Ford - Windstar :: 1995 - When A/C Is Turned On Compressor Clutch Doesn't Engage
I have a 1995 Ford Windstar. When I turn on the air conditioning, the compressor clutch does not engage despite having sufficient refrigerant in the system. Jumping current directly to the compressor clutch will engage the clutch, so it's not the clutch. I suspect the relay for the compressor clutch inside the CCRM may be bad, but am not sure how to test it. I have a Haynes repair manual, but how to test this device?
View 12 RepliesMalibu - Chevrolet :: 2000 - Compressor Motor Clutch Is Not Engaging When AC Turned On
I have a 2000 chevy malibu that has not had a/c the past 2 summers. I'm trying to diagnose what the problem could be. When I start the car and then turn on the a/c by pressing the button in the car nothing seems to happen.
When I went to look at the compressor motor I could see that the clutch is not engage and the middle of the compressor is not turning. What to check without taking to a mechanic??
Chevrolet - Lumina :: 1996 - Compressor Clutch Does Not Engage And Fans Do Not Spin When AC Turned On
I am having trouble with my air conditioning system in my 1996 Chevy Lumina. When I turn on the AC, the compressor clutch does not engage and the fans do not spin. I was able to jump the compressor so the clutch engaged, however, the fans still did not spin and the AC was not cold. I then jumped the low pressure cycling switch (near the accumulator), which caused the fans to spin while the compressor was running. However, this still did not produce cold air from the AC and none of the AC lines were cold to the touch. I am starting to think the system is low on Freon, but I do not have gauges to test the pressure.
View 2 RepliesFord 7.3L Power Stroke (1999-2003) :: Compressor Clicking On / Off About Every 5 Seconds - Clutch Smell
On 2500 mile trip, no A/C last 400 miles and we're cooking
Compressor clicking on/off about every 5 secs, clutch smell. Seems to be turning okay.
I brought some tools, including a full socket set.
Can I pull the clutch and remove shims in the campground? Looking for a condensed version of how?
Worst case, how do I replace the clutch- of I can find a dealer with one?
Pulley and clutch fixed, but cycling on and off...adding freon?
Golf IV / Jetta IV :: 2003 GLI - Air Compressor Clutch Will Not Getting Engaged
I have a 2003 2.8 GLI and my compressor clutch will not engaged i provided the clutch with a direct power and ground from the battery and it engaged. i also went to the junk yard and got a couple of Fan Control Module ($4 each) and it still does not engaged.
View 3 RepliesGolf IV / Jetta IV :: AC Clutch / Compressor Relay Location
Golf 2.0 ... Finding the location of the AC Clutch/Compressor relay location. On the TDI its behind the the dash and I looked on mine and it doesn't seem to be the same. I've seen a thread where some said it was under the battery? Where it is and what number will be stamped on it. Another thread said it should be behind the dash and number 385 or 358, I looked and I don't have those numbers back there.
View 2 RepliesGolf IV / Jetta IV :: AC Compressor Clutch Turn On But Does Not Kick Off
I have an issue with my 2003 golf 2.0 ac I've done everything that I cloud thing of to check but I still have this issue so here it is. The air coming out of the vents is warm, compressor Clush turn on but doesn't kick off. I hook up ac gauges and it reads 70 on low side and 155 on high side with an ambient temperature of 80. The system has freon, I check fans and they are on when compressor kicks in all relays and fuses are fine.
View 8 RepliesGolf IV / Jetta IV :: Clutch Not Stay Engaged After New AC Compressor Installed
99 Jetta, installed a new AC compressor a month ago, has been working great, not clutch will engage for a few moments, then turn off for a minute, then engage again. Seems, like there is Freon in there by the gauge on the low side.
View 4 RepliesGolf IV / Jetta IV :: Compressor Clutch Bearing Making Sound
I found out that the bearing in the compressor clutch is the one making my car sound like crap... but I have been looking for it and everywhere I call they only sell the whole compressor that is expensive. I was thinking on get the clutch out and lube the bearing up or something but I don't know if I have to discharge the freon for doing it ... How to remove the AC clutch ?? Its an mk4 btw....
View 4 RepliesGolf IV / Jetta IV :: 2003 - AC Compressor Clutch Won't Engage - Low Voltage?
