Passat (B5) :: 1997 VR6 Started Overheating - Fans Just Quit Running
My car just started over heating and I checked the fans and they are not running. I'm new to the VW family and although I love the way this car drives I've been baptized with quite a few problems.
View 2 RepliesGolf IV / Jetta IV :: 1999 - Overheating / Fans Not Running
So my friend, ignoring my advice that this generation seems to be riddled with electrical problems, decided to purchase a seemingly nice 99 Jetta, with a junkyard AEG swapped in(AEG is written on the intake and block like a JY would do). Sun roof doesn't slide back, gets jammed, evidence shows water has built up previously and run down the A-Pillar to the fuse box.
I just got the fans unplugged and verified that the fans with power applied, both have their low/high speeds. The fuses on top of the battery are in-tact, no visible melting, looks like the thing is in ok shape(haven't taken them off to inspect the contacts yet).
Passat (B6) :: 2007 - Fans Not Running / Engine Heating Up?
Finding the electrical controls( fuses, relay, control unit) of the fans ( both are not working) ... Passat station wagon 2.0T (FSI) 2007 .....
View 4 RepliesGolf IV / Jetta IV :: Overheating - Fans Not Coming On
As the title says, car is overheating. Car gets to 190F within a couple miles drive. Temperature fluctuates between 190F and 225F.
Water pump was replaced ~2 months ago. Was not overheating prior. Temp reached 190F and stayed. Currently has the "black top" coolant temp sensor.
I noticed the coolant fans are not running after I turn the ignition off. This time of year they would usually be running after turning the engine off. If car is overheated and with AC off the fans do not run while engine is running.
I used the guide below to try diagnosing the cause: [URL] ....
Remember both fans should come on in slow speed any time the key is on and the AC is on - if the temperature is above about 32 F (0 C). Both fans run with key on and AC on
S180 (fuse 8, 30 amps, green plastic, above battery) must be good for slow speed operation.
Fuse and holder look good: no melting, no discoloration.
S164 (fuse 3, 40 amps, metal strip, above battery) must be good for fast speed operation.
fuse looks good: unbroken.
To ensure the AC circuits and the Fan Control Module has power check:
Fuse 5 on the cabin fuse panel.
Fuse 16 on the cabin fuse panel. When this fuse is blown the radiator fans will often run unexpectedly.
Fuse 25 on the cabin fuse panel.
All three fuses look good: unbroken
For the first test of the slow speed fans from the radiator thermoswitch have the key off.....Both fans should run in slow speed.
Passed test: both fans run slow
The second test is for the fast speed fans, key on, AC off.... Both fans should run in fast speed.
Passed test: both fans run fast
If the fans run in the tests above, then you should be good to go. No further tests are needed.
If you have been seeing high coolant temperatures and the fans have not been running, then you may need a new thermoswitch.
Honda - Accord :: 1999 V6 Overheating - Fans Will Not Run Unless AC Is On
My 1999 Accord V6 with 180k miles has started overheating. The fans will not run unless the A/C is on. I replaced the coolant temp switch A, because the fan came on when I jumpered the pins of the fan connector. The fan will not come on, even when the temp gauge goes all the way to the top. Jumper the pins or turn on the climate control, the fans kick on, and the temp drops. Tested the old temp switch in boiling water and it tested fine. Tried spreading the pins on the temp sensor in case the connection was just bad and that did nothing.
Otherwise, the system seems to work fine. Top coolant hose gets hot first, then bottom gets hot after 10 minutes. The heat works, and I didn't see any signs of exterior leaks. What else might keep the cooling fans from coming on?
Toyota - Camry :: 2001 - Overheating / Fans Seem To Come On Only If Turn On AC
I have a 2001 toyota camry ce in Miami, fl which is overheating. the fans seem to come on only if i turn on the a/c. however the temperature still rises and gauge needle hits red. if on idle the fans never come on. observed fluid inside radiator with cap off and it does not run through while on idle with a/c off, it just gets hot. changed thermostat and added new 50-50 antifreeze, still same. I'm suspecting a switch but why is fluid never running even when hot? I even drive it with hood open (unlatched) to let a bit more air in and still overheats, even with a/c on and fans running (again, they only turn on with a/c on), it overheats.
View 3 RepliesGolf IV / Jetta IV :: 2002 - Overheating In Traffic - Fans?
