Golf IV R32 :: Overheating - Radiator Fans On - Cruise Control Stopped Working?
So I noticed my temp gauge was starting to rise when I was on the freeway. I figured my fans were out but I just opened my hood and both fans were spinning. When I turned the car off both fans turned off but the temp gauge was almost into the red.
In the morning I turned on my AC and only the passenger side fan was working.
So I am not really sure what my next diagnostic step should be. The engine was not radiating any heat so I am not sure that it is even actually running that hot. Could it possibly be the temperature gauge? If I got a vagcom would I be able to check the actual temperature from there?
I am also concerned on how to find out if the fans are running at both speeds at the appropriate times.
Not sure if this is related but my cruise control stopped working a few weeks ago also.
Golf IV / Jetta IV :: 2002 - A/C And Both Fans Stopped Working?
So I just got a 2002 1.8t, everything was fine until the fans and ac stopped working. After poking around the forums a bit I changed the following:
1. Fan Control Module. Result: nothing
2. Radiator Cooling Fan Switch Temperature Sensor. Result: nothing.
all fan components have the correct voltage going to them. Fuse 16 for the AC clutch is not blown and has power going to it. The AC compressor has power going to it. The fuses on the battery box have power going to them specifically S180.
My question is what am I missing? is it possible that the fans themselves could be bad? car is not overheating, the after run coolant pump kicks on. But the AC clutch is not spinning nor are the fans. btw AC clutch is not seized up.
Golf IV / Jetta IV :: Radiator Fans And AC Stopped Working At The Same Time
A few days ago I was driving around. I get back in my car and when i turn it on no air blows and the radiator fans aren't working at all. My car hasn't overheated but have stopped driving until I can figure the issue out. I have since replaced the fuse box on top of the battery to no avail. I was thinking that it could possibly be the fan control module but in all the posts I am reading not one says that theirs don't work, they just keep running. So is there something else i should be looking at?
View 1 RepliesGolf IV / Jetta IV :: Overheating - Fans Not Coming On
As the title says, car is overheating. Car gets to 190F within a couple miles drive. Temperature fluctuates between 190F and 225F.
Water pump was replaced ~2 months ago. Was not overheating prior. Temp reached 190F and stayed. Currently has the "black top" coolant temp sensor.
I noticed the coolant fans are not running after I turn the ignition off. This time of year they would usually be running after turning the engine off. If car is overheated and with AC off the fans do not run while engine is running.
I used the guide below to try diagnosing the cause: [URL] ....
Remember both fans should come on in slow speed any time the key is on and the AC is on - if the temperature is above about 32 F (0 C). Both fans run with key on and AC on
S180 (fuse 8, 30 amps, green plastic, above battery) must be good for slow speed operation.
Fuse and holder look good: no melting, no discoloration.
S164 (fuse 3, 40 amps, metal strip, above battery) must be good for fast speed operation.
fuse looks good: unbroken.
To ensure the AC circuits and the Fan Control Module has power check:
Fuse 5 on the cabin fuse panel.
Fuse 16 on the cabin fuse panel. When this fuse is blown the radiator fans will often run unexpectedly.
Fuse 25 on the cabin fuse panel.
All three fuses look good: unbroken
For the first test of the slow speed fans from the radiator thermoswitch have the key off.....Both fans should run in slow speed.
Passed test: both fans run slow
The second test is for the fast speed fans, key on, AC off.... Both fans should run in fast speed.
Passed test: both fans run fast
If the fans run in the tests above, then you should be good to go. No further tests are needed.
If you have been seeing high coolant temperatures and the fans have not been running, then you may need a new thermoswitch.
Golf IV / Jetta IV :: 1999 - Overheating / Fans Not Running
So my friend, ignoring my advice that this generation seems to be riddled with electrical problems, decided to purchase a seemingly nice 99 Jetta, with a junkyard AEG swapped in(AEG is written on the intake and block like a JY would do). Sun roof doesn't slide back, gets jammed, evidence shows water has built up previously and run down the A-Pillar to the fuse box.
I just got the fans unplugged and verified that the fans with power applied, both have their low/high speeds. The fuses on top of the battery are in-tact, no visible melting, looks like the thing is in ok shape(haven't taken them off to inspect the contacts yet).
Golf IV / Jetta IV :: 2002 - Overheating In Traffic - Fans?
So i have a 2002 1.8t that i got in december. Everything has been great so far untill the other day the car overheated on me in traffic. It was a bit warm out maybe 75-80 degrees. I saw the needle start to climb and then the light went on so i through the heat on full blast and it dropped the needle a bit and turned the light off long enough to pull off the highway. I let it cool down and checked things out. I am not low on fluid, an the fluid was changed within the last year with the vw recommended stuff. The radiator hoses are pressurized so i believe that the pump and thermostat are working. I am thinking it could have something to do with my fans. I tested them in my driveway by supplying them with 12v and the spun perfectly. It only happens when the car is standing still for a period of time. Driving at any speed is fine. Is there some sort of switch that tells the fans to turn on?
View 2 RepliesGolf IV / Jetta IV :: 2002 - Turbo Fans Keep Blowing Out?
I bought a 2002 gti mk4 with about 127000 miles on it .I did not know the turbo fans were blown out , they were sitting in my down pipe next to my catalytic converter . So I replaced the turbo myself , and 2 hours later the fans fell out of the new turbo , what might be the problem ? why it keeps blowing.
