Ford Ranger / B-Series :: 2003 - Valve Cover Leak / Exhaust Smell Then Started Bogging / Dying And Shaking
I have a 2003 ford ranger 2.3 vin d 5 speed, this truck originally... Took it in for wires plugs front brakes fuel filter battery and added a small cold air intake. We discovered a valve cover leak and while repairing guy drops a screw into a valve and when finished he started it lodged the screw between the valve, shearing off a cam sprocket bolt. Throwing the timing. 2 valves on the exhaust side were bent and replaced. no damage to the head.
Timing was reset and the truck was running. 2 days later truck is running/had a hint of exhaust smell then started bogging dying and shaking, at which time we got an 02 bank2 lean code and fixed that. it cleared code and didn't fix it. From there we replaced coil, imrc intake bc of a crack, tried and check all vacuum, reset the timing. Timing would slip before but no longer than 10 minutes every time truck started.
Found the hole in the timing cover that holds the bolt to torque? to harmonic balancer was broke. replaced along with the diamond washers and cam sprocket bolts. timing finally held crank sensor was adjusted. truck came home for one day running good, we had removed the cold air intake and replaced the factory air intake. next day it was so slow outta first gear, you must baby the throttle, if you floor It, it sputters and kinda pops, truck stays slow all the way to about 10 mph and 2000rpm then it begins grabbing speed, 3000rpm is where this truck shifts the best, 2nd is better, third better than that.
As rpm increase the truck runs better, it idles steady at 1100-1200rpm at stops with an audible miss and then struggles again on takeoff. Here what im wondering, the truck has an abs sensor that just came on, but no codes showing now.tomorrow I wil run matko determinator 3.0 on it. and test the catalytic converter. first how do I check the timing belt to see if it stretched? do these trucks store the p.i.d.s. koer or kams that could cause one, all, or any of this and if so do I have to have it flashed from ford or can you manually do this without a drive cycle test.
Passat (B6) :: Oil Leak Under The Hood Around The Front Of Valve Cover
Well I popped the hood to clean my air filter and noticed that the top of the engine looked to sprayed with oil mainly on/around the front of the valve cover. I haven't really "investigated" to see where its coming from. Where it may be coming from!! It has 32,XXX miles and auto.
View 4 RepliesPassat (B5) :: Burning Oil Smell When Stopped - Cam Seal And Valve Cover Gasket Leaking
After reading some posts I think my passat could have the cam seal and valve cover gasket leaking. I smell burning oil when stopped. How much should this repair cost if I go to an indy repair shop?
View 3 RepliesCamry :: 2002 - Small Oil Leak On Rear Passenger Side Of Valve Cover
2002 Camry 4 cyl was leaking a small bit of oil on the rear passenger side of the valve cover - about directly behind where the timing chain is. I replaced the valve cover today, but noticed that there is still a small amount of oil leaking at the same spot. Is this a common problem with the '02 Camry? Or perhaps I have a valve cover problem?
View 2 RepliesPassat (B6) :: Small Leak From Back Side Of Engine - Valve Cover
Today I did a oil change (70k). While under the car I notice a small leak from the back side of the engine. When I got home, I had the chance to remove the engine cover to investigate and clean the engine up a bit.
I found that the bolts in the rear of the valve cover had a little puddle of oil around them. I took a T-30 torque bit and was able to get a least a full turn on the rear bolts and about half turn on the middle ones. Fronts were about a quarter turn. Check your valve cover bolts.
Sonata I45 (LF 2015+) :: Oil Burning Smell After Driving - Leaking Valve Cover Gasket?
I've been noticing an oil burning smell after driving recently, it's been going on for a few days now. My oil level is good, I have 8,500 miles on the car. Today I finally had a chance to look under the hood for any visible leaks, and I noticed some oil stains on what I think is the valve cover gasket.
2015 Sonata 2.0T ...
Camry :: Oil Leak Coming From Valve Cover Gasket
so I have a 2azfe engine
So there's an oil leak coming from the valve cover gasket (just purchased vehicle dirt cheap with 220k)
found this
Notice all the oil sitting on top of the exhaust mani gasket
In the left(lower) part of the picture it appears to be scraped.
the gasket appears to be newer, I did NOT use a screw driver to remove the valve cover, which is what this appears to have been done..
Can this be sanded down then filled with jb weld, and then regasketed?
Golf IV R32 :: Coolant Leak At Valve Cover Gasket
I've got a coolant leak here (I wiped away some of it before taking the picture):
Close up
This is the only place I can find coolant leaking and it's running down all the way to the water pump:
When I wiped away from just below the valve cover gasket it flaked right off and it doesn't appear there is any oil mixed in. I changed the oil today and it didn't appear to have any coolant mixed in either.
The coolant doesn't appear to have any oil in it's nice and pink as it should be. I started the car from a cold start and sat and watched the area waiting for it to leak but nothing ever came out, of course.
I know there shouldn't be coolant leaking from this area anyways but I don't know how else to explain the trail pictured. I definitely have a small leak somewhere as I've found coolant on the floor of the garage before.
Do I just replace the valve cover gasket and move on or is there something else I should be concerned with here?
Sonata NF (2006-10) :: 2007 - Valve Cover Leak
I have a 07 Sonata and having recurring valve cover leak. First time it happened it leaked onto my alternator and had to get car towed and whole bit. About a year later they discovered it again during routine oil change and had it fixed again. Yesterday during a routine oil change, they discovered a leak again!! I know this is an established problem but how many times can the same problem occur?? I'm passed the warranty (103K).
