Passat (B6) :: Shuttering In Front End When Go Over Harsh Bumps - Bad Engine Mounts?
I have a 08 2.0T sedan with 97K that I have been chasing a "shuttering" feeling in the front end when I go over harsh bumps like railroad tracks and frost heaves that we get on roads here in NE.
At this point the front suspension has had a lot of improvements done and problem still exits.
Front suspension work over last 6 months:
- New LCA Bushings (solid rubber style rear and Whiteline front)
- Koni FSD Shocks
- VW DG Sport Springs
- 034 Density upper strut mounts
- Meyle HD Sway Bar Link
- ECS Sub Frame Bolt Kit
After all this there is actually an increase in this shuttering feeling most likely due to a firmer suspension now with new springs.
The car drive fantastic, the feeling that there is something loose up front and the shuttering feeling when hitting harsh bumps is diving me crazy.
In addition, I drove a local VwVortexer's 06 Passat that is riding low on coilovers and it did not have this same shuttering from the front so pretty sure what is going on in my car is not normal.
Completely went through front suspension last night and tripled checked that everything is tight and secure!
Also, have upgraded sub frame bolts with ECS kit and checked all the bolts to make sure they are tight and all is good.
Since after all this work and substantial $$$ investment the problem is still there, should I be looking at motor mounts ?
The engine/tranny is no where near secure sitting in the existing mounts, have noticed two things that have been this way for quite awhile.
If parking brake is not on when tightening or breaking loose lug nuts car has a lot of rock back and forth and you can see engine moving a lot if hood open.
Last night I put a large screw driver between right side mount where piece from engine goes into frame mount and I can move engine side to side with minimal effort about 1 1/2" or more.
One more thing, when coming to a slow stop at the last downshift just before you stop I get a light clunk from left side somewhere and if you slow down from 50 mph or so to 25 to 30 mph and then put gas back on you get a left side clunk too but not always. Does it sound like bad mounts?
Passat (B5) :: Front Suspension Clatter / Most Apparent Over Sharp Bumps
2003 passat gl; 1.8t w/all new front control arms, replaced to cure suspension noise, now metallic clatter persists, but any (even) light application of brake pedal and noise stops.. it is most apparent over sharp bumps...
View 3 RepliesPassat (B6) :: Front Suspension Squeaking Noise When Going Over Speed Bumps
2010 VW Passat - Sedan
See the attached videos. The first one (night time) was made before I took the car to the dealer the first time. Dealer said that I was going too fast over the speed bumps, so I made another video (daytime) showing the speed (10-13 mph). Both times you can hear a squeaking noise coming from the front that I just started hearing last week. The car has only 23,000 miles on it. I bought it brand new back in September of 2010. I don't know what to do because the dealer (of course) says that they checked everything and there is nothing wrong with the car.
What was the cause of it. I can take it to a mechanic and check it myself and then bring it to VW for repairs and telling them exactly what's wrong and why.
Video 1 .....
Video 2 .....
Passat (B6) :: 2006 - Front Suspension Squeaks Quite Over Bumps When Cold
I've got a 2006 b6 2.0 with about 92k on it. I bought it Cpo at around 68k 3 years ago this December. My auto tech said I'm going to need a new timing belt in about a month, so once this semester is over in a few weeks I'll be taking it in for that. Anyway, to my questions. My front suspension squeeks quite a bit going over bumps, especially when cold. Is this a sign of bad things to come in the future? Now my brakes, when they get wet they give off a very rough feeling, not very smooth. I have to slam on my brakes to 'wake them up'. Is this telling me they need to be replaced?
View 2 RepliesPassat (B6) :: Noise From Front Suspension When Going Over Small Bumps On Roads At Low Speeds
I'm getting ready to do some maintenance such as flushing the brake fluid, new air filter, and changing spark plugs. I've noticed lately a noise from what I'm assuming is my front suspension that can be heard when going over small bumps on roads at low speeds. It sound like a squeaky spring, almost like something needs to be oiled. I'm still on stock suspension with close to 80k on the clock, so I was wondering if there is anything in particular I should look for when I'm messing around the wheels bleeding brakes, or if there is a common procedure to lubricate something so the noise stops. I can hear it from inside the cabin so I imagine you can hear it from outside the car.
View 3 RepliesPassat (B6) :: Harsh Ride - Ture Grinding Especially Over Some Turns Or Speed Bumps
In a nutshell, I'm tired of my incredibly harsh ride. I drive a 2006 3.6L with H&R Sport Springs. I had to put spring boosters in the rear to keep the tire from grinding, but whenever I have a passenger in the back it still grinds, especially over some turns or speed bumps.
The ride quality is also very harsh, it sucks. Plus the front wheels can't align anymore (at least that's what the guy at the mechanic's told me.) Basically, I want my ride quality to improve a lot. I'm debating going back to stock, but I'm not going to like the big gap in between my wheels.
Passat (B6) :: Suspension Feeling Harsh At Times?
Some days car's ride very smooth and other days you feel every bump with the suspension feeling harsh at times. For some reason after it rains the car rides better as well. Do the tires soften up when there is moisture? Sometimes the temp. outside also affect things. Is it just my imagination?
View 4 RepliesSilverado :: 2001 - Front Suspension Bumps
I just recently did some work on the front end of my 2001 Silverado 2500HD (Replaced hub bearing assy, rotor and pads), and while working on the front end happen to notice something I need some guidance on. I happen to notice the bump stops are basically crushed as if the vehicle just sits on them all the time. Would it be worth it to replace these and would they just get crushed again, and further, should I adjust the torsion bars a bit to lift the front end up off of these?
