Ford F-150 (2009-2014) :: 2013 FX4 - How To Remove Right Side Valve Cover To Replace Gasket
I have a 2013 FX4 with the 3.5 twin turbo engine. How to remove the right side valve cover to replace the gasket? I have loosened the perimeter bolts and was able to get it to move slightly but nothing more. I also removed the spark plugs thinking that they might be holding the tubes which are connected to the valve cover by round seals. I have not removed the seals since I was concerned that I might damage them. Do they need to come off? If so how do I do it? It's amazing how complicated this job is! Short of calling the dealer service, I have just about exhausted all my usual tech resources.
View 4 RepliesPassat (B7) :: How To Remove Engine Cover
Thinking of cleaning up the engine bay of my Passat 3.6 V6. How to remove the engine cover of a Passat 3.6 V6? For asian cars, it is fairly straightforward.
View 2 RepliesPassat (B5) :: 2001 - Both Valve Cover Gaskets Are Leaking
I took it to the stealership to get the alternator and some vac. lines replaced all under an extended warranty. They informed me that both valve cover gaskets and right side cam adjuster gaskets are leaking. By no means am I a mechanic or close to but I am trying to get this stuff done as cheap as possible so I am going to try to tackle this myself.
View 3 RepliesPassat (B5) :: Few Leaks Coming From Valve Cover Gasket
I have a 99 passat 2.8 v6, that closing on 200k miles, and its a car i'd really like to keep, lately i've had a few leaks coming from valve cover gasket, which i replaced, and now from the front drivers cam, and the rear passenger cam, the smell is terrible and the smoke is worse, i clean out the pcv but its still happening, i talked to a mechanic he says with that many miles i should just do the timing belt and get the seals done.
View 19 RepliesPassat (B5) :: Hot Oil Leaking From Valve Cover And Tensioner Gaskets
So, weird smell that I thought was burning plastic or rubber is actually hot oil leaking from the valve cover and tensioner gaskets.
My car is nearly 8 years old (2003), and has about 70K. Should I go ahead and buy a timing belt kit and replace all that stuff at the same time?
Passat (B6) :: Oil Leak Under The Hood Around The Front Of Valve Cover
Well I popped the hood to clean my air filter and noticed that the top of the engine looked to sprayed with oil mainly on/around the front of the valve cover. I haven't really "investigated" to see where its coming from. Where it may be coming from!! It has 32,XXX miles and auto.
View 4 RepliesPassat (B5) :: 1999 - Dipstick Funnel Broken
I bought a 1999 Passat 1.8T a few days ago. I noticed before I bought it that the dipstick funnel was broke but I knew it was only a $2 part. Today I bought the part at a local dealer and went home to install it. Problem is the old one is actually broke in half. One half remains on the dipstick the other half on the tube. I can't for the life of me get that thing off the tube. I have a inspection scheduled at the dealer tomorrow so if I can't get it off I will probably just have them do it.
View 1 RepliesPassat (B5) :: Oil Loss After Cam Tensioner And Valve Cover Gasket Replacement
I noticed the oil smell that can be associated with a leaking Cam Tensioner Adjustor Seal from my 2003 1.8T Passat a few months ago. The dealer confirmed that it was leaking and that it was covered by my extended warranty since my car was 5 years old and at 70K miles. I had the work done and after I picked up the car I noticed that the oil level was at the top of the hashes not at the top bend like it was when I took it in.
I don't know what caused it to drop to the hashes but I do know that the level has dropped to 3 visible hashes in the little over 1K that has been put on the car since then. I am concerned because in it's first 70K miles the car did not visibly lose a drop of oil.
Any logical cause for this annoying trend, the only thing that changed was that the Cam Tensioner and Valve Cover Gaskets were replaced. Is it possible something else was messed up during the repair?
Passat (B6) :: Small Leak From Back Side Of Engine - Valve Cover
Today I did a oil change (70k). While under the car I notice a small leak from the back side of the engine. When I got home, I had the chance to remove the engine cover to investigate and clean the engine up a bit.
I found that the bolts in the rear of the valve cover had a little puddle of oil around them. I took a T-30 torque bit and was able to get a least a full turn on the rear bolts and about half turn on the middle ones. Fronts were about a quarter turn. Check your valve cover bolts.
