Ford - F150 :: 2003 - Condensation Inside When Running AC For Long Periods Of Time
My 2003 f150 v6 occassionally leaks a little inside when running the AC for long periods of time. Its only a little bit, and Ive noticed it after several road trips with the AC on the whole time. I am aware of a service bulletin fix on this. Essentially the problem is the two drain holes are horizontal through the firewall so air blows water back in, and the fix is to fit two L shaped hoses to block the wind and allow the water to drain downward in the engine compartment. I have done this months ago and it has largely solved the problem, when the water was more of an issue. My question is, is some condensation to be expected or is something clogged up? From time to time the heater core area makes a faint rhythmic rattling that goes away eventually.
View 2 RepliesFord 7.3L Power Stroke (1999-2003) :: F350 Running Rich / Crank Very Long Time Before It Starts
I recently (in the last few months) have noticed my truck (1999 F350 duallie) seeming to be running very rich … I pull a 32' trailer with it and noticed on the art few trips the front and right side of the trailer covered with diesel fuel spots when I got home …. It also smells very rich when idling…. The last couple times I started it in the mornings it seems to crank a very long time before it starts …it still runs but its got issues evidently … it has these 3 codes :
P1280
P0475
P1670
The 1670 will clear , but the other 2 I can't clear, they are right back every time you turn the key on …
Ford A/C :: Engine Running At High Temps When Idling Or Waiting At A Long Stop Light
I have a 390 FE engine and whenever I am idling or waiting at a long stop light my engine temperature goes from the regular temp of 180 to about 190 to 210. How to keep the temp normal when idling? I have checked my fluids and they all seem to be fine, I don't know why it would be doing this.
View 2 RepliesGolf V R32 :: Crank For A Long Time Then Stalls And Die?
So ive had a starting issue in the R32 for quite some time now. With waterfest approaching and the new S3 going into production that i ordered, it has come time to finally fix it. I have taken in to many dealerships and very talented techs, and no one has any idea. The car seems to crank for a very long time or start right up and then just completely stall and die. The second time i start it, it starts completely fine like nothing ever happened. This only happens when the car sits for a few hours. It has never done it if the car has sit overnight or during the cold months. It has to be warm and sit for a specific amount of time. Its like it catches the car transferring into a cold start but not fully cold yet, if that makes sense. Also i am now noticing a small squeak each time it starts, like a belt. I have replaced the fuel pump/spark plugs/coil packs. Nothing has changed. We thought maybe a stuck injector but were doubtful as its not constant. Im debating a cam position sensor just to see if thats the issue. There is no CEL or any codes.
View 12 RepliesGolf IV / Jetta IV :: Flashing ABS Code For Long Time?
My car has been throwing an ABS code for a long time now and I've finally decided to actually deal with it.
The code is: 00285 - ABS Wheel Speed Sensor Front Right (G45): Electrical Fault in Circuit
After reading that this could be due to a bad sensor, I replaced the front right sensor, but I am still getting the exact same code. I used measuring blocks in VCDS-Lite to check out what was going on with the wheel speeds and found that at speeds less than 20 km/h, the front right sensor reads 0 km/h, while all the others continue to read the proper speed.
Golf/GTI VI :: 2013 - Long Crank Time Before Engine Starts?
I own 2013 Mk6 GTI. I am having to over crank the engine for a period of 8 seconds or so before the car starts, especially after it has been sitting for a few hours. My thought was a faulty check valve in the fuel pump. I have heard that our fuel filter has a built in pressure regulator that may get stuck open for whatever reason and that may also cause a long crank time.
View 9 RepliesLincoln - Ls :: 2003 V8 - Cooling Fan Running High About 90% Of The Time
My Lincoln engine / coolant fan is running high about 90% of the time but the car is not overheating or heating up prior to the fan issue. This is a new situation. I'm trying to avoid a $1200.00 new fan purchase ( it only comes as a one unit option - fan, shroud, motor ).
View 4 RepliesGolf IV / Jetta IV :: 2001 GLS 2.0 Making Creaking Noise When Run For A Long Period Of Time
Currently own a 2001 vw golf gls 2.0 with 223000 kms on it. used specifically as a beater car. Noticed that it has all of a sudden started to make a creaking sound when it has run for a long period of time. Stops when you hit a speed of around 50 kms/hr.
