish filling, the gas pump will usually click off before the overflow happens. The filler neck and vent hose don't appear to be pinched. This happens at multiple gas stations and weather doesn't effect it happening. The only issues I could find on line was the stopping and starting when trying to fill up and mine doesn't do that at all, it will just go until overflows like I described.
View 5 RepliesSanta FE SM (2001-06) :: 2004 - Filling Up Gas Tank Makes Engine Die
I've got a 2004 Santa fe V6 2.7 with a strange problem (145k miles).
On Sunday I filled up the tank and the car would start but not stay running the engine would just peter out and die. Took me a few minutes and a little revving and feathering the gas to get it to where the engine would not die b/f I got it into gear. After driving a mile home I turned off the car and restarted it 3 times w/o incident.
There was a previous episode that was very similar a few months ago. However, this was an isolated incident. I did a little research on the fuel filter and discovered the necessity of pulling out the back seats and did not take any action beyond always buying good gas. I lied to myself that the first freeze and a very cold engine was somehow to blame.
Friday morning I left on a trip (w/o getting more gas) and in route I filled the tank twice and both times it did not want to start. The car stated like normal when I left for the return trip. I stopped for gas once on the way home with the intent of buying just enough gas to get home and leaving the engine running while I pumped. As soon as I removed the gas cap the engine died and was once again difficult to start (the engine seemingly becoming more stubborn with each incident).
Additionally the idle while in gear was not as smooth as it has been but not necessarily to the point where I would have noticed if I had not been watching closely. I spent about 10 minutes on idle and under 10 mph creeping through a construction zone and the rpm dropped sharply a few times. what this could be?
Volvo - Xc70 :: 2001 - Can't Start After Filling And Chugging During Cruise
I have a 2001 Volvo V70 XC which won't remain on after I fill it up, and while cruising (but not accelerating!) on the highway, it will chug-chug-chug and gives a very jerky ride (confirmed with cruise control). This happens during 60-80 km/hr, but less so at 100-120 km/hr. After I fill the tank I have to rev the engine to get it to 'catch' - if I don't the tach will drop to zero and the car will stall.
View 2 RepliesSanta Fe (CM - 2007-12) :: Stalls After Filling Up With Gas
Something I haven't seen yet. 2007 2.9l is hard to start and stalls after filling up with gas. After it runs a minute, no problems. Is it something with the gas cap maybe????? The catalytic converts have been changed, maybe something with the O2 sensors???
View 20 RepliesSanta Fe (DM - 2013+) :: Fuel Tank Not Filling All The Way
Well, just got back from my dealer - had them check into why after driving approximately 20 miles my fuel gauge registers 3/4 full. They said it has nothing to do with the cluster gauge everything checks out as accurate. My vehicle had the ECU 293 update applied at production. According to them is it because there is something preventing my fuel tank from filling all the way up. According to the service rep when the pump clicks off, my fill up is about 3-5 gallons short.
When I took delivery of the vehicle I noticed that the distance for the remaining (full) tank of gas read around 384. I've never seen that number again. Now when I do a fill up the best tops out at 310 or so. Where exactly did my 70+ additional miles until empty go?
They opened a case for my vehicle with Hyundai and said that Hyundai is already aware of this problem and they are working on a repair.
Santa Fe (CM - 2007-12) :: Car Stalling After Filling Up Gas Tank?
2007 Hyundai Santa Fe is currently stranded 4 hours away from home. The gas tank was 1/4 full and they filled up the gas tank and drove 4 miles down the thruway and then the car starting acting funny and stalled. Now when they try to start the car the car it dies after a few seconds. Of course it's Memorial Day weekend too.
View 9 RepliesSanta Fe (DM - 2013+) :: Pump Runs For 15 - 20 Liters And Then Shuts Off While Filling Up
The last 3 times I have tried to fill up, I have had about 1/3 of a tank. Tthe pump runs for ~15 -20 litres and then shuts off. I cannot fill any further. I have 9/16ths in the tank now, 360km to empty. I will phone the dealer tomorrow. 42000km now.
View 29 RepliesSanta Fe (DM - 2013+) :: When Filling The Gas Tank And Press The Nozzle Fully It Keeps Clicking Off
Have issues filling the santa fe? when I start filling, if i press the nozzle fully, it keeps clicking off on me. Even if I try to half press it, it still clicks off periodically. It's a real PITA, especially in the winter. 2013 Sport.