So i have a 2002 1.8t that i got in december. Everything has been great so far untill the other day the car overheated on me in traffic. It was a bit warm out maybe 75-80 degrees. I saw the needle start to climb and then the light went on so i through the heat on full blast and it dropped the needle a bit and turned the light off long enough to pull off the highway. I let it cool down and checked things out. I am not low on fluid, an the fluid was changed within the last year with the vw recommended stuff. The radiator hoses are pressurized so i believe that the pump and thermostat are working. I am thinking it could have something to do with my fans. I tested them in my driveway by supplying them with 12v and the spun perfectly. It only happens when the car is standing still for a period of time. Driving at any speed is fine. Is there some sort of switch that tells the fans to turn on?
View 2 RepliesPhaeton :: Coolant Overheating Warning Coming On - Fans Going Crazy
I have a V8 engine, and I have been getting the coolant overheating warning come on once in a while.
The engine fans go crazy, and the temperature needle on the small round gauge climbs all the way to red then the coolant overheating warning comes on in dash screen.
This can happen right after I turn the car on, or on occasion, it can happen as I am driving around the city.
I stop, switch the car off, and I turn it back on after a minute, and the car is just fine. So, basically, it doesn't seem like the engine coolant is actually overheating, but the fans and warning systems seem to think that they are. The fans are pretty loud, and its noticeable when they go on, and when this happens, I know that the needle will go all the way up and the warning will go off. I also know that if I turn the car off for a minute, and it will be just fine.
The conditions are random for when this happens. So its not when its particularly hot or cold or anything predictable. Could this just be a sticky thermostat? Is it a bad water pump? Bad battery?
The trouble is that now I am afraid I cant take a real drive. Around the city I can just pull over, but I am afraid to take the car two hours out or something.
Subaru - Outback :: 2007 - Overheating / Fans Are Working When Not Driving
My Subaru just had the thermostat replaced, and it seemed to work until the wife took it she said it over heats when not driving the fans are working, it's over flowing out the reserve tank the fluid looked good when changed the thermostat so I don't think it's the head gasket my next guess would be either the water pump... After I last changed the thermostat and test drove it I felt the upper radiator hose it was hot but the bottom one was cool/warm.
View 8 RepliesDodge - Neon :: 2005 - Overheating / Cooling Fans Are Not Coming On
2005 Dodge Neon SXT 206XXX
Long story short on a trip (about a 1 hr. drive) got about a block away from destination and gauge showed it was over heating. Stopped the car started up after five min. just fine. Got home replaced the thermostat and cap (old cap was junk). New cap was junk aftermarket so yesterday I took the same car on a half hour drive to get a Mopar cap ran just fine up again until a block away, pulled off the road turned it off let it set a few min. then didn't even show it was over heating. Let the pressure off and replaced the cap and added in a bit more coolant ran fine all the way back (even pushed speed in a few spots).
The above is just what seems to be the mechanical side of the issue. After noticing the gauge was going a bit above the normal spot I noticed my cooling fans are not coming on. Checked fuse and tested relays out to be fine. First thought is to check voltage to the fans but also tempted to check coolant temp sensor with bench test. Will be going over to my dads to do voltage testing later today.
Camry :: 2000 Vehicle Overheating - Radiator Fans Kick In And Then Temperature Goes Down
My Camry seems to be overheating. When I'm driving the gauge maintains and reads 6/10, when the engine is idling, it goes upto 8/10, radiator fans kick in and then temperature goes down to 6/10 and keeps cycling over a period of 5 mins.
It's got 100K miles, water pump has not been replaced yet.
I checked the hose temperature; top hose 210 F, bottom hose 192, fans kick in when top hose is around 215 F.
I checked the engine temperature where the sender is installed and it was reading 205 F. Coolant level is OK. I burped the system. Previous owner told me, he had thermostat replaced by dealer.
Toyota - Camry :: 1995 - Overheating / Fans Only Work When Put Relays In Halfway?
I know the alternator needs replacing but why are the fan relays not working correctly. Also, the top radiator hose is really hot? I replaced the thermostat as well as the coolant reservoir? I also replaced a couple of the fan relays from my older wrecked Camry. Would the noisy alt that is going out have something to do w/the fans and fan relays not working properly?
View 6 RepliesGolf IV R32 :: Overheating - Radiator Fans On - Cruise Control Stopped Working?
So I noticed my temp gauge was starting to rise when I was on the freeway. I figured my fans were out but I just opened my hood and both fans were spinning. When I turned the car off both fans turned off but the temp gauge was almost into the red.
In the morning I turned on my AC and only the passenger side fan was working.
So I am not really sure what my next diagnostic step should be. The engine was not radiating any heat so I am not sure that it is even actually running that hot. Could it possibly be the temperature gauge? If I got a vagcom would I be able to check the actual temperature from there?