View 1 RepliesGolf IV / Jetta IV :: Radiator Fans And AC Stopped Working At The Same Time
A few days ago I was driving around. I get back in my car and when i turn it on no air blows and the radiator fans aren't working at all. My car hasn't overheated but have stopped driving until I can figure the issue out. I have since replaced the fuse box on top of the battery to no avail. I was thinking that it could possibly be the fan control module but in all the posts I am reading not one says that theirs don't work, they just keep running. So is there something else i should be looking at?
View 1 RepliesGolf IV / Jetta IV :: Both Radiator Fans Run All The Time While Engine On Even When Cold?
Both my radiator fans run all the time, even if the engine is cold. Soon as I fire it up, even if it's 0 degrees, they are running. To be clear, as expected, the fans do not run if the car is off.
Based on these symptoms, what components could be the culprit?
Golf V R32 :: Cooling Fan Running Most Of The Time When Turn On The Engine
I'm at 47000 miles. Out of no where the fan began to run and its been running most of the time when i turn on the engine.
There's no CEL, engine temp gauge is normal at 200. Coolant levels above MIN.
What might be triggering the fans to go on? I'm suspecting it might be coolant thermostat sensor.
Ford - E150 :: 1993 - Cooling Fan Clutch Too Long / Will Hit Radiator?
I need to replace the fan clutch on my 1993 Ford E150 Club Wagon 4.9L Chateau. The original part, YB466 has been replaced. The new ones are all too long and the fan will hit the radiator. The original is 2-3/8" long front to back, including the nut. The replacement ones available are 2-5/8" or longer. I have talked to our local machinist, and he says the new parts cannot be made shorter. The water pump shaft is not long enough to allow shortening. He says look for a shorter water pump.
View 11 RepliesGolf V R32 :: Big Time Burning Smell In Cabin At The End Of High Speed Run?
Big time burning smell in the cabin at the end of a high speed run. smells like belts burning maybe.
There's a stretch i take on the way home sometimes, and i can open up and get up to about 120 easily. did it last week and got a strong burning smell, kinda smells like rubber a bit, but it could be fluids... kinda hard to tell, but absolutely a burning smell. but i wasn't sure if it was me.
Did it again yesterday, car pulls perfectly fine, but the cabin was again filled with a burning smell. no CEL's, no nothing that i can tell. cools down perfectly and everything, no beats skipped. All my maintenance is up to date.
LS / MKZ :: 2002 3.9l LSE Cranks For A Long Time Before Starting
I have a 2002 v8 lse with 92000. When i go to start it after it has been sitting for 20 minutes or more it cranks for a long tome before starting. When it does start it idles fine but has a strong fuel smell. There are no codes and no problems once it starts. However it starts up right away in cold weather. It seems like a flooding issue. The fuel pressure is within range but it does seem to bleed off quicker than most cars i work on when the engine is no longer running..
Unfortunately I don't have the specs on on fuel pressure runoff. I suspect the fuel pressure sensor/regulator. I don't believe it would be an injector due to the fact it never runs rough or misses once started and if it was the pump it wouldn't give off a fuel smell in the exhaust once started.
Golf IV R32 :: High Pitched Whistling Sound When Car Running At Idle
High pitched noise when car is running at idle and when not on the gas. Whenever I accelerate it goes away. Pitch/Loudness seems to be higher with RPM's. Could be coming from front of the car.
Checked so far:
I read some other posts about this and fully disconnected my aftermarket radio. I'm pretty sure it is not a ground loop as no power to HU shouldn't still create the whistle.
What I have:
I have an EIP aftermarket street exhaust. I checked the exhaust to see about the flapper, but I don't believe I have any of the items involved - maybe I'm wrong. After some more reading it sounds like a vacuum leak as it goes away upon acceleration. I need identifying what vacuum hoses are still in place/clamped off with having an aftermarket exhaust.
I do not have a CAI, just a K&N drop in.
Sonata NF (2006-10) :: Long Crank Time (8 - 10 Seconds)
I have a 2006 Sonata GLS with the 3.3L V6 and close to 230,000 miles. A few months ago I noticed that my crank time at starting was longer than typically - it has steadily gotten worse.
Now the crank time is close to 8 - 10 seconds. (Which might not seem like much but trust me, it is).
I suspected that the fuel pump was faulty, however, once started - it runs great.