View 7 RepliesGolf IV / Jetta IV :: Only One Of Radiator Cooling Fans Working
I have a quick question, I got a 2005 mk4 gli, and when the cooling fans go on, only one works, the other one does not, I checked the fuse and its fine.
View 13 RepliesSubaru - Outback :: 2007 - Overheating / Fans Are Working When Not Driving
My Subaru just had the thermostat replaced, and it seemed to work until the wife took it she said it over heats when not driving the fans are working, it's over flowing out the reserve tank the fluid looked good when changed the thermostat so I don't think it's the head gasket my next guess would be either the water pump... After I last changed the thermostat and test drove it I felt the upper radiator hose it was hot but the bottom one was cool/warm.
View 8 RepliesGolf IV / Jetta IV :: A/C Malfunction - Air Stopped Blowing Out Of Vents
This morning my AC was working just fine, air blew cold and nothing seemed wrong. But then tonight when I went out it was cold outside so I decided to turn the heat on.. That's when a problem happened. Tried turning the AC on but no air came out the vents at all. Tried all the air settings, nothing at all, even when it's on "4". The only thing that seems to work is the re-cycilation button, it lights up and I can hear it working. So to sum it up, no air coming out the vents and the AC light won't turn on when I push it in.
View 3 RepliesGolf IV / Jetta IV :: AC Randomly Stopped Blowing Cold Air
No AC... Its not the fuse box on top of the battery, I recently already changed that. The air coming out is not cold at all, so I checked the pressure, and it was even higher then it was supposed to. After letting some pressure out, still no cold air. What could the issue be? Should I maybe bleed the system?
Also, its a 2001 GLX so I have climatronic....
Ford A/C :: 2002 F150 - Climate Control - System Stopped Blowing Air - Sputtering Noise From Fans
Have a 2002 SC lariat with climate control. A few weeks ago, the system stopped blowing air. It seems the brains still work for temp control as I can adjust the temp and the natural flow air through the system will change temp.
I heard a sputtering noise from the fans a few weeks ago at about the time it quit. Is this because the servo motors for the fans quit or if it would be something from the controls?
Golf IV / Jetta IV :: ESP Light On After Driving 10 Miles - AC Stopped Blowing Cold Air
So my alternator went bad last week so I replaced it. Tested it yesterday and it was charging fine and drove it to work. I got the esp light on after driving 10 miles everytime I start it. So I go start it and it turns over slow but starts. Before I got to a friends house I was getting on it from a stop pretty hard and noticed the ac stopped blowing cold air. I go to leave a few hours later and it barely turns over and died shortly after moving. Took a while to jump it and the battery light blinked the whole way home. THEN, I go inside and hear something about 5 minutes later and my stereo is on! Also ABS light is on. Could a dead battery do all this?
View 1 RepliesPontiac - Grandam :: 2004 - Compressor Is Working But AC Stopped Blowing Air
Bought an 04' Pontiac Grand. AC worked fine on the test drive then after a few weeks the AC stopped blowing air. I can feel the compressor is working and the air is being conditioned but the blower motor does not turn on. I've tried using all the speeds and none of them work. I do not believe the controls are to blame but rather either
A.) resister or
B.) connector(s) or
C.) blown blower motor.
Camry :: 2010 Toyota Blower Motor Stopped Working - Fuses Blown
I have a 2010 Toyota Camry 2.5L. Suddenly the blower-motor stopped working. I looked at the under-hood fuse panel and noticed a few of the fuses in the fuse bus-bar were blown, however I'm not sure how the bus-bar is removed. Is this most likely my blower-motor problem? If so, how do I replace those fuses?
View 6 RepliesGolf IV R32 :: Cigarette Lighter Keeps Blowing Fuses
So I just got a new Passport Radar for the car and noticed that im getting no power...Checked the fuse box and and fuse was blown...replace it and the fuse blows automatically.
View 6 RepliesPrius (Gen 2) :: 2006 - Radiator Cooling Fans Stopped Working
I own a 2006 Prius with 52k miles on it. Great car BTW. The problem is simple, the radiator cooling fans stopped working on high mode; they run around 25% only even, not removing the heat from the a/c evaporator and the radiator coolant. I checked fuses: OK, checked relays: OK. They spin freely and nothing is blocking the front face of the evaporator. Funny I noticed it when I started hearing the a/c compressor buzzing noise and then I realized the fan noise wasn't there!
View 7 RepliesFord - Explorer :: 2004 - A/C Blower Keeps Blowing Fuses
Why the rear Auxiliary A/C blower on a 2004 Sport Trac keeps blowing fuses and how to fix it?
View 12 RepliesFord A/C :: 1999 Expedition - Overheating / Air Stopped Blowing Cold
Last week my 99 Expedition w/ 130,000 miles overheated. Air stopped blowing cold, then blew REALLY cold momentarily, Temp. went to high, check engine light on, car wouldn't accelerate. Was a block from home - put it in neutral and got home. Let it cool down. Checked all fluids, etc. Took it to our family mechanic - been our mechanic for 5 years - could find nothing obviously wrong so he cleared the code. Car ran fine for a week then temp started to rise again yesterday. Only common thread...the rear air was on both times. Once we were highway driving, other time in stop/go traffic. Replaced the thermostat last year.
View 2 Replies