Ford 7.3L Power Stroke (1999-2003) :: Fast Steady Leak From The Fuel Rail Outlet Fitting While Running
I had just replaced my the fuel pressure regulator in the fuel bowl because it appeared to be leaking from where the FPR is, now with the new FPR , it is no longer leaking from there but now leaking (fast steady leak while running) from the fuel rail outlet fitting... How do you replace these, why all of the sudden it started leaking there ???
View 9 RepliesFord Fuel System :: Small Leak Where Filler Neck Ties Into Rubber Hose That Runs Into Fuel Tank
I recently purchased a used 1999 F250 Super Duty with about 150k miles on it. The truck runs great and I have no complaints but there are a few things that need to be taken care of. It looks like there is a very small fuel leak where the filler neck ties into the rubber hose that runs into the fuel tank. There is a thin film of diesel along the side of the tank, on the leaf spring, the air bag and various other places. Nothing is dripping. I want to drop the tank and replace the hose. The Haynes manual says to depressurize the whole fuel system--is this really necessary if I don't plan on doing anything to the system aside from dropping the tank?
View 2 RepliesFord 6.7L Power Stroke Diesel :: 2015 - Rubber Air Inlet Into DEF Tank?
I was filling my DEF tank (2015 Super Duty 6.7) with 2.5 gal jug a few weeks ago and while I was filling it, the small black rubber air inlet on the container that allows air into the container while filling my truck got sucked into the container and then straight down into my DEF tank before I had a chance to stop the flow. Is there a screen in the DEF fill hose to catch foreign objects like is in the gas/diesel fill hoses?
View 6 RepliesPhaeton :: Fuel Leak Coming From Rear Right Side Of Tank
I have a gas leak coming from the r/s rear of the tank. The exposed fuel lines all look good. It seems to be dripping down from the top but I can't see anything unless I drop the tank down. I ran the smoke tester but don't see anything comming out. Could I have overfilled the tank??
View 6 RepliesFord Fuel System :: Rear Tank Leak - No Power
I have the dual tank setup & this is my problem.
Last year I replaced both tanks - the front was leaking bad and rear was starting to leak. After replacing both tanks, the rear tank (which I was using before) was unusable - it would idle fine and when applying throttle would stall out. The front tank's gauge did not work.
This week I pulled both tanks. Had new gauge assembly put on front pump unit. Also had the rear pump replaced with a new (rebuilt?) one. Installed both tonight. Now the front tank is running fine with a gas gauge. I Filled up the rear and once I had about 16 gallons in, fuel started leaking from the front top of the tank it looks like (where in-tank pump is). This leak has continued as the truck was turned off too. I think it may have stopped now, but its dark and I am parked on a hill. As another problem, I still have the same "stalling" problem. The rear will idle fine, but start to stall out when a load has been applied.
So to summarize:
- What is causing it to want to & stall out?
- Why am I leaking gas?
It seems to stop dripping gas after (maybe) the pressure is lower from leaking the gas out. Also, when 1st starting it up on the front tank, it wants to stall out...probably from the gas that leaked out while it was shut off? The truck will run for about 1/20th of a mile on the rear tank when initially starting it up before showing signs of stalling.
Accord :: Fuel Tank Has Some Leak - Removing Freezing Bolts On Exhaust Pipe?
The exhaust pipe connecting the cat and muffler is broken. However, the bolts connecting them are so rusted that look like one piece. Any tips on removing them off? I am afraid that PB blaster won't work in this case. I am thinking of drill them through, but afraid of damaging the cat.
BTW, my car's fuel tank has some leak. I can smell the gas. Is it safe to use a torch to remove freezing bolts?
Subaru - Legacy :: 1997 - Fuel Leak Detectable On The Garage Floor Under Gas Tank
I have a small fuel leak (97 Legacy Brighton wagon). The leak is detectable on the garage floor under the gas tank although I'm not certain that the gas tank itself is actually leaking.
View 3 RepliesFord 6.7L Power Stroke Diesel :: Slight Leak From Titan Fuel Tank
I've had the Titan fuel tank installed for about a month now and am loving the extra range, although this morning I walked by the truck and got a slight whiff of diesel by the fuel filler door. I pulled out the flashlight to take a look, and noticed a really small, faint trail of diesel fuel running down the driver's side of the tank near the rear strap.
I crawled under the truck to inspect it as best as I could in the driveway, feeling around the sender, filler, and vent tube connections, and didn't notice any obvious puddles of diesel. About the most I got was some dampness around the sender unit seal, but it wasn't much, and could even be residue from the fuel lines dripping during installation of the tank. Based on where the trail down the side of the tank has formed, my best guess is it's going to be a filler or vent tube hose clamp that I didn't get tight enough.
Unfortunately I just filled the tank up last night and am headed out camping for the weekend this morning. I followed all the install instructions exactly, making sure to check the torque on the sender unit seal four times before installing the tank back in the truck because I didn't want to deal with any leaks, so I really hope it's not that seal. I also filled the tank up to the brim right after install and crawled all around it a day or so later and noticed no dampness or leaks. Needless to say, I'm not looking forward to dropping the tank again and then potentially waiting on parts if something is defective. I'm waiting on a call back from Titan to get their advice.
