Prius (2004-09) :: False Positive P0A80 - Replace Hybrid Battery
Recently my 2nd gen Prius has been acting, strange. I hoping to get some insight to the best way to fix the problem, so I will include as much detail as I can.
Over the weekend I went to go run some errands and while I was leaving my neighborhood, my dash lit up like a Christmas tree, with the red triangle, CEL, low tire pressure, and the exclamation on the MFD. So I quickly turned around and parked it back in my garage.
A little later and after doing some research on the forum here, I began to troubleshoot, at which point the feeling of dread was at the pit of my stomach and decided to go to the local auto store and have the code read. It was of course the "P0A80 - Replace Hybrid Battery Pack" the exact message I didn't want it to be.
So I turned around and went back home, the entire time all the lights stayed on and monitored the SOC of the traction battery. It was charging, just increasing and decreasing quicker than usual.
Prius (2004-09) :: Replaced 2 Modules In Hybrid Battery - Code P0A80
I have 2005 Prius with 300k miles. I started throwing P0A80 code. I removed the battery and checked all the modules and found 2 of low voltage, ordered them from Ebay and replaced them. I placed the battery back in the car and started the car but got P0A80 code again. I purchased the grid charger from Hybrid Automotive and connected it according to their instructions for 24 hours. I drove a car but got the red triangle again and P0A80 code again. I removed the battery again and tested the voltage of all the modules and these are the readings:
View 4 RepliesPrius (2004-09) :: A/C Compressor Out And ABS Actuator Failing After Hybrid Battery Replacement
A few weeks ago, I received the triangle light in my 2007 Prius with 125k miles on it. When I took it to the dealer, they said that the hybrid battery needed to be replaced. A new battery was ordered & installed by the dealer, which took a couple weeks as the battery wasn't in stock. When I picked up the Prius this week, within driving it a couple miles, it was apparent the A/C wasn't working. I took it right back to the dealer who said they'd look into it. When the Service sales guy started it again, it made a very strange noise as well, which it never did before. The dealer has come back and said that not only has the A/C Compressor out but the ABS actuator is also failing. They are saying this has nothing to do with the battery replacement but both these items were working fine before having the battery replaced
View 1 RepliesPrius (2004-09) :: P0A80 Error Codes Appeared, Still Pending
I recently replaced my engine water pump at 164,000 miles on my 2007 Prius, the car sat for 3 weeks while waiting to gather needed parts, i.e., water pump, coolant and Airlift system for adding coolant fluid. After installing the new water pump the car ran rough for 5-10 minutes upon initial crank (parked for 3-weeks). I took a 20 minute test drive around the neighborhood that evening, outside temperature around 65 degrees F, and car ran fine. SOC looked ok, bars moving between Blue and Green, everything appeared normal.
The next morning, I backed out of my driveway and the Red Triangle of Death appeared on the dash so I parked the car.
That evening I hooked up OBDII ELM327 scanner using Engine Link and picked up 2 separate P0A80 error codes, 1 of them was pending. I disconnected the Aux battery for 3-5 mins to clear the error's, Red Triangle of Death was cleared, then drove the Prius for 20 minutes with no errors or alarms. SOC seemed to be normal. OBDII ELM327 scanner showed the HV batteries were charging at same level, 16.8V and Aux battery was registering at 14.0 Volts.
The next morning, after 20 minutes of driving the Red Triangle of Death appeared, and shortly after I experienced loss of power, with sporadic engine idle and interior traction battery fan was on. Luckily I had made it to work and was able to pull into a vacant parking lot.
I did notice that around the time the Red Triangle of death came on this morning the SOC dropped quickly to 1 Purple bar and was slow to charge then shortly after came the loss of power and sporadic engine idle followed by interior battery fan.
Prius (2004-09) :: P0A80 / C1310 / C1259 And P3015 Codes On Scanner
The Prius has 115ooo miles. It is a 2005. Just recently it started showing the red triangle of death, check engine light, and the brake light. When I check for codes using a scanner it comes with the following:
P0A80
C1310
C1259
P3015
Prius (2004-09) :: 2006 - Got Error Codes P0A80 / P3019 / P3000?
Yesterday I got the "red triangle" and check engine light along with these 3 codes:
P0A80 - replace hybrid battery pack
P3019 - battery block 9 becomes weak
P3000 - battery control system
In April of this year I have the entire battery replaced, in September I got the triangle again and one cell was replaced under warranty. My warranty is good through April 2016, however I'm afraid that this new code P3000 is going to be something not included in my warranty.