I put a pressure gauge on the fuel pump outlet and found that it only kicks the pump on when the car is cranking, the fuel pump does not kick on when the key is in the "on" position. Once the vehicle starts, it seems to be drawing fuel.
The pump has all sorts of pressure, I am not worried about that.
I decided to change the Fuel pressure regulator valve thinking that maybe it wasn't holding pressure - That didn't seem to do anything.
Do I need to change the entire Fuel Pump Assembly?
Ford - Taurus :: Run For Long Period Of Time And Then Won't Start
The problem I'm having with this vehicle is that, it will start up just fine most of the time if I just hop in my after and haven't drove it for a while, however after I drive lets say 20 min+ and then decide to turn the car off and go back to turn it on, it just wont, it will turn over and its getting power but it won't follow through to start the engine, took it to a place by my house for 3 days and they said its probably the fuel filter but they couldn't give me a straight answer, what it most likely is? Its a 2001 Ford Taurus...
View 6 RepliesGolf IV / Jetta IV :: VW 1.6 SR (AKL Engine) Rough Running / High Fuel Consumption
Regarding my problem (outline below):
>> Went for a refueling stop, and thereafter proceeded onto the highway
>> Approx. 500m into the drive onto the highway the car started jerking and running rough with an initial puff of smoke (none thereafter)
>> Immediately after this initial jerking/shuddering there was a significant increase in fuel consumption i.e. from a familiar 8.2L/100km to 18L/100km in the cruise
>> We continued driving not knowing what it was (I suspected a spark plug may have stopped working)
>> Pulled up at the gas station to observe what went wrong inside the engine bay - no signs of any leaks, fuel sprays, etc. but only that the engine was shaking
>> I checked the rear of the car while the car was idling and observed a pulsating sound...some light smoke and a fuel-rich egg-like smell
>> Asked around and I was led to think the catalytic converter was ruined, so the next day I had the catalytic converter cut out
>> After removing the catalytic converter the problem persisted...although the engine operated with slightly less flow resistance
Attempt at diagnosing the problem
>> My wife called in a technician from BMW at Canal Walk to come have a look and what errors were flagged
>> The tech ran the diagnostic and no fault codes were indicated, except a few short circuit faults due to my incorrectly placing -ve on +ve when I tried to charge my cars battery with jumper cables
>> He proceeded to ask if we changed the spark plugs, I said yes. He then looked at the oil on the intake manifold and said there could be a torn valve on the intake manifold and that air that is not measured by the air mass flow sensor is entering the engine, which is causing the car to rev hunt (this problem of rev hunting has been with us for a while). The engine also shuts down uncommanded at stops and sometimes between shifting gears with the subsequent loss of power steering (very dangerous!!)
>> We also had the O2 sensor replaced a month before this occurence
The images attached (#1- #3) are marked up to indicate the component I am referring to.
[IMG] FilesImage_1.jpg[/IMG]
[IMG] FilesImage_2.jpg[/IMG]
[IMG] FilesImage_3.jpg[/IMG]
Went to Cape City VW in Cape Town and the part number for that orange thing/diaphragm is 06A 198 205A 'Repair kit for valve'. Is this significant? The car sounds as strange at idle...as if has noisy valves. I can upload (if there is an option) a sound clip of how the car sounds if this assists.
Golf IV / Jetta IV :: 2002 Running At Insanely High RPMs On The Highway
I don't own a VW, but my friend does, and she knows absolutely nothing about cars. She drove me home from a friend's house today, and I noticed her car was sitting at insanely high RPMs, even though we were only going like 60-65. The car was ranging from like 4500-5200rpms the entire way home, and the engine sounded like a lawn mower.
Don't know many details on the exact model of 2002 jetta it is (I'm a subaru guy) but it's an Auto. I was convinced she had it in 3rd the entire way instead of drive. I asked and she said it was in drive, but I was sitting in the back so I couldn't quite tell. Not sure how being in 3rd works on an automatic, but she could still come to a full stop. The car was pretty much constantly sitting at above 3k whenever it wasn't at a full stop though. Like, after letting of the brake at a stop light, and pressing the gas, it'd pretty much immediately flick up to 3k and never go below.
So, not sure if this is normal for these cars, but I thought it'd be worth asking since it would suck for her if this could have been fixed earlier. My subaru sits at 3k when I hit 60, and only hits 4k if I'm going like 80, so I just thought this seemed pretty weird.