Golf IV / Jetta IV :: Radiator Fans And AC Stopped Working At The Same Time
A few days ago I was driving around. I get back in my car and when i turn it on no air blows and the radiator fans aren't working at all. My car hasn't overheated but have stopped driving until I can figure the issue out. I have since replaced the fuse box on top of the battery to no avail. I was thinking that it could possibly be the fan control module but in all the posts I am reading not one says that theirs don't work, they just keep running. So is there something else i should be looking at?
View 1 RepliesGolf IV / Jetta IV :: 2004 - Overheating / Fans Stopped Working Correctly And Fuses Kept Blowing
I have a 2004 volkswagen jetta, and it has started overheating. At first my problem was the thermostat. After that was changed out the fans stopped working correctly. It kept blowing fuses in s180 slot.
I read somewhere in another post that this is due to the fact the resistor in the low speed fan go bad, and for your car's radiator fan to go from zero to high speed, causes the fuse to blow. Also I read that when the fans start up it draws the most current, and then after it's running the current is considerably less.
This is my solution, I went to napa, and got a circuit breaker for a car, and Yes, to my surprise they make them. I picked up several a 10amp, 15 amp, 20 amp, and a 30 amp. First, I tried the 30 amp circuit breaker and it didn't trip the circuit, but when I put a regular fuse in the slot, it did trip the circuit, when I did the fan test at the thermostat switch. Next, I put the 25 amp in there and neither did it trip the circuit. When I put the 10 amp in the s180 slot, it tripped the circuit, just as the regular 30 amp fuses do. So that confirmed that the amps that were being drawn from the fans were not enough to trip a 30 amp circuit breaker.
What I did next, is I took a 20 amp circuit breaker and put that in the s180 slot. Then I hooked up vag com on my laptop to check and see how it performed with the 20 amp circuit, and these are the results.
Car Temperature in celsius
at 111 degrees the gauge was moving past the halfway point
at 115 degrees the gauge was one notch past halfway going towards the red zone
at 120 degrees the gauge was two notches past halfway going towards the red zone
at 122 degrees the fans kicked on high speed for about 30 seconds, and knocked the
temperature down to 105 degrees.
In conclusion, if the high speed on the fans work, you don't have to take those out and go and buy an expensive new fan set. Just stick a 20 amp circuit breaker in the slot, and keep using the fans that you have.
Part no: 782-3154................ Name: Circuit Breaker, 20 Amp; Blade
Note: I take NO responsibility for any damage you do to your vehicle from any information you obtained from this post. Do this at your own risk! I am not a mechanical expert but this is my solution to the overheating problems.
Prius (Gen 2) :: 2006 - Radiator Cooling Fans Stopped Working
I own a 2006 Prius with 52k miles on it. Great car BTW. The problem is simple, the radiator cooling fans stopped working on high mode; they run around 25% only even, not removing the heat from the a/c evaporator and the radiator coolant. I checked fuses: OK, checked relays: OK. They spin freely and nothing is blocking the front face of the evaporator. Funny I noticed it when I started hearing the a/c compressor buzzing noise and then I realized the fan noise wasn't there!
View 7 RepliesGolf IV / Jetta IV :: Speedometer Stopped Working / Cruise Control Does Not Work
I am proud new owner of a 03 Mk4 Bora GLI. I have some issues that I could use a hand with. My symptoms are as follows:
1. Speedometer stopped working.
2. Fuel gauge goes on the fritz (rapidly declines) when parked on an incline or going around corners.
3. Cruise control does not work. "Cruise" light come on the dash but the set/reset button on the stalk does nothing.
Note: All fuses are in tact.
Golf IV / Jetta IV :: Only One Of Radiator Cooling Fans Working
I have a quick question, I got a 2005 mk4 gli, and when the cooling fans go on, only one works, the other one does not, I checked the fuse and its fine.
View 13 RepliesDodge - Charger :: Cruise Control Stopped Working / Brake And Traction Control Lights Constantly On
My college son's 2014 Charger V6 has developed three issues since he purchased it used in late May. The cruise control has stopped working and the anti lock brake and traction control lights are constantly on. Any possible cause?
View 15 RepliesSanta FE SM (2001-06) :: Cruise Control Has Stopped Working
My 2002 Santa FE's cruise control has stopped working, light comes on but no hold or anything, any obvious faults they have that I can try. I checked the fuse, that's OK...