Passat (B5) :: CEL - Smell After Emissions Work - Oil Leak On Rear Valve Cover?
Last week my check engine light went on. Some hoses needed replacement and the mass air flow sensor was out of spec - I had it replaced as a preventive measure.
Now the car seems to have a subtle oil/exhaust/acrid smell, especially after car has been driven 15 minutes or so and in stop and go situations. When I step outside the car, an acrid smell appears around the engine and tailpipe area.
Check engine light is off - I took it back and they could detect nothing amiss - granted the whole garage smells like oil and exhaust. They did find a "class 1" oil leak on the rear valve cover - just a bit of oil on the rim - not yet dripping.
Passat (B5) :: Burning Oil Smell When Stopped - Cam Seal And Valve Cover Gasket Leaking
After reading some posts I think my passat could have the cam seal and valve cover gasket leaking. I smell burning oil when stopped. How much should this repair cost if I go to an indy repair shop?
View 3 RepliesPassat (B5) :: Replacing Catalytic Converter, Valve Cover, Cam Seals And Timing Belt?
I have some serious work that needs to be done on my car. The catalytic converter needs replacing, and the valve cover gasket and cam adjuster seals need to be replaced. This work falls under their respective warranties. However, I'm wondering if I should have the water pump and timing belt done at the same time as I have 77000+ miles on my car. Is there anything else that would be good to do at the same time as this work. I would be going back to the VW service center for these repairs. Would it save me any money to do this all together?
View 4 RepliesPassat (B5) :: Tapping Sound Coming From Back Of Valve Cover After Warmed Up At Idle
I have a 2001 1.8t tip wagon(75k) that that is starting to worry me. It makes a tapping sound (coming from back of valve cover) AFTER it is warmed up at idle. When the RPMs go over 1,000, the sound goes away. Is this the cam chain adjuster or tensioner??? Also, when the engine first starts up it makes a similar noise , only louder, for the first couple of seconds.
View 5 RepliesGolf/GTI VI :: Valve Cover Leaking?
I had it checked out at the dealer and they called it a "weep" so they went on to tell me that VW probably wont approve warranty work for it. I pushed for them to take pictures and send it in anyway.
Now assuming they won't do it, I have been looking for a DIY or a technical order on the job but I can't find anything.
Tiguan :: 2012 - Valve Cover Is Leaking Out Oil
Just found valve cover of my Tiguan is leaking out oil this morning. Will go to dealer tmr for gasket replacement. My car is just over 50k miles. What happened to VW's car quality control???
View 5 RepliesAccent MC (2006-11) :: Valve Cover Leaking?
Haven't had the engine cover off for about 25k now (cleaned it up under there last time I changed plugs.) Took it off today and noticed it's a little oily on all four sides around the valve cover.
Pretty sure I can account for the oil that's near the filler cap... I don't recall spilling enough that would completely go around the entire valve cover though...
But how did it end up so high on top of the valve cover on the corners? It's even a little wet looking on the back if you look hard enough..
I only have 4600 miles left of the 10/100 warranty so I'm glad I caught this and hope the dealer can do something about it... or are they going to tell me this a "normal" amount of seepage? I haven't owned a vehicle with plastic valve covers before so I don't quite know what to expect.
Santa Fe (CM - 2007-12) :: Oil Seepage From Valve Cover
So with about 70,000 km on my 3.3 V6 I'm noticing some oil seepage from the valve cover gasket. It's not enough to budge the oil level on the dipstick, and frankly not the sort of thing I would bother having fixed (especially with a leased vehicle). The only thing bugging me is that the alternator is getting pretty grimy and dirty from it, and I'm wondering how much it can take.
View 12 RepliesCamry :: Broken Bolt In Valve Cover?
I was loosening the bolt that holds down the number one spark plug wire when it just spun off leaving less than half the bolt in the valve cover. I tried using the grabbit extractor but that did not work.
View 8 RepliesRepair :: Leaky Valve Cover Gasket
when replacing valve cover gasket, using the cork based one. Do you use any gasket sealant or any kind of silicone or just put it in by its self.
View 5 Replies