View 3 RepliesSanta Fe (CM - 2007-12) :: Oil Leak On The Valve Cover Over The Alternator
I have a 2009 Santa Fe Limited with 82000 miles. I have replaced four (4) batteries since it was purchased, new, in March, 2010. I have repeatedly taken it to the Hyundai dealerships in Las Vegas, Nevada and Centennial, Colorado, for an oil leak on the valve cover over the alternator. At no time has the service technicians at the dealerships ever told me there was problem. Last Thursday, the latest new battery, installed that same day, failed. I had my independent garage technician assess the multiple battery failures, with the associated battery display light illumination, related to the location of the continual oil leak. He stated that the cause of the battery failures was from the oil damaging the alternator. I contacted Hyundai Customer Service, today, and was told that there have no reported problems from oil leakage onto the alternator, with subsequent damage to it, and/or the battery.
View 3 RepliesPhaeton :: Leak From Left Valve Cover Gasket
I had a very slow oil leak that dripped onto the garage floor and i brought it into the dealership. They said it was a leaking left valve cover gasket; I searched and came up with nothing? The engine has just over 30K miles on it.
View 20 RepliesGolf IV / Jetta IV :: Oil From Valve Cover Leak In Pistons
I drive a 2003 24V VR6 GLI
I recently did a valve cover repair to stop the dreaded misfire problem. Well, I'm still waiting on a few things but during the spark plug change obviously some of the oil from where the valve cover leaked previously fell into the pistons because I couldn't really clean it all out efficiently. This seems like it would cause a lot of problems? Do you think I should throw old spark plugs in there and let all the oil burn up before finally replacing them? I really don't want to foul up my brand new NGK's.
Also, I pulled p0300, p0305, p0306, so I am guessing oil in the spark plug/coil pack connection may cause some of the misfires, but do you think two of my coil packs are bad still? My plan was to move them around to see what happens after I get the new parts and am actually running again.
Golf/GTI VI :: 2010 - Oil Leak Around The Valve Cover Gasket?
I just noticed what appeared to be an oil leak around the valve cover gasket, which the VW dealer has determined to be a defective cam sensor. Apparently the VW parts distribution center in Wisconsin has 530 of these in stock, so it may be a common failure. This is on a 2010 GTI with 28,xxx miles. Thought the community would like to know.
View 2 RepliesPontiac - Grandprix :: 2001 - Major Oil Leak Under The Valve Cover
I have the 3.1 V6 in my 2001 Pontiac Grand Prix and today it started spewing oil out of what looks like an electrical plug in the front, toward the bottom just under the valve cover, dead center. What is this plug?
View 3 RepliesVolvo - Xc70 :: 1999 - Oil Leak Puddled On Top Of Valve Cover
1999 Volvo V70 XC. The car is a 5 cylinder turbo charged w/automatic transmission. I removed the plastic panels from the top of the valve cover to discover oil puddled on top of the valve cover. Not sure if it is the fill cap leaking or something more serious. I noticed a rubber tube that I assume is part of the PCV system could this be the source? Also, the car uses oil between oil changes. The manual says to use 5W30 weight oil, but most of the European cars I've owned use 20W50 due to the high compression and torque. I'm wondering if 20W50 might reduce oil burning.
View 3 RepliesFord F-150 - 1997-2003 :: Oil Leak - Valve Cover Gasket?
So, when I bought my truck, it leaked oil.....bad. It goes through around 2-3 quarts a week. I needed a vehicle, this one was cheap, so...I run it. Every other day, I put half a tank of gas and a couple quarts of oil in it. It leaks on the passenger side, right above the starter. I figured it was the valve cover gasket, and planned on changing it today. I saw a post about the "typical" head gasket oil leak, which sound suspiciously like what mine is doing. I have no oil in the coolant,or vice-versa.....
View 9 RepliesElantra XD (2001-06) :: Minor Persistent Oil Leak From Valve Cover Gasket
Looking for some insight into the state of the motor in a 2002 XD. Short story is that it appears to be leaking oil from the valve cover gasket (common, I know) and sometimes winds up running extremely low on oil before it gets changed. When draining the minimal oil in these conditions, non insignificant amounts of water can be found along with the drained oil.
Car is at 155k miles, has exhibited this behavior for more than a year, and has no noticeable knocking issues, power loss, mpg loss, heating/cooling issues, or any other ill effects other than apparently making a mess in the engine bay, on the ground where it parks, and scaring people when draining the oil.
Logically this is going to not be the case forever.... Thoughts? Prognosis? Treatment?
Volkswagen - Beetle :: 2003 TDI - Compression Leak From Valve Cover Around Number 1 Cylinder
I purchased a 2003 VW Beetle Diesel and have compression leaking from the valve cover around the number 1 cylinder. It does not run or will barely run. Is this a common problem and what could cause this. i haven't tried anything yet.
View 2 RepliesSonata NF (2006-10) :: Valve Cover Gasket Leak But Minor As Dirt Stick To It
I'm suspecting a small valve cover gasket leak. I've noticed dirt starting to accumulate near the alternator side of the front valve cover, there is dirt on there stuck to oil, I don't see any wet oil but its so minor the dirt just sticks to it. 107k miles here. Seems to be a common problem. I think Downhiller had a large oil leak, source unknown around his crank pulley area. You wouldn't think a car this young would leak oil. It's not bad, I havn't had to top any off I just like a mildly clean engine.
View 38 Replies