Golf IV / Jetta IV :: 2000 - Transmission To Mount Bracket Bolts Destroyed Inside Trans Housing?
Long story short, over torqued the top two stretch bolts and destroyed the threads. We helicoil'ed both holes and put the bolts back in. That was about 4 months ago.
Today both bolts snapped not while moving. We dolly'd the car home and bought a replacement bracket, however all three bolts along the bottom that go into the transmission housing broke off inside.
I'm a tad stuck at this point. I could drill and tap new holes over the existing, but i question whether that is a good idea. My other thought was to get 3 of the larger stretch bolts that go in the top, completely drill out the three that are broken and tap the big ones in. This thought would also require drilling the bracket to make the larger bolts fit.
Golf IV / Jetta IV :: Passenger Side Motor Mount Spacer
What hardware I need to install the passenger side motor mount spacer from Euro Image Tuning. Been sitting on it for a while and cant find the hardware that it came with. Would like to install it, but dont remember what it came with..
View 2 RepliesFord Super Duty (1999-2016) :: 2004 - Changing Shift Motor - Transfer Case Stuck Due To Broken Bolt?
I'm in the process of changing my shift motor on my 04 f350. I can't get it off because of a broken bolt. The previous owner must have done this before, and snapped the head and some of the shaft off, so it's basically an alignment pin that's recessed into the hole on the motor. For some reason it's holding the motor on, even though I don't think the hole is threaded. Any way to get it off. I'm thinking that taking a MAP gas torch to the casting on the motor may be my best bet.
View 8 RepliesGolf/GTI VI :: Broken Pedal Light Bracket - Full Dash Replacement To Fix It?
Right above the foot rest on the driver's side is a bracket with a light and some kind of purple connector -- it's attached precariously with one screw on a VERY thin piece of plastic that i inadvertently hit with my foot and broke off. is this going to require some crazy full dash replacement to fix?
When it broke, it was dangling by wires behind my brake pedal, which seems incredibly dangerous. Just wondering how badly I'm going to get hosed on getting this strange lapse of german engineering fixed.
Golf V R32 :: Removing Broken Rear Belly Pan Bolt?
just got back into a .:R 6/18/13 and took it to a nearby jiffy lube to get an oil change not 100% sure if they're responsible or not but i noticed the belly pan was hanging rather low and broke not too long after. ordered a replacement from ecs w/ the 3 M6x20 pan->subframe bolts since they were missing. got under the car today to replace/install new pan and noticed that 2 of the missing bolts were broken in the frame. tried searching but found nothing?
View 4 RepliesCivic - Honda :: Transmission Bracket / Mount Has A Crack
I have a 2005 Honda Civic (2-door) and have been told that the transmission bracket (which I assume means the same as a mount) has a crack. So two questions:
1. What it would cost to replace this bracket/mount?
2. What's the worse that can happen if I don't replace it?
Lexus RX 2010-15 :: Torque Specs For The Caliper Bracket Bolt?
2011 Lexus RX350 ... What are the Torque specs for the caliper bracket bolts (front and rear caliper brackets) a pdf will be great
View 1 RepliesChevrolet - Silverado :: Upper Rear Shock Mount Bracket Has Rusted Off
I have a 1999 Chevy Silverado 1/2 ton 4 wheel drive truck. The upper rear shock mount bracket has rusted off.
View 2 RepliesSubaru - Outback :: 2007 - Bolt From Caliper Bracket Broke While Driving At 60 Mph?
3 weeks after having my brakes replaced. At 60 mph yesterday.
The garage has the car now and is saying it was a freak accident and not something they caused. I call foul to that. It's a 2007 Subaru Outback.
What should I say to them to make sure this gets repaired properly? And what unseen damage should I be looking out for? The wheel run has a groove from where the bolt rubbed. That's all I could see. And I could lift up and wiggle the caliper.
It was only the pad replaced on the front brakes. It was pads and rotors on the back.
Ford Super Duty (1999-2016) :: U-Bolt Bracket On Front Passenger Side Rusted
I have a 99 F250 Super Duty 4x4. The u-bolt bracket on the front passenger side has rusted through and broken in two places. It has broken right at the hole for one of the u-bolts, which then broke the sway bar bracket off (so the sway bar is no longer attached on the passenger side). Also, the track bar bracket has broken off.
Is there a replacement bracket that can be purchased? Or does it need to be fabricated from scrap? The u-bolt bracket, sway bar bracket, and track bar bracket are all one whole piece. It is welded to the axle, so it would need to be cut off. Then the new bracket would need to be welded back on.
Malibu :: 2012 V6 - Engine Mount Bolt Broke Off In Frame
Recently took 2012 Malibu V6 to dealer for warranty water pump replacement. During the repair the bolt holding the "snubber" (engine mount shock damper). To the frame was cross threaded and snapped off in the frame. Dealer contacted GM engineers and was told to replace that section of frame.
They told me that they would have to drop tranny n engine to do it and would have my car for 3 to 4 more weeks. They have already had it for 3 weeks. Anyway it sounds serious and i am concerned for the integrity of my vehicle after having that extensive of tear down and reassembly.
Passat (B5) :: How To Get Passenger Side Engine Mount Bolt To Stop Spinning
So I just replaced my oil pump and i am reassembling my front end and I just cant get my passenger side engine mount bolt to stop spinning so i can get the nut on (the mount underneath the car) , I have no clue how to stop the spinning
View 1 RepliesCorolla / Matrix 2009-13 :: Front Plastic Air Shield Under Head Lights Bracket Broken
Managed to break loose a corner of the plastic air shield under head lights bracket is broken. Does epoxy repair kits will work ok on this.
View 1 RepliesGolf IV / Jetta IV :: MK4 GTI Exhaust Leak Or Possible Bolt Missing
Brief back story