Below are a couple pics of the weepage. Obviously not a huge leak, but something I want to get taken care of ASAP.
Ford - Fusion :: Check Fuel Inlet Light Went On
The check fuel inlet light went on. Should we be concerned? What does this mean?
View 9 RepliesPassat (B5) :: 2004 - Gas Leak When Filling 3 /4 Tank
The leak only happens when filled more than 3/4 of a tank. It appears that the leak is coming from a hose or hose fitting to the right of the opening on top of the tank,under the driver's side rear seat. So far I have only been able to drop the tank about 2 inches.
View 3 RepliesFord Super Duty (1999-2016) :: 2003 F250 V10 - Fuel Smell / Gas Tank Vent Leak
New to me 2003 F250 Super Cab 6.8 V10. Great condition inside and out. 68,000 miles. Began smelling fuel (gas) a few days after driving it 250 miles from purchase location. Traced leak down to the top of the gas tank. Staining was visible around the rear vent. Applied about 5 psi to the tank and sprayed soap around until I saw bubbles coming from a hairline crack at the rear vent connection. Its where the fitting for the hose comes out of the tank.
My first choice would be to hot weld the crack. I'm not very comfortable with the idea of a heat source near a gas tank. I'm not sure, but the heat from the plastic welder might be hot enough to ignite fumes? Second option is to try some industrial 2 part epoxy (PIG) and seal it with that. Is there pressure inside the tank, and if so how much? Can try this fix with epoxy or JB Weld?
Passat (B6) :: Oil Coming Out Of PCV On Turbo Inlet
Is it bad if there is oil coming out of the valve cover breather going into the turbo inlet? I noticed the sides of the turbo inlet on the top is lightly covered in oil.
View 3 RepliesFord F-150 (2009-2014) :: Message Center Started To Read - Check Fuel / Fill Inlet?
I just got my new 2009 F150 XL yesterday and after 100 miles today the message center has started to read Check Fuel, Fill Inlet.
View 13 RepliesPassat (B6) :: Gas Cap Light Coming On When Tank Is Low On Fuel
The gas cap light comes on when my tank is low on fuel, dealer says it is a small evap. leak. I have an '07...
View 10 RepliesFord Escape / Hybrid :: 2011 - Multiple Codes / Check Fuel Inlet Message When Vehicle First Turned On
I am running into some issues with my 2011 Escape 2.5L. I am pulling a total of 7 codes. Two codes keep repeating, which those are P0455 and P0457. And I am also getting a C1963. Accompanying the engine codes, my HUD is displaying "Check Fuel Inlet" when I first turn the vehicle on.
View 10 RepliesPassat (B7) :: How To Get The Computer To Show Fuel Economy For Full Tank
The computer apparently calculates the fuel economy per trip (or a series of trips if the car is stopped less than 2 hours) but I don't know how to get it to display the fuel economy for the tank full. Normally I'd reset the computer upon refilling but since it calculates per trip it doesn't calculate per tank. Fortunately the fuel gauge seems to be pretty accurate and each mark is approx 1 gal so I can do a quick approximation but I'm used to having the car do the tankful calculation. BTW, I reset on MFA 1, I've never reset on MFA 2 and that doesn't show tankful economy either.
View 3 RepliesPassat (B6) :: Low Fuel Light Came On And Gas Gauge Needle Went To Empty With Tank 3/4 Full
So yesterday I was driving home from work.. I know my tank was 3/4 full. All of a sudden, my low fuel light came on and my gas gauge needle went to empty.
The needle sits at E, but it still says about 20 miles till empty on the MFD. When I left the house this morning, it said 5miles till empty.. by the time I got to work, it said 20. Kinda odd..
I will hook up the vagcom when I get home tonight, any area I should scan for? or just a complete scan? There is no CEL error on the dash though. What I could look at to fix this?
Golf IV / Jetta IV :: Coolant Leak At Outlet Flange / Yellow Color In Overflow Ball?
Bought a used 2000 Jetta, 2.0L AEG engine by the looks of it, 188k miles. Previous owner told me he did a bit of work on it, and acknowledged the coolant leak - have to fill the overflow ball about once a week. He said he recently replaced the timing belt, water pump, and tensioner pulley. Not sure if that has anything to do with it.
From what I can see it seems to be leaking at the outlet flange (see pics of rust).
Would any of this cause the water in the overflow ball to be rusty yellow (see pics)? Should I just go ahead and replace the ball and then the o-ring at the outlet flange?
I'm new to VWs, but am up for a bit of work to make sure it gets to 200k miles (bought the Bentley manual).
Ford 7.3L Power Stroke (1999-2003) :: Persistent Coolant Leak At The Thermostat Outlet
The truck has been a dream for several months and I had a coolant leak at the thermostat outlet. Changed the fitting and thermostat and sealed with lots of blue monkey snot. It's been perfect for a couple months but a week ago it started leaking again. Exactly the same as last time. I cleaned the mating surface of the water pump with a plastic scraper to remove the old sealer and then finished it with fine scotch brite. I looked at several parts breakdowns and none of them showed a gasket.......
View 14 Replies