What could potentially be wrong? This is a 2006 Prius with approximately 208,000 miles. I'm not sure this is worth it anymore especially if I have to keep putting in more money.
Prius (2004-09) :: 2005 - Codes C1241 And C1300 Generated After Battery Replacement
So my check engine light had been on intermittently for the past few weeks. I thought it was for the oil change as it was about that time and ignored it.
View 5 RepliesPrius (2004-09) :: Red Triangle Of Death (P0A80) - HV Battery ECU?
I've pulled the HV battery from my 2007 Prius with 144, 000 miles given recent Red Triangle of Death (P0A80) and looking to replace battery pack but want to rule out the ECU. I've searched the threads and found mention of testing the ECU but wasn't clear.
How to test the HV Battery ECU in or out of the car? Using a volt meter and light bulb, etc......I would really like to rule out the ECU before putting dollars in a rebuilt battery pack.
Prius (2004-09) :: 12V Battery Does Not Crank Car - Code P0A80 And P3021
I had a 12v battery issue that I see common. 12V battery does not crank car. Jump car and works fine for a few days. I had this issue and it went away. Dealer said replace 12v battery, or just carry my charger pack with and use that unless it gets worse.
Jump ahead 2 months. I drive 50 miles each way to work 5 days a week. No issues. Yesterday, after my car sitting all day, I am backing out of driveway and get the red triangle. Code was P0A80. I looked it up. I cleared the code and was going to dealer if it came back. Today, after driving 50 miles into work, no issues, I get the red triangle. Code P3021. Fan started running back there too
My question : Would replacing the 12v battery useful for this issue?
Prius (2004-09) :: Replaced Dead Cells On HV Battery - Code P0A80
Have replaced dead cells on wife's HV battery over a month ago. Threw this P0a80 code today and will barely move. She idles into dealership and they say it's the battery, really!
View 2 RepliesPrius (2001-03) :: Red Triangle After Hybrid Battery Replacement
well I saw one other thread on this topic but no resolution. I replaced the hybrid battery like the codes told me too on my 2003 prius and it now drives great but as soon as it start it shows a problem and the red triangle stays on. No check engine light, no codes, no driving issues just a red triangle. How to diagnose a red triangle when there are no codes.
View 16 RepliesPrius (Gen 2) :: Hybrid Battery Drained / List Of Codes Scanned
I'm hoping I can get some diagnostic insight into a problem I just started seeing on my 2007 Prius. I have had the Prius for a little over 4 years. Currently around 123K miles.
Starting two days ago I noticed when I started driving that the engine was constantly running and when pulling out from a stop sign just up the road from my house the acceleration was sluggish. I look at the MFD and see the hybrid battery is nearly drained. Unusual because it was blue or green when I parked the night before. Driving for a few minutes, the battery fills back up and driving is normal. The only warning light is for a tire pressure sensor which just started to come on that day. Over the last two days I get the same thing at start up. Hybrid battery is drained. Lights aren't left on over night. Tire sensor light is constantly on but I checked the tires and pressure is good all around. Nothing plugged in anywhere to drain battery. The 12V battery was replaced maybe a year or so ago with an Optima yellow top, so not likely the issue. I checked diagnostic codes in the MFD and came up with a lot of codes:
LAN Monitor EMV:
01-DB 190- 40- 5
01-DE 178- FA-1
01-DB1F1- E5- 4
01-DB 110- 8A- 7
01-DB 178- 46- 3
LAN Monitor NAVI:
01-E3 - 00- F
Prius (Gen 3) :: Check Hybrid System Message After Auxiliary Battery Replacement
Jumped into the Prius this morning to discover dash lights working, no radio etc so vehicle would not turn on. Replaced the auxiliary battery (about 5 years old.) Now all dash light, radio etc are looking great BUT:
- Enngine will not engage
- Message stating Check Hybrid System
- Various waning lights on dash (yellow waning triangle, swerve icon on left)(battery, brake, chech engine, steering wheel?) and abs!!!on the right)
Prius (2001-03) :: Hybrid Battery Replacement - Warning Triangle Shown
I replaced my hybrid battery of my NHW10 a year ago. now recently it shows the warning triangle. Once it went off after a long drive but now its permanent. is there a way to Diagnose what is the cause of this? If its a Hybrid battery issue, will it go off if i replace the bad cells?
