Sonata NF (2006-10) :: Oil Pump Chain Position?
I had an oil pump failure in 1 2.4 L Sonata, 2006. I am ready to install the new oil pump balance shaft unit but cannot find where the timing marks on the pump pulley and crank should be? The service manual I bought simply says the correct position is critical. Any position or a simple diagram or link? It is a chain drive pump.
View 1 RepliesPassat (B5) :: 2004 - Secondary Air Pump Hose Broken?
Ok so I accidentally broke the hose that connects the secondary air pump to the stock intake box and been looking around for a replacement. I have looked around and searched and searched and the only one I found is this one: [URL] .....
Will this work for a 2004 1.8T? I know it says that its for the 2000-01 but it looks exactly like the one that goes on mine. Haven't checked the dealer to see how much they want for it but it will most likely be an arm and a leg.
Nissan - Maxima :: Clunking Sound - Broken Timing Chain / Belt?
95 nissan maxima decelerated on highway, i heard a clunking sound, and then it shut off, i opened the hood and it smelled like burnt rubber. Checked all of the belts i could see..no problems. Car wouldn't start after this...and all i could hear was a clicking sound. Pulled 6 codes for the car including bad speed sensor and a misfire, as well as bad EGR...i think the timing chain/belt broke..but i can't access it.
View 3 RepliesToyota - Camry :: 1996 - Tranny Shot Sounds Like Chain Inside Broken
Can swap a 98 Toyota Camry auto tranny to a 96 Camry with the same size engine? Sometimes the axles are different (splines) so if the axles are changed also then the tranny will work. But the axles and tranny all have to be switched?Driving down the road at about 65 mph there was a clunk, a binding like brake stuck thing going on, and then the tranny would not move the car. It seems as though the chain, if there is a chain in the tranny, broke. Someone told me it is the gears (planetary) on the right hand side of the transmission that drives the axle. No one including me has gone under it to look. But I do have access to that 98 tranny and axles.
View 15 RepliesFord Super Duty (1999-2016) :: 2008 V10 - Timing Chain Broken Or Fell Off On The Passenger Side Bank
Today I either broke timing chain or it fell off on the passenger side bank of my 08 F250 V10. Put a hole in valve cover. What to expect for repairs. Is this engine Zero tolerance.. unsure if I should expect bent valves or not and just how far I may have to go with this.. best way to test. I have a bore scope camera and mechanical abilities.
View 14 RepliesC/K :: 99 K1500 5.7L Won't Run After Replaced Timing Chain And Water Pump
I just replaced the timing chain and water pump on my 1999 K1500 5.7L. After spending several evenings and a few early mornings working on it, I get everything back together and go to start it up. It starts then immediately dies. After double checking that the CKP sensor, two plugs on breather, and a/c and alternator wires (these are all that I unplugged) are connected I try in one more time before coming in to work today.
Timing chain was installed with No. 1 at TDC and mark on cam at 12 o'clock position as stated in the Haynes manual for the truck. I did not remove or even touch the distributor since replacing the intake gaskets ~3 years ago. Will check to see if any codes are showing in the morning when I have my laptop at home.
Passat (B6) :: 2006 - Safe To Drive With Broken Exhaust?
The exhaust pipe on my 2006 Passat broke towards the front where it comes down from the engine bay. Am I going to mess it up or hurt anything by driving it this way temporarily (1 day at most) or is it just going to be loud and a little sluggish?
View 7 RepliesHyundai - Sonata :: 2007 - Does Timing Chain Tensioner Affect Oil Pump
My son's 2007 Hyundai Sonata had an engine noise that was eventually diagnosed as bad timing chain tensioners. However, one Hyundai dealer repeatedly denied the problem, so it was 8 months before another Hyundai dealer admitted it and changed the tensioners. A couple of months later, the engine light and oil light were on and he was told he needed a new oil pump. By this time, the warranty had expired and he had to pay for the new oil pump and eventually a new engine. My question is this: Could the failure of the oil pump have had anything to do with the timing chain tensioner problem?
View 19 RepliesPassat (B6) :: 2006 2.0t - Timing Belt And Water Pump Replacement?
How to change the timing belt and water pump on a 2006 2.0t passat?
View 3 RepliesSanta FE SM (2001-06) :: Power Steering Pump Pulley Broken
My Santa Fe has a broken power steering pump pulley. Darn thing broke right around the spindle! I can not find a replacement anywhere. I've tried to find a one new, used and at the upull lots (only one Santa Fe in at Pick n Pull dang thing was stripped clean!). The pump is easy to find but this pulley is a ghost!
