Golf V R32 :: Anti-Rattle Spring Damage After Replacement Of Brake Pads?
I took my R to a local mechanic to have my rotors turned and my brake pads replaced (RedStuff). A couple of days later, I noticed a loud noise coming from my front passenger wheel well when I was driving, and the pitch changed when I hit my brakes. It appears that the anti-rattle spring was not reinstalled properly because it has fallen in between my caliper and rotor, causing damage to the rotor and my aftermarket wheels. Since I'm not much of a DIYer, I wanted to get your opinion on the situation and how I should approach things with my mechanic. How hard is it to properly install the anti-rattle spring?
View 7 RepliesPassat (B6) :: E-Brake Won't Release When Change Brake Pads?
Having issues with the auto-ebrake? My friend has a 09 passat with the push button ebrake. He was changing his brake pads when his ebrake will not release. He was told by VW to not use a c-clamp to depress them as they would mess up the sensors or something along those lines.
View 14 RepliesPassat (B5) :: Engine Noise Sounds Like Rattle Consistent With Idle
'02 V6 30v with 73k.. engine noise sounds like rattle consistent with idle sounds like its coming from rear section of motor. i did search came up with a few probabilities but no resolutions just wondering if possible it could be oil pump because if i add oil then start up the noise disappears for a few mins then comes back, a few guys mentioned it could be camshaft tensioner.
View 4 RepliesPassat (B5) :: Brake Noise After Swapped New Pads
My independent mechanic just swapped out some PBR Deluxe pads that he put on with new rotors in June with with PBR Deluxe Plus pads. He did this free of charge because the front brakes were making a loud metallic clunk sound on the first brake application when backing up (weird, no?), and they were dusting like crazy. Back in the summer I followed the bedding-in procedure fellow Vortexers recommended. Aside from the clunk, the brakes were silent, though extremely dusty.
Well, after a couple of drives with the Deluxe Plus pads, I can say that they perform very well, just like the Deluxe pads before them. It's too early to tell if the dust issue is better, but the metallic clunk is still there, though far quieter than before (even with the windows open); I'd say its more of little click now.
But here's what I really don't like. I took the car out tonight to bed the brakes, doing 5 or 6 60-to-30 mph runs, followed by 5 minutes of 40-50 mph cruising with little braking and no real dead stops. All was good until I went to get gas afterward: as I slowed to <10 mph, I heard some squeaking from the fronts. Not hugely loud, but enough for me to be upset about.
Did I do something wrong? They were fine until the bedding-in run. Maybe the temperature (20s) played a role? I didn't think I went too nuts on them. I'm hoping I don't hear the squeak tomorrow. What about the persistent click I hear when braking for the first time in reverse? Could this be related the excessive dust with the PBR Deluxes?
Passat (B5) :: After New Brake Pads Rough Ride?
Background: I had new rear brake pads/shoes installed today. The dealership installed them, and let me know that the front wheels still have another 10,000 miles before they'll need new pads. I have 55,000 miles on my Passat. Back in August, I put new Nokian tires on.
So, when I took my car from the dealership, after they installed the brake pads, I went on the highway, and my ride felt different. It was a rumbly roughness, but it was subtle. I am not even sure if I am imagining it, but I don't think I am.
I checked the air pressure of the tires, and it's fine. The invoice from the dealership said "replace rear pads/shoes, service drums/rotors and check wheel cylinders". I do not know how any of that could make my ride have this slight roughness to it.
Passat (B6) :: Rear Brake Pads Wearing Too Quickly
My car has about 37k on it; and while the front pads look to be about 50% worn; the rears look like they are closer to 90%. Is this normal? The car is also sluggish while braking especially when the engine is being auto-revved to keep the system voltage up (a known problem). It also seems that the car will step into ABS lock-up mode too soon in a panic stop situation; which might also indicate that the brake system is biasing too much power to the rears; too little to the fronts.
I've never had a car wear the rear brakes more rapidly than the fronts; usually the rears are much more lightly utilized to reduce the tendency to skid. Is there any way to adjust brake bias? I'm getting ready to change rear pads and flush brake fluid.
Passat (B7) :: Rear Brake Pads And Rotors Went Shot
So my car has 36 or so thousands miles and well the rear brake pads and rotors were SHOT! The rear rotor was falling apart and huge chunks were coming off. The issue stands now that I can't spread the rear caliper for anything, the ebrake is off too. I tried to use the C-Clamp trick but it honestly didn't even budge. I also opened up the bleeder and master cylinders cap just to cross that off the list when trying to compress. This is the hardest caliper I've ever had the misfortune of dealing with and I fear that the passenger side is not going to be any better. Aside from spending more money or renting the "tool" is there anything else to check because the C-Clamp trick has work on mine and my father trucks calipers.
