Golf IV / Jetta IV :: Radiator Fans And AC Stopped Working At The Same Time
A few days ago I was driving around. I get back in my car and when i turn it on no air blows and the radiator fans aren't working at all. My car hasn't overheated but have stopped driving until I can figure the issue out. I have since replaced the fuse box on top of the battery to no avail. I was thinking that it could possibly be the fan control module but in all the posts I am reading not one says that theirs don't work, they just keep running. So is there something else i should be looking at?
View 1 RepliesPrius (Gen 2) :: 2006 - Radiator Cooling Fans Stopped Working
I own a 2006 Prius with 52k miles on it. Great car BTW. The problem is simple, the radiator cooling fans stopped working on high mode; they run around 25% only even, not removing the heat from the a/c evaporator and the radiator coolant. I checked fuses: OK, checked relays: OK. They spin freely and nothing is blocking the front face of the evaporator. Funny I noticed it when I started hearing the a/c compressor buzzing noise and then I realized the fan noise wasn't there!
View 7 RepliesFord - Flex :: 2009 - Radiator Cooling Fans Won't Working
My wife's 2009 Ford Flex has an intermittent radiator cooling fan issue. It has dual cooling fans and with the AC on, the passenger side fan runs wide open but the driver side fan doesn't run. With the AC off, neither fan runs even though I let the car idle for a long time to try and get it hot enough to allow the fan(s) to turn on. It doesn't matter if the engine is cold or warm, the passenger side fan runs extremely fast when the AC button is pushed. I've checked all connections and applied some dielectric grease to the connections. I also checked the fuses to the fans. Have to buy the entire dual fan assembly?
View 3 RepliesGolf IV / Jetta IV :: Radiator Fans Are Unreliable
As it was such a matter of time, my fans on my 24v gave up during winter, no big deal as it was a pretty cold winter but now that spring is around the corner, I gotta fix this issue. To they change for the same OEM unit that will die in the next 30k miles.
View 3 RepliesGolf IV / Jetta IV :: 2003 GLS AC Inoperative / Cooling Fans Turn On Low
My 03 Golf ac is not working and i am looking for a wiring diagram/ troubleshooting chart. the cooling fans turn on low and I hear the engine surging like the compressor is trying to cycle but it is not.. When I jump the low pressure switch the fans go to high and no power to the compressor. I get a flash of power to the compressor but just a blip every ten seconds. I am trying to check continuity of the ac clutch but having a difficult time getting in there hot. I just bought the car and fixed light body damage on the right front but it was not even bad enough to hurt the washer bottle. Hard to believe the hit caused damage to the ac? AC seems to be charged with about 100 psi static pressure. Why are diagrams so hard to find?
View 2 RepliesGolf IV / Jetta IV :: 2001 - When The Car Is Turned Off The Cooling Fans Stay On
I have a 2001 jetta 1.8 turbo. when I turn the car off the cooling fans stay on and kill my battery. Ive been told it could either be a relay or temp sending unit but i dont know what one to tackle first, also my coolent temp stays way low almost as if the thermostat is stuck open.
View 2 RepliesGolf IV / Jetta IV :: 2001 - Misfire At Idle - No Cooling Fans?
I have a problem I can't seem to figure out. My car has a misfire at idle. It has stumbled every once in a while at idle before while at Red lights. Now it does it all the time. Check engine light is on and I got 5 codes. P0300, p0301, p0302, p0303, p0340, and p0012. The last two are for cam position sensor. I took it outo and looked at it. Looks fine. I reinstalled it and hand cranked the motor with a meter hooked up and I am reading about 10 volts when it senses the metal ring going around. So I think that is good. I sprayed brake cleaner on all the hoses to see if the motor reved to hopefully find a vacuum leak. Nothing. I also noticed today that my cooling fans or my ac don't work. Now I have another issue to deal with. I checked all my plugs and wiring and coils also.
View 1 RepliesGolf IV / Jetta IV :: Smoke Coming From Radiator Fans
I don't understand what is going on I noticed smoke coming from my fans radiator fans and I'm pretty sure that it was motor being fried I've gone to the junkyard and bought a used assembly hooked it up and still nothing could be a possibility that when the motor fried it fried the control module for the fans
View 1 RepliesGolf IV / Jetta IV :: Radiator Fans Making Noise?
Radiator fans making tons of noise on my newly purchased gli jetta...
