Ford 6.0L Power Stroke Diesel :: 2003 - No Boost While Going Uphill?
i have an 03 F350 6.0 turbo diesel. Problem im having is a boost problem. on the passenger side, the intake tube keeps popping off the turbo. The Boot ripped on me on a hill so i replaced it with one from the junkyard seeing that it costs so much new. Anywho when i changed the intake tube i did clean it with brake cleaner to clean it and wipe it off. After i did i went for a ride and it just popped off at about 2500 rpm. So i went back thinking maybe i had too many bruskies and recleaned and tightened the clamps on the boot again. Get going down the road going normal again. I gave it a heavy foot to about 3200 and let off it made a sound like fluttering then as soon as i hit it again it blew off. looked at some other forums that said to put hairspray on the boot to seal it. haven't drove it yet just looking for other peoples solutions.
View 8 RepliesFord 7.3L Power Stroke (1999-2003) :: Intermittent 0 Boost After Short Drive
I guess it would be classified as very intermittent but in the past year I have had 3 separate times when my truck has after a short drive suddenly had zero boost..
Pull over and turn it off for 30 sec or so and all is fine. Cycle the ignition faster than that and issue persisted. It has only happened in colder temps. In all the reading I have done on FTE I've not come across anything similar.
Passat (B7) :: 2013 - Transmission Malfunction / Power Loss Driving Uphill?
Occasionally my 2013 tdi has weird transmission issues. Usually it is from a start from a stop sign, typically when I am driving uphill. What happens is I step on the gas and it takes maybe 3-5 full seconds to respond and actually start moving. It is a total loss of power. What could be happening? I took it to the dealer and they said they "tuned the transmission" or something that I don't really buy because I still have the issue occasionally. I had this issue from day one and now have about 25k miles on the car.
View 6 RepliesPassat (B5) :: 1999 1.8T - No Power But Has No Codes And Makes Boost
I'm fighting with my latest purchase, a '99 Passat 1.8T AEB with the Tiptronic trans. I'll just get right into it. The car has been gutless since the first time I drove it, thinking it was the DV, I talked the seller down on price and took the car home. It wasn't the DV... so I checked all the basic things I could to try and find an issue. This included checking for vacuum leaks (only found one, fixed it), fuel pressure (50psi at idle with hose connected and 58psi disconnected), boost (5-7psi with wastegate accuator connected, but only spikes to 10psi between shifts with it disconnected), and compression test (180psi for all cylinders). None of the tests pointed anywhere, but the spark plugs did show signs of a lean mixture (white and chalky).
With the basics out of the way I bought an ebay VAG-COM cable and VCDS-Lite from Ross-Tech. After setting up the VCDS-Lite software I began with a MAF test, which showed a high of 96g/s, lower than the expected 120g/s. I grabbed a different MAF sensor and tried it, but the results were almost identical. Then I looked at throttle angle, this was 86.8 degrees at WOT, which seems to be average for AEB engines. However, at mechanical WOT VCDS-Lite says that it is only at "Part Throttle". I'm thinking this is just an inconsistency with the software, but I don't know. The last thing I checked was fuel trims, but they were slow to respond, only showing 0.0% for most of the drive and eventually changing to 0.8%. From what I've read this seemed normal.
Any other tests I can try? I'm leaning towards the MAF sensor being the culprit, but I swapped it with a used one and saw no change. Maybe both were bad? Can the throttle position sensor cause this? I read an older thread where the angle sensor said WOT but not the position sensor.
Passat (B7) :: 2013 - Found Code P0299 For Turbo Power Under Boost
Sudden power loss experienced. CEL (Check Engine Light came on) and Glow Plug Light was flashing. Power loss is severe so really can't drive it anywhere. Turbo Failed at 5500 miles.
Mechanic quote: "Found code P0299 for turbo power under boost. Removed upper engine cover and intake hose. Checked turbo shaft and found play near intake side of turbo. Removed lower engine shield and lower hose to intercooler. Checked for metal. Contacted VW and created VTA. Instructed by VW to replace turbo. Did."
Sounds like service manager abbreviated when entering into the computer. In any case a shame that this car was in the shop for more than a week while the dilly dallied and waited for a turbo to be shipped in.
Some earlier turbo-fail threads from last summer stated dealer told them "bad batch" of turbos was being experienced by VW. Believable, particularly if they're banged out in China? Let's all hope it was a bad batch.