View 3 RepliesPassat (B5) :: (2003 1.8T) Rear Brake Pads Wearing Out
What's with the rear brake pads wearing out before the front brake pads. Took my '03 Passat in last week to the dealer for the recall and the service dept. guy said my brake pads were worn out. I took the car to my local mechanic who specializes in VW's. Sure enough, rears were almost gone but fronts still had plenty of meat left on them. Of course I had him replace the rears. But I always thought the fronts wore out first. Could this anomaly be due to ABS?
View 11 RepliesPassat (B5) :: 1999 - ABS And Brake Light After Replacement Of Pads And Rotors?
OK, I just got back from having pads and rotors install on my '99 Passat. I was expecting this to clear up the brake and abs light problem but it did not. The brakes still feel mushy and the ABS light still comes on.What should I check? In the brake forum people suggested bleading the brakes, is this the next step? Any quick how to?
View 3 RepliesPassat (B6) :: 2006 - Replaced New Pads But Brake Fault Light Came On?
Put new pads on by 2006 Passat tonight. Disconnected the battery removed the calipers and used a 12 volt battery to retract the pbrake then pushed back the pistons. Buttoned everything up but when I started the car had the park brake fault light and car is now in limp mode (3rd gear only with harsh engagements.
Disconnected the battery again and will let it sit.
Passat (B5) :: Noisy Brake Pads - Moaning Sound When Brakes Applied
Back in April when I was getting my car inspected the mechanic told me I needed new rear brake pads. I knew I did so I let him change them.
Now I get noisy brake pads this moaning sound out of them when I apply the brakes while I'm backing out of a parking spot or my driveway. I've only driven about 5 or 6 hundred miles since then.
Passat (B5) :: Yellow (Front Brake Pads Worn) Light Turning On Then Off
I have about 50,000 miles on my pads, they look 50% gone, but couple days ago I've got short "beep" and light yellow came on(circle with several small parts of larger circle). What and why? Rotors, pads, other?
View 4 RepliesPrius (2004-09) :: 3 Brake Dash Warning Lights Came On After Got New Brake Pads / Rotors
i have the brake (!) the ABS and the VSC lit up after i got new bearings and new brake pads and rotors, the car was also stalling before the mechanic removed these bearing "dust cover" circles that must have been causing speed sensor interfernce bc the spedometer was stuck on 0....so the car seems to be done stalling after those were removed and all the big lights went off then i hit the brakes a few miles later and those three lights came on...
View 2 RepliesLexus IS 2014+ :: Front Brake Pads Touching The Rotors / E-Brake Engaged And In Park
I noticed the front brake pads were touching the rotors when I was painting the brake calipers. I had my e-brake engaged and in park. I'm assuming the e-brake only brakes the rear wheels because the front rotors were still movable. Although the car still rides fine but I'm not sure if this is normal.
View 1 RepliesPassat (B5) :: Brake-related Rattle Occurs On Rough Road Surfaces?
I have an annoying rattle the occurs on rough road surfaces. It comes from the front right wheel area but goes away instantly with light brake pedal pressure. Three trips to the shop have not identified the problem. I just read somewhere that there are "anti-rattle clips" or springs on the brake calipers. Is this right and are these the same as the retaining springs/clips that can be seen from the outside through the slots in the alloys wheels?
View 5 RepliesSebring - Chrysler :: Rear Window Defroster Tab Comes Unglued
I've a got a 2006 sebring convertible. I replaced the rear window defrost tab 2 years ago & it has come un-stuck again. The dealership has tried adhering it 3X and after the 24 hour cure time, as soon as I turn on the defroster, the tab comes off the window. Dealership is telling me to replace the ENTIRE rear window!
View 5 RepliesPassat (B5) :: Driver Side Wheel Shakes And Rattle Noise When Slightly Apply The Brake
Ok everyone the good weather is back, so the drivers side window is down and, I am back to diagnosing an issue that I've been having for some time now. BTW were dealing with my DD 02 1.8t wagon. So all the time over any little bumps in the road or anything that i roll over that "shakes" the drivers side wheel I get this terrible rattle noise. I mean it sounds like I am a dump truck bombing down the road with a bunch of shovels in it......well not that extreme but that sort of shake noise. Anyway the noise however does not occur over any bumps when i even just slightly apply the brake. So I know that it has got to have something to do with the brake rotor or caliper or something on that wheel. Any common issues with brakes? I mean i doubt it is hurting the performance of the vehicle but it is extremely annoying and i feel like something isn't stable that should be until i apply my brakes.
View 11 RepliesGTI 337/20th Anniversary :: Rattle That Sounds Like A Shield In Low Revs
On my gti when in low revs, theres a rattle that sounds like a shield but I've check the one around that cat and the one under the turbo. but it still rattles. What this could be?
View 3 RepliesGolf IV R32 :: Bouncing Steering Wheel Sounds Like Rattle?
During low speeds when I hit rough payment my steering wheel feels a little more bouncy than usual. Also I am hearing what sounds like a rattle in the front of the car. The steering feels tight otherwise.
View 1 Replies