View 12 RepliesElantra XD (2001-06) :: Stalling After Filling Up With Gas
Hyundai Elantra 2003 ( 140000 KMs) Okay has happened the last 2 times, after putting gas in car. When I turn the key, engine revs up pretty high, about 3000 rpm and then car stalls. Will happen 2 or three times but does start if I give it some gas...
View 2 RepliesSanta FE SM (2001-06) :: Will Not Start After Pumping Gas
I have a 2004 Santa Fe and every time after I pump gas into it it will not start. I try to start it five to six times and it finally starts but chugs and stalls unless I pump the gas. This lasts until I've driven for a few minutes.
View 6 RepliesSanta FE SM (2001-06) :: 2.7 Won't Start After Fueling Up
My '05 Sante Fe 2.7 doesn't want to start after fueling up. I have to hold the accelerator pedal down, like we used to on the old rods when we flooded the engine, to get it to start. I replaced the gas cap thinking that was the issue, but didn't fix it. I get no check engine light and with 340k miles, it sent out several codes a while back at the dealer. Could it be the fuel filter or pump?
View 2 RepliesSanta FE SM (2001-06) :: Won't Go Into Park Or Start
I have been getting a 2006 Santa Fe GLS A/T back on the road for friend who let it sit for almost 2 years because the bumper had gotten knocked off. I charged the battery to get the car to start and it started up OK, but the front brakes were shot completely. I then proceeded to replace the front brake pads and rotors, and when I went to start the car again I noticed something peculiar.
The car wouldn't start, or even attempt to (didn't here it cranking at all). I know the battery is good, and all the other components in the car turn on when I turn the key to A/C setting. I have the shift lever in what would seem to be Park, but the light on the console shows it is Reverse. It shows the car is in reverse when I have it in Park or Reverse, and shows Neutral when I have it in Neutral.
Before I did the brakes (which I don't believe to be related) it was being a bit fussy about switching gears and going into park, but it was definitely working.
Santa FE SM (2001-06) :: Car Would Not Start, Just Clicking
I have a 2004 Santa Fe with about 85,000 miles. I went to go to work today and it would not start. Just clicking. So I jumped it and it started right up. On My way to work I noticed all the lights were dim. I turned on the turn signal and all the gages went dead and the transmission started to shift rough. Than the radio started to cut in and out and than the gauges on the dash started to turn on and off. I just replaced the taillight, but drove it for a few days with no problems. Just thought I would mention that.
When I arrived at work, parked it and turned the car off, it won't start back up.
Santa FE SM (2001-06) :: Clunk On Take Off From A Start
I have a 2004 Santa fe with the 3.5 auto transmission. It has developed a clunk on take off from a start. It will usually clunk two or three times like it is shifting hard, but it is not. I have had a mechanic ride with me (he was not sure what the cause was), a check with a transmission shop said they had never heard of an issue like that with this model, and had it checked for diagnostic codes (there are none).
They are not sure whether it is in the transmission or the AWD, and want to send it to a transmission shop to check it out (feels like exploratory surgery to me).
Hyundai TSBs indicate numerous Power Train issues, including TSB 195729 reprogramming shifting. The clunk will happen two or three times on take off and sometimes when accelerating from about 30 mph. The transmission does not seem to slip. Power is good. Acceleration is good. Shifting to selectronic works well.
Some forums have indicated similar sounds coming from the axels or bushings.
Santa FE SM (2001-06) :: When Put In The Key All Lights Come On But Car Won't Start
When I put in the key all lights come on, when I turn to start I get one click then nothing. The lights do not dim or turn off at all.
View 2 RepliesSanta FE SM (2001-06) :: Car Won't Start / Radio Will Not Come On
It has a new battery, a new alternator, gas, oil changed. The lights inside come on, the radio will not come on, when you try and start it, it will not turn over, it acts as if its dead....A mechanic told me it might have an electrical issue a couple of months ago because I had gotten a new battery then, and it drove for 3 weeks and died... I don't know what could it be..
View 2 RepliesSanta FE SM (2001-06) :: 2003 V6 Sometimes Won't Start
We have a Hyundai Santa Fe 2003 2.7 V6 and sometimes it just won't start, the starter motor turns over fine and the battery is fully charged, and most other times it starts straight away. The engine purrs nicely when it's running.
I suspect it's an electrical fault, perhaps a faulty sensor? (Cam position sensor, crank position sensor, fuel position sensor?) What sensor would cause the car to start and run perfectly some times and not start at all other times?
Immobilser issue? Although I don't have a button on my key so maybe the car doesn't have one.