I don't want obtain any huge lifts, just want to get off the bumps and maybe improve the ride a little bit in the process. I also did have a bad hub bearing on the drivers side and after seeing this bump stop wondering if that might be why.
Golf VI R :: Front Suspension Clunking Over Bumps?
Aside from the clutch and gear changing noise, recently I've been noticing something that sounds almost like a rattle when going over bumps, say a series of filled potholes on a highway where they just slightly bump to move your wheel around, it's not that deep thumping you would expect to hear but it sounds like something is loose in terms of the suspension.
Happens on the front and seems like its coming from both sides. To me it sort of sounds like they forgot to tighten something up when they removed the shipping "blocks"/spacers, but I am not exactly sure what to check. I really do not want to visit the dealership at only 600 miles on the clock ...
Golf IV R32 :: Clunking Sound From Right Front Suspension When Going Over Bumps
I have a clunking noise from the right front suspension when going over bumps. I've replaced the Strut bushings that were collapsed, the control arm bushings that had play and the noise is still there. There is no play in the links. There is a slight noise in the sway bar bushings when struck with a rubber mallet. I hate to keep replacing parts chasing down this noise.
View 9 RepliesPhaeton :: Front Suspension Creaking Sound When Going Over Bumps
Just recently I've been hearing a slight creeking sound coming from the front end when going over bumps. I don't have a lot of suspension knowledge so I'm not sure where to start looking and wanted to see if others had the problem, and what the outcome was? The car is at 60k miles.
View 20 RepliesLexus LS 2007+ :: Front Suspension Is Blown / Bouncing When Go Over Bumps
Feels like the front suspension is blown in the front of my car and i got an alignment not too long ago and the sides are feathering already. spoke to couple of my friends and we have confirmed that the front is blown and also when i drive i see the front bouncing when i go over bumps. I just want to ask the people who did remove their stock suspension and see what brand they are.
View 8 RepliesSanta Fe (CM - 2007-12) :: Clunking Coming From Front Suspension When Go Over Bumps
I can't find the obd port on my new 2007 SF. Also there is a clunking coming from the front suspension when i go over bumps, what is the most common cause of this?
View 13 RepliesPassat (B7) :: Noise Coming From Rear Suspension When Going Over Speed Bumps
I'm new to vw and I have a passat 3.6 sel premium and I have been hearing a noise coming from my rear suspension when I have a full car or going over speed bumps and such. It took it to the dealer and they said that they couldn't replicate the problem, could it be the control arms or it's bushings? The car is only 6 months old smh.
View 8 RepliesPassat (B6) :: 2006 - Suspension Noise When Going Over Bumps Early Morning
I am having problems with suspension noice in the early mornings going over small obstacles or bumps on the road. I have complained to VW dealer and they changed something in my rear suspension, but the noice is still here. I think it is coming from the front suspension. 2006 Passat. It is usually in the am when i start the car and than goes away later.
I think this is what they did for me, but it did not fix the noice.
[URL]
I am thinking that I should go back and see about this TSB
[URL]
Lexus LS 2007+ :: 2009 LS460 AWD - Front Suspension Noise When Hitting Small Bumps
I have a 2009 460 awd with adjustable suspension and when making a right turn the front left side makes a noise. I have had the dealer look at it 5 times or more but each time I am told that there are no problems. Now that the weather is getting colder it is becoming more pronounced.
View 7 RepliesFord Escape / Hybrid :: 2012 XLT Front End - Inside Tire Wear And Suspension Pop Over Bumps
I realize that is vague. I realize it could be anything from a wheel bearing to a ball joint, tie rod, control arm/control arm bushing, etc.
Are there any very common front-end steering or suspension issues on 2012 escapes? When tires are inflated to 32-34psi, the car tracks straight, gets great mileage --but almost sounds/feels like it's got a CV or wheel bearing issue on the front right. Every time I hit the brakes while backing out of the driveway I can hear a slight bump or pop. When the car is parked (flat, tires straight) there is slight play left-to-right in the steering wheel.
I'm a German car guy. Have never touched this car. (Wife's car) Right tire is wearing bad on inside. Looking for some direction so I can assess. Car has 88k miles. This will be a DIY fix. Don't have any manuals or anything so just looking for a heads up where to start. Also is Haynes the best way to go? Is there a Bentley? Anything online/CD/DVD?
Play in steering wheel makes me think tie rod (fine because easy/cheap) but such excessive wear on the inside right front makes me think wheel bearing. Could it be both? This is AWD. Is this (like a Subaru) a CV joint where the front spindle passes through a strut base that everything attaches to --so there's an inner and outer wheel bearing?
Does anything up front require a press or can it all be done without a press?
Prius (2010-12) :: 2015 - Ride Is Really Harsh When Going Over Bumps
My 2015 prius series 5 ride is really harsh when gong over bumps! 17 OEM wheels w Toyo tires set at 33 frt/32 rear, Trd springs frt/rear, trd rear sway Cusco frt sway bar, front power brace and center brace! Should go back to stock springs? Or invest in set of soft coil overs ? I like the lowered look too!
View 4 RepliesSonata NF (2006-10) :: 2007 - Clunk In The Front Suspension Making Noise While Going Over Small Speed Bumps
I have a 2007 Sonata Ltd (63000 miles) and had a clunk in the front suspension. I had the front upper control arms replaced (which were visually badly worn) and that fixed the problem. But now, a several months later another similar clunking noise has developed when I go over those small speed bumps in parking lots.
View 18 Replies