Golf IV R32 :: Noise From Front End When Drive Straight Or Uphill
So I've recently noticed a noise from the front end. It sounds like a plastic to metal, or metal to metal. It's more of a clicking. It's not sequential, and I can not purposely make it happen. It happens when I drive straight, up hills, and sometimes in turns. It does not happen, when I hit bumps, get on the throttle, or brake. The car doesn't seem sluggish, nor does it feel untidy in the corners. I think it's suspension, but that would make a difference in the ride quality.
I've looked at my coilovers, everything is tight. I recently replaced my sway bar links, but everything is tight and the sway bar isn't loose. I removed my spacers, changed wheels, and the car still makes this noise.
It kind of sounds like something is hitting the firewall, or something is hitting the subframe. I didn't notice this before I did any work to the car. I changed the oil, trans fluid, rear diff fluid, and haldex filter and fluid. I don't think this has anything to do with my noise though. I do have a little shake at idle, kinda like the exhaust is hitting the subframe. That goes away when I'm driving, and is a different noise.
now that I think about it more, it just sounds like something is loose and making contact. Like a loose spring, or sway bar bracket. The problem is I've checked those and they aren't loose, with the car up, and the car down(on a lift) Nothing appears to be loose, and I'm not sure what to check from here.
Toyota - Camry :: 1999 - Sputtering When At A Stop And Also As Drive Uphill
This morning I was at a stop light and my car started to sputter and as I accelerated it drove just fine. Then it happened again at another stop and also while going uphill it sputtered and bogged down. Could it be a bad fuel pump? Or maybe I need a tune up?
View 17 RepliesFord - Taurus :: 2003 - Sputters In Drive When Taking Off And It Barely Goes Uphill
My mother has a 2003 Ford Taurus. I really hate this car, but she wants it fixed. It sputters in drive when your taking off and it barely goes up hills. There is no sputter in idle or park. I put on new fuel filter and spark plugs on it and cleaned the idle air control. What should I try next?
View 19 RepliesFord - Explorer :: 1999 - Transmission Slipping When Shifted From Park Into Drive And Going Uphill
I have a problem with my transmission slipping. It seems to happen most often when I have shifted from park into drive and am going uphill. I don't really notice a problem with it when I am on flats or even at red lights. It can drift backwards for 10-15 feet before "catching."
I don't feel any problem when I am going faster or in higher gears. 1999 Ford Explorer SOHC 6 Cyl 4.0...
Ford Transmission :: Over Drive Light Started Flashing And Truck Got Jerky Going Uphill - 4r70w Went Out
One day I was driving my truck 96 f150 4x4 Eddie Bauer edition and the over drive light started flashing and the truck got jerky going up hills. I got home and hooked my code reader up and (p0708) it said transmission range sensor. I replaced that the next day and drove it around town for about 30 minutes and parked it all seemed to good. But the very next day I started down the road and the transmission was slipping very bad after I turned around after a few hundred feet I barley made it back to my house. I checked my transmission fluid it's full and doesn't smell burnt or anything, I double checked the alignment on the neutral safety switch I just installed and it still in line. So I'm thinking my transmission is going out...
View 4 RepliesPassat (B6) :: Rough Idle When In Drive / Slight Loss Of Power With Horrible Gas Mileage
My 07 2.0T (101k mi.) Passat idles roughly when in the drive position (at a stop light, or sign, etc.), the engine sounds "gruffy", and suffers from a slight loss of power with horrible gas milage. I've had spark plugs and the coil pack replaced two weeks ago, and still can't seem to find the source. There are no misfire codes or any others showing up. From reading many posts here, I've found that a common issue is carbon build up for similar symptoms of my car. Do I need fuel injector cleaner, and or valve stem cleaner, etc? As far as the possibility of cleaning out the intake valve, I only open the hood to add oil, washer fluid, check my oil, and wipe down the engine.
View 5 RepliesPassat (B5) :: How To Switch Gear When Going Uphill
This weekend I'm heading to a friend's house up on the hill. The road on the way to his house is steep. I've never learned how to use the 1,2 gear other than Drive. Should I slow down(let go of gas pedal) before switching to 1 or 2? Or brake completely then switch gear? I really don't know. I don't even know the difference between 1 and 2.
View 1 RepliesFord 7.3L Power Stroke (1999-2003) :: Lack Of Power Going Uphill - Struggling And Lugging
Long story short, when going up hill or any incline for the matter it feels like it's struggling and lugging, blowing carbon everywhere. It's an automatic so I yeah can downshift sometimes but even turning overdrive off doesn't work in a lot situations. My EGTs are way too high and I'm not about to tow my project car to OKC unless I get this figured out. I live around Salt Lake City so towing can be hard up surrounding passes. Just cruising to park city at 70mph on I80 up a pretty good incline my EGTs were 1,000. Just driving around the city, some hills I see 700-800 when I'm going 35mph.