View 7 RepliesBuick - Parkavenue :: Cruise Control Stopped Working
The cruise control stopped working. The "Cruise" light comes on, but the speed does not hold.Where should I start looking? Where is the control module?
View 4 RepliesKia - Sedona :: 2002 - Cruise Control Stopped Working?
On my 2002 Kia sedona mini van my CC has stopped working. How do they work and what should I look at as reasons why it just stopped? I just had all the belts replaced and crank shaft sensor replaced, could any of that have played a role?
View 5 RepliesGolf IV / Jetta IV :: 2002 - A/C And Both Fans Stopped Working?
So I just got a 2002 1.8t, everything was fine until the fans and ac stopped working. After poking around the forums a bit I changed the following:
1. Fan Control Module. Result: nothing
2. Radiator Cooling Fan Switch Temperature Sensor. Result: nothing.
all fan components have the correct voltage going to them. Fuse 16 for the AC clutch is not blown and has power going to it. The AC compressor has power going to it. The fuses on the battery box have power going to them specifically S180.
My question is what am I missing? is it possible that the fans themselves could be bad? car is not overheating, the after run coolant pump kicks on. But the AC clutch is not spinning nor are the fans. btw AC clutch is not seized up.
Camry :: 2000 Vehicle Overheating - Radiator Fans Kick In And Then Temperature Goes Down
My Camry seems to be overheating. When I'm driving the gauge maintains and reads 6/10, when the engine is idling, it goes upto 8/10, radiator fans kick in and then temperature goes down to 6/10 and keeps cycling over a period of 5 mins.
It's got 100K miles, water pump has not been replaced yet.
I checked the hose temperature; top hose 210 F, bottom hose 192, fans kick in when top hose is around 215 F.
I checked the engine temperature where the sender is installed and it was reading 205 F. Coolant level is OK. I burped the system. Previous owner told me, he had thermostat replaced by dealer.
Prius (2010-12) :: Cruise Control Suddenly Stopped Working
My cruise control all of a sudden stopped working today.
View 7 RepliesSanta FE SM (2001-06) :: Cruise Control Stopped Working Suddenly
Never had any issues with it before and was working fine on a trip a couple of weeks ago. On the way home I had it on, we stopped to get some food, and then when we started up again cruise control wouldn't turn on at all. I tried turning on and then setting, but nothing happened so I don't think it's the light. Checked the fuse and it looks fine (no noticeable distortion or break to the wire anyway) and brake lights all work.
View 8 RepliesSanta FE SM (2001-06) :: 2004 GLS Cruise Control Just Stopped Working
I have a 2004 Santa Fe GLS that the cruise control just stopped working. It will not turn on when I press the ON button. Could it be a blown fuse? I recently had a new AC compressor installed. Could it be related to that? Maybe something didn't get plugged back in?
View 1 RepliesFord F-150 (2004-2008) :: Cruise Control Stopped Working
I have a 2003 F150 4x4. One day my cruise control was working fine and the next it wouldn't work at all. When I push the set button the little green light in the dash blinks on then off and the cruise won't set. Any way that I can check to see what it might be myself or am I going to have to pay a dealer to fix it?
View 2 RepliesFord Excursion :: 2001 - Cruise Control Stopped Working
One day it work and the next day it didn't. I checked the 15a fuse and it was good. What else should I be looking at?
View 12 RepliesVolvo - 740 :: 1991 - Speedometer / Odometer And Cruise Control Stopped Working?
I have a 1991 740 Wagon with ~153,000 miles. I say approximately, because the speedometer, the odometer, and cruise control stopped working. My mechanic says it is the sensor loctated on the differential, I believe he said.
2 questions: My local Volvo junkyard has gone out of business; where is a good place online to get used parts? and second, .is sensor difficult to replace? I can fix things that are easy.
Mazda - Brakes - Lights - Protege5 :: Cruise Control Stopped Working
Cruise control and right/left brake lights have stopped working. Upper brake light still works.
View 10 RepliesFord 6.0L Power Stroke Diesel :: Cruise Control Stopped Working
My cruise control stopped working today on my trip back from Yosemite. Tried looking through the owners manual, but apparently it doesnt have its own fuse. Everything else seems to work just fine, so I am gonna start there.
View 14 Replies