I got a 2003 GTI 1.8t and the AC air is blowing warm. With the car on, AC on and fans full blast both rad fans turn on but compressor clutch does not engage. Took it to a shop and the mechanic said the system was full of refrigerant but that the compressor was not getting the proper signal and there was an electrical problem.
I check the power at the compressor and it is reading about 7 volts, which is low correct? That should be getting 12-13 volts correct? I also check the pressure switch over by the passenger side and it was getting 13v. What to check next to start ruling out causes? Any quick way to determine whether this is electrical or a compressor issue? I am limited in my abilities as far as electrical work goes.
Golf IV / Jetta IV :: A/C Don't Blow Cold Air - Compressor Clutch Stays On Passenger Side Only
The A/C does not blow cold. The Compressor clutch does kick on and stay on The passenger side fan kicks on only (I think the driver side is toast but i need to test it to confirm) The system has 45psi on the low side
I did not check the high side as I don't have a gauge for it but will get one if I need to test that. So my thoughts are that my expansion valve is toast which is what expands the hot liquid and turns it to cool liquid so the A/C gets cold. I think this because it seems all of the other components work.
Golf/GTI VI :: Clutch Pedal Knocking When AC Turned On
I have a question about an annoying issue that I'm having with the clutch pedal: is it normal for the clutch pedal to knock or vibrate whenever the AC is on? I ask because it only happens when the AC is turned on. The knocking goes away if I fully depress the clutch pedal or only lightly depress it. It seems to only occur in the in-between.
View 2 RepliesGolf/GTI VI :: Clicking When Engaging Clutch
Exactly what the title says.....when its cold out/cold start....engaging the clutch pedal it makes a click sounds up top of engagement?
View 6 RepliesGolf IV / Jetta IV :: When Tried To Pop The Clutch To Start It Went Into Gear But Nothing Turned On
This morning my cars battery was dead and when I tried to pop the clutch to start it it went into gear but nothing turned on. When jump starting the car it turned on I drove it for a little while and was idling when it shut back off (battery was dead again). I came back to the car in a couple minutes, tried to start it and it started right up. I'm not sure what to think of this.
View 4 RepliesGolf IV R32 :: Clicking Noise After Turn Signal Turned Off
So the other day driving to work i was driving my car to work, i put my turn signal on and after i turn it off it still kept doing the clicking noise. At first i thought i was just hearing stuff cause it was early and i was tired, so after work i checked it out again i sure enough it was doing it. It even does it sometimes without even first putting the turn signal on. My buddy and i thought it was a relay or a fuse. Is that right?
View 7 RepliesGolf VI R :: Clutch Clicking While Shifting Between 1st, 2nd And 3rd Gear
Last couple morning here in Michigan we've seen temps in the low to mid 30's. The last two mornings when I shift between 1, 2 & 3 I'm hearing a clicking noise coming from the clutch when engaging the gear. After a few minutes, once it warms up, the clicking goes away.
I am @ stage 1+ W/VWR intake, but I'm not expecting clutch troubles from that.
Golf VI R :: Clutch Clicking / Popping Noise
Black 4 Door '13
37xx miles
Build date 07/12
No engine mods
I have had the clicking/popping clutch noise since I was breaking in the clutch but i thought it would eventually wear off. I have went through all the transmission threads and seen that a lot of people got it fixed having their clutch pedal assembly or master cylinder replaced.
Golf IV R32 :: Clicking Noise During Idle / Goes Away When Press In Clutch
Just replaced my OEM clutch and flywheel with SPEC ones and now I have a weird clicking noise during idle from it. Noise goes away when I press in clutch. My technician says that they are known for this noise. Is that true?
View 6 RepliesGolf/GTI VI :: Clutch Clicking At Initial Travel / Wind Noise From Doors At Highway Speed
So far from reading up here is my list:
1) Water pump.
Its not leaking or making noise at this time.
2) Clutch clicking at initial travel.
Noticed this on the first couple miles.
3) Smelly A/C.
This is ongoing
4) Wind noise from doors at highway speed.
Noticed this also
5) Wastegate rattle
Don't hear any rattle, or I am not narrowing down the sound when it happens.
Anything else I should add?