View 3 RepliesPrius (2004-09) :: 2006 - Hybrid System Overheats With Codes P3190 And P3191
Something in my Gen II 2006 Prius is causing a type of overheating condition in the hybrid system. The fault/error codes coming up are P3190 and P3191. If I turn the car off for 30 minutes and restart it, it runs fine for a period of time (but usually not more than a week).
I first noticed the problem a couple of months ago during my 45 mile (mostly highway) commute. While driving on the highway, I noticed that the Prius wouldn't accelerate when I stepped on the gas pedal. A couple of minutes later, my dash warning lights come on and the car started slowing down (no response to the gas pedal at this point). For a minute or so, I was able to change gears (reverse or drive) and move a little in either direction but the transmission stops responding altogether very quickly.
Dash lights that light up
Hybrid system error symbol lit up and I noticed that the hybrid battery charge level was at one purple bar.
The first time it happened, I had my car towed to the nearest Toyota dealership. The flatbed tow truck driver (to my surprise) was able to start the Prius and back it into a spot at the dealership. Some of the dash lights were no longer lit.
The dealer couldn't find anything wrong with the car except for the fact that my water pump was leaking. They replaced the water pump, cleared the error codes and drove the car around for about 45 minutes but couldn't reproduce the problem. I drove my car home.
note: this dealership replaced my hybrid battery and 'computer' (I'm sure it has a specific part name - I don't have the info) right before my warranty ran out over a year ago. I didn't have any warning lights lit up on the dash at the time but I told the master mechanic working on my car that it didn't have much power going to the wheels when I put it in reverse (I couldn't back into my driveway). After the hybrid battery and computer were replaced, I had no issues with backing into my driveway.
The same issue happened a week later. I turned the car off for 20-30 minutes, started the car and noticed that the bulk of the dash warning lights turned off so I drove it home. I took it to my local mechanic the following day. He cleaned the intake manifold, changed the spark plugs, cleared the P3190 and P3191 codes indicating that they were generic codes indicating a misfire and said that it was now running fine.
A week later the same thing happened. I did some research and brought the car back to my local mechanic and asked him to change the transmission fluid & to use the Toyota ATF WS fluid. He changed the transmission fluid (and noted that it was dirty), cleared the codes and I brought the car home. I unfortunately didn't get a sample.
We had a power failure that night so I plugged my pond aerator into the cigarette lighter to keep my koi alive and less than 2 hours later I came out to find the pondmaster ap-20 (20 watt) air pump (blows bubbles through 1/2" tubing) wasn't running and my car had shut off with the dash warning lights illuminated. I have run this little aerator for 4 days on a single tank of gas without issues in the past.
Prius (2004-09) :: 2007 - Hybrid Battery Always At One Bar Down?
My concern: The hybrid battery, or the monitor really, has never, ever, not once, shown an all-bars charge. It is almost always at one bar down, and will drop below that but never goes above. My brother has a Gen I and his battery shows all bars from time to time. Not mine.
View 6 RepliesPrius (2004-09) :: Hybrid Battery Is Low Overnight
My hybrid battery has been running low the past few days. This has never happened before, but it has been around 90 degrees out during the same few days. I noticed it this morning as I left for work. It was down to two bars when pulling out of the garage. I was getting pretty nervous, but at least the ICE was charging it. Although, it never fully charged the system, as I live pretty close to work. On the way home, I tried to drive around for a mile or so to see if I could get the battery fully charged.. The best I could do was four bars. Is this typical of the hybrid system in warm weather? Should I be worried about it? Also, the system has a fan, why doesn't it come on if the hybrid battery is so temp sensitive?
View 18 RepliesPrius (2004-09) :: Possible To Charge Hybrid Battery When Car Is Idling
I recently purchased a used 2007 prius. The car has not been driven for some time. I won it in an auction from a used/wreaked car lot and am in the process of fixing it up. I need to know if it is possible to charge the hybrid battery when the car is idling or will this only discharge the hybrid battery and if so, is there any way to charge the hybrid battery other than driving the car?
View 6 RepliesPrius (2004-09) :: Red Triangle / CEL And Red Car At The Top Of MFD - Hybrid Battery Failing
i have a 2006 with almost 200k miles. Got the red triangle, check engine light, and the red car at the top of the MFD. I ran the codes and got P3000. Does this sound like traction battery failure? The car still turns on and ICE still cycles off and on.
View 19 Replies