View 3 RepliesGolf IV / Jetta IV :: GTI VR6 Fans On Radiator Don't Turn On / Engine Gets Warm
I'm having an issue with my fans on my radiator. They don't turn on when the engine gets warm and the A/C is off. I've replaced the crack pipe, water pump, and belt tensioner. I've replaced the fans not to long ago because the low speed wasn't working. I tested low speed at the fan connector and it wasn't working. After replacing fans I tested and it was working when jumping the pins on the thermo switch connector. I got both low and high speeds to work during that test. I've since replaced the thermo switch to see if it would fix the issue but the fans still won't come on without turning the A/C on. Any other tests I could do or should I just try to get another thermo switch.
View 4 RepliesGolf IV / Jetta IV :: AC Will Not Activate Until Engine Gets Hot Enough That Radiator Fans Turn On
I have an odd problem. My AC will not activate until the engine gets hot enough that the radiator fans turn on. Once they do, the engine RPMs drop, the clutch kicks in, and I get frosty cold air with no problems. I already replaced my FCM and checked all fuses. It worked consistently all last summer and considering the AC is nice and cold once it kicks in, I don't think this is a pressure issue and it was recharged at the beginning of last summer by a good shop.
I changed my coolant flange a few months ago, same temp sensor. Didn't try AC back then as it was cool outside still. Could this have something to do with it? I have proper readout on my dash. Maybe it's the ambient temp sensor?
2.0 Getta GL AEG 230,000 miles.
Golf IV / Jetta IV :: Both Radiator Fans Run All The Time While Engine On Even When Cold?
Both my radiator fans run all the time, even if the engine is cold. Soon as I fire it up, even if it's 0 degrees, they are running. To be clear, as expected, the fans do not run if the car is off.
Based on these symptoms, what components could be the culprit?
Prius (Gen 2) :: Radiator Cooling Fans Running Constantly?
I can usually find what Im looking for with a quick search but I have had no luck with this issue.
View 19 RepliesGolf IV R32 :: Overheating - Radiator Fans On - Cruise Control Stopped Working?
So I noticed my temp gauge was starting to rise when I was on the freeway. I figured my fans were out but I just opened my hood and both fans were spinning. When I turned the car off both fans turned off but the temp gauge was almost into the red.
In the morning I turned on my AC and only the passenger side fan was working.
So I am not really sure what my next diagnostic step should be. The engine was not radiating any heat so I am not sure that it is even actually running that hot. Could it possibly be the temperature gauge? If I got a vagcom would I be able to check the actual temperature from there?
I am also concerned on how to find out if the fans are running at both speeds at the appropriate times.
Not sure if this is related but my cruise control stopped working a few weeks ago also.
Golf IV / Jetta IV :: 2002 - A/C And Both Fans Stopped Working?
So I just got a 2002 1.8t, everything was fine until the fans and ac stopped working. After poking around the forums a bit I changed the following:
1. Fan Control Module. Result: nothing
2. Radiator Cooling Fan Switch Temperature Sensor. Result: nothing.
all fan components have the correct voltage going to them. Fuse 16 for the AC clutch is not blown and has power going to it. The AC compressor has power going to it. The fuses on the battery box have power going to them specifically S180.
My question is what am I missing? is it possible that the fans themselves could be bad? car is not overheating, the after run coolant pump kicks on. But the AC clutch is not spinning nor are the fans. btw AC clutch is not seized up.
Camry :: 2003 Camry 2.4L - Cooling / Radiator Fans Stay On All The Time
My 2003 camry LE 4 cyl cooling/radiator fans stay on all the time. As soon as I turn the ignition key both radiator fan start to spin even though the car is cold and not on. I checked all the relays and fuses. Checked the voltage on the coolant sensor harness with ignition switch on, there is no 5v or the green pin is not grounded. I am clueless where to go next.
View 14 RepliesGTI 337/20th Anniversary :: Engine Cooling Fans Not Working At All
1999.5 golf afp engine cooling fans not working at all. fter run coolant pump also does not seem to be working. fcm changed still no luck fans do work when jumped straight to battery.
View 1 RepliesGrand Prix :: 2000 - Cooling Fans And AC Compressor Not Working
Cooling Fans and a/c compressor not working-2000 Grand Prix. They both work when I jumper them. Replaced coolant temperature sensor, checked fuses and relays -all good. Not sure what to troubleshoot from here.
View 4 RepliesOldsmobile - Alero :: 2001 - Engine Is Getting Hot / Cooling Fans Not Working
My 2001 alero 3400 engine is getting hot again this alero is running with a 2001 impala engine run great for few months, replace radiator, hoses, thermostat and suddenly coolant start leaking in the overflow, fans not working even with ac on, i replace the etc sensor and did not work, the fans turn on when I disconnect the etc sensor so i think the fan motors are ok. I got one pcm module from the salvage yard in case I need to replace it but I read that only the dealer can reprogram the computer system because vin number issues....
View 2 Replies