View 3 RepliesGolf IV R32 :: Check Engine Light Come Up / Secondary Air Pump Broken
I recently had a check engine light come up on my 2004 r32. Dealer told me that the secondary air pump is broken and needs to be replaces, codes that came up were p1432, p1423, and p1411.
I replaced the pump and the next day I heard the "vacuum" sound of the air pump so I know that it works. A day later my check engine light come on again, and I cannot hear the pump anymore.
Now I just changed the pump, not even the rubbery inserts as I didn't know. The pipes seemed to be fine. I checked the quote from the dealer and they also mentioned that the intake pipe is broken, part number 1J0-131-128-AB.
Is that one of the pipes that is connected with the secondary air pump or it's the main intake pipe??? If it's from the main intake, is it possible that the secondary air pump want work because of that???
Should I change the rubbery inserts on the secondary air pump??? Is it safe to drive until I take care of this?
Passat (B5) :: Oil Leak At The Cam Chain Tensioner?
1.8t has an oil leak. My friend took it to a shop and they told him its leaking from the cam chain tensioner. I've never heard of this. Are they messing with him?
View 3 RepliesPassat (B6) :: 2006 3.6 4mo - Fault Codes For Catalyst System / AWD Controller And Haldex Pump
Ok, so I scanned a 2006 Passat 3.6 4mo. I got a fault for the catalyst system, a fault for the AWD controller, and a fault for the Haldex pump. I'm guessing the catalyst code is for the oxygen sensors? What should be my next course of action on the AWD stuff?
============================================
Address 01: Engine Labels: 03H-906-032-BLV.lbl
Part No SW: 03H 997 033 M HW: Hardware No
Component: P3.6-FSI-LEV2 G00 2370
Revision: --H11--- Serial number: VWZCZ000000000
Coding: 0000175
[Code] ....
Saturn :: Smelling Like Gas / Service Engine Light On - Fuel Pump Broken
I got my a fuel injector cleaning on my Saturn at the dealer. They sent me on my way with the car smelling like gas. After days of driving with the smell of gas, the service engine light on, and the car stalling I took back into the dealer. Now they are telling me that the fuel pump is broken and they want me to pay for it. This does not seem right. What happened. This seems to me something that the mechanic messed up...
View 9 RepliesHonda - Cr-v :: 2006 - Timing Chain Won't Working
I have a 2006 Honda CRV with 145,000 miles on it. It has been giving me warning lights for about 10 weeks. My mechanic discovered that it is burning oil, which he says all old cars do. But the lights continued. He put the computer on it and says that I need a new timing chain and it will cots $1,100.00. He also says he's not 100% sure that this will stop the lights. I don't want to sink that kind of money into the car if it won't correct the problem. The lights that come on are the check engine light, the VSA light and the triangle light. They do not come on all of the time. Maybe 3 time a week but they go off if I stop the car and re start it.
View 19 RepliesSonata NF (2006-10) :: Timing Chain Tensioner Replacement
Changing timing chain tensioner? Mine is making the rattling noise on startup. Tried searching one internet for any DIY's out there. Haven't really found any good ones.
View 7 RepliesPassat (B5) :: 2001 - Cam Chain Noise On Cold Starts?
01 V-6 2.8 30V 90000 mi, now hear cam chain noise rattle for appx one second on cold starts only didnt do it before the timing belt was just replaced,why is it doing it now
View 5 RepliesPassat (B5) :: Timing Chain Won't Working - Blown Engine?
I posted my passat to sell/part out last week. So I talked to the mechanic today and he hasn't looked in the engine. He just says that when the timing chain goes it wrecks the valves and pistons (needs rebuild). HE WAS TRYING TO SAVE ME MONEY THOUGH...FAMILY FRIEND. My sister got lucky on her passat and only messed up the valves. But she was sitting still....I was doing 80mph on 95 going to work. Should I have the engine looked at or sell it.....what are the odds I got lucky??? I found a lot of posts/blogs about how everyones engine blew, but no one said they got lucky.
View 9 RepliesSonata NF (2006-10) :: Rattling On Startup - Timing Chain Sound
The car has a rattling sound on start up and I read here that is the timing chain tensioner. The quotes for fixing it has been huge(from 900-2000 just for labor).
And I changed front struts and had Monroe put on the car, the ride is very soft and a bit bouncy. I had a 2004 Altima and the ride was very stiff and I loved it. By the way, the car is a 2006 V6 with 111000miles.