At stop lights I'm seeing 400 at idle. My probe on the pyro is going bad starting to flutter but even if I fix that I'm still having issues up hills. Boost is good, up-pipes don't appear to be leaking but fuel pressure is a little low @56 and I know it's not the fpr because I just messed with that yesterday, put a new poppet and oring in, I haven't checked the fuel pump yet or dropped the tank either. If it is in fact fuel pressure related, does it make sense for me to see smoke coming out, wouldn't that indicate too much fuel? I'm lost, it's driving unloaded like I'm pulling an anchor.
Regardless of which spring I put in the frx I get 56psi, even with the black one I may see 58psi but even with 58psi it was still lugging it's butt off up hills and making that terrible drone sound like F you down shift me now.
Passat (B5) :: Won't Boost Beyond 2 PSI?
I've been experiencing this problem since I had the car but it gets me around fine and has been getting 30mpg; hasnt bothered me all that much but i'd really like to get the problem solved... A few months ago I hooked up a boost gauge and she would not boost beyond 2psi. Since then I've changed the air filter, spark plugs and found a wire that was un-plugged causing the engine light to stay on. Hooked up a scanner and no more codes.. But the car still doesnt pull the way I'd think it should and with a stop watch hits 60 in no less than 9 seconds (shouldn't it be around 8?). The WG actuator rod is free, but I disconnected that electronic control solonoid, drove the car hard and there was no change in performance or driveability! One thing I havent done is change the fuel filter so I'm thinking maybe it's in a limp mode and awaiting the fuel filter to be changed? But then wouldnt a code come on if this is the case?
View 9 RepliesFord 7.3L Power Stroke (1999-2003) :: High Pitched Squealing / Scraping Sound - Loss Of Power Towing Uphill
Towing a 5th wheel at about 10,000 lbs total. Towards the end of out 9 hour trip home and going upgrade the truck begins to loos power and the engine starts making some bad sounds. Although its hard to hear it starts about 45 seconds in and continues later when going uphill. the truck also made a very high pitched squealing/scraping sound (not a belt) like it may have been coming from the turbo. Oil temp was about 220, trans temp at 170 at the time of the event.
Truck has 216k, stock, upgraded trans cooler, original fuel pump.
Here is the video : YouTube.....
Passat (B5) :: Car Seems Surging On And Off Boost After Got Hit
[URL]...........................................................
My wife hit a deer going 60MPH 3 hours from home. Go back up and pick up the car, it's down on power, I feel it surging on and off boost, hard to drive smooth. Roughly a half hour later I get a CEL. Don't have the code handy, but Boost limit Maximum exceeded. My local VW dealer says its a normal wear and tear item so Allstate will not cover it. The car had the radiator, radiator support, condenser, hood, bumper, grill, passenger fender, timing belt cover and timing belt replaced.
Allstate says not covered, like a flat tire, once I leave the shop, its like a flat tire on the road, nothing to do with the repair. BTW I had it repaired at an Allstate recommended PRO shop. I get it back tonight after 8 weeks of fooling around. Will need to check the actuator, hopefully it's bad. The turbo itself is good, boost fine, no smoke.
This is an 04 Passat 1.8T. I have had 14 cars with turbos, still have four and have never had a turbo go bad, full synthetic oil every 3K and 60 second cool down in hot weather.
Passat (B6) :: Less Boost In Tip Mode?
Is there any difference in boost between drive and manually shifting with a tiptronic? How about using sport mode?
I saw a video of a guy testing hist mkv with apr stage two and he reported that he was not getting full boost when manually shifting his dsg.
Passat (B5) :: Not Making Boost - CEL Is On
Just got the car not to long ago and its not making any boost right now. the CEL is on and its throwing a code for a MAF sensor. what would be your first step to resolving this problem.
View 4 RepliesFord 6.0L Power Stroke Diesel :: 2006 F350 - Clunking When Go From Drive To Reverse And Now With Drive Too
So I have a 06 350 and I'm getting clunking from drive to reverse and now with drive too, I know my rear diff is on it's last days but I am wondering if that could cause the clunking and now my truck around 90km shakes likes crazy and same thing wana know if that's the diff. And if I was to fix diff myself would it not just be easier for me to just swap axles if I wanted to be cheap??
View 12 Replies