I am also concerned on how to find out if the fans are running at both speeds at the appropriate times.
Not sure if this is related but my cruise control stopped working a few weeks ago also.
Golf IV / Jetta IV :: 2004 - Overheating / Fans Stopped Working Correctly And Fuses Kept Blowing
I have a 2004 volkswagen jetta, and it has started overheating. At first my problem was the thermostat. After that was changed out the fans stopped working correctly. It kept blowing fuses in s180 slot.
I read somewhere in another post that this is due to the fact the resistor in the low speed fan go bad, and for your car's radiator fan to go from zero to high speed, causes the fuse to blow. Also I read that when the fans start up it draws the most current, and then after it's running the current is considerably less.
This is my solution, I went to napa, and got a circuit breaker for a car, and Yes, to my surprise they make them. I picked up several a 10amp, 15 amp, 20 amp, and a 30 amp. First, I tried the 30 amp circuit breaker and it didn't trip the circuit, but when I put a regular fuse in the slot, it did trip the circuit, when I did the fan test at the thermostat switch. Next, I put the 25 amp in there and neither did it trip the circuit. When I put the 10 amp in the s180 slot, it tripped the circuit, just as the regular 30 amp fuses do. So that confirmed that the amps that were being drawn from the fans were not enough to trip a 30 amp circuit breaker.
What I did next, is I took a 20 amp circuit breaker and put that in the s180 slot. Then I hooked up vag com on my laptop to check and see how it performed with the 20 amp circuit, and these are the results.
Car Temperature in celsius
at 111 degrees the gauge was moving past the halfway point
at 115 degrees the gauge was one notch past halfway going towards the red zone
at 120 degrees the gauge was two notches past halfway going towards the red zone
at 122 degrees the fans kicked on high speed for about 30 seconds, and knocked the
temperature down to 105 degrees.
In conclusion, if the high speed on the fans work, you don't have to take those out and go and buy an expensive new fan set. Just stick a 20 amp circuit breaker in the slot, and keep using the fans that you have.
Part no: 782-3154................ Name: Circuit Breaker, 20 Amp; Blade
Note: I take NO responsibility for any damage you do to your vehicle from any information you obtained from this post. Do this at your own risk! I am not a mechanical expert but this is my solution to the overheating problems.
Hyundai - Accent :: 2004 - Overheating / Temperature Gauge Starts Moving Up As Radiator Fans Kick On
I have a 2004 Hyundai Accent. The temperature gauge in the car moves toward the "danger zone" only under both the following conditions:
1) Car is at IDLE after being driven for a while (15-20 minutes). 2) Headlights are ON (I've sat in the car and watched the temperature gauge move up and then back down as I turn on and thrn turn off the headlights).
*What I've also noticed is that the temperature gauge starts moving up as the radiator fans kick ON.
Golf IV R32 :: Fans Don't Come On - Car Running Hot
My R now has 78k on the clock so I guess it's time for the obligatory issues with the radiator fans. My car started running hot from time to time, not constantly. Brief explanation of the issues and my "diagnosis" for each:
Without the A/C turned on the fans don't come on - when I turn the A/C the passenger side comes on all the time (faulty switch). Driver's side fan is intermittent - usually it turns on with the a/c but if it doesn't a tap on the center with the lug wrench gets it spinning (stuck brush).
The main thing I want to make sure is that it's not a thermostat issue as well (or instead of the switch). The heat works fine - I've been blasting it every time I hit traffic on my way home just to ensure that the car doesn't overheat. My assumption was that if the heat works then the thermostat is opening to allow the coolant into the heater core.
Lumina :: 2004 LS - Fans Not Running Continuously When AC Switched On
I recently bought Lumina 2004 LS. both radiator fan clicks when temperature is very high (about to reach red). Also I have noticed when the AC switched on fans are not running continuously, works for few seconds and went off.
I have already tried replacing the thermostat and two relays. What to check? Looking for wiring diagram for Radiator fans.
IS F (2008-2014) :: Climate Fans Running Even After Car Completely Off
I woke up to a dead battery this morning .. And the other day I realized that my climate fans were still running even after the car was completely off.. It's really strange I'm not sure what the issue could be, but not only that! I can adjust to any temp, throw on the a/c and no matter what it's blowing out hot hot hot...
View 4 RepliesPrius (Gen 2) :: Radiator Cooling Fans Running Constantly?
I can usually find what Im looking for with a quick search but I have had no luck with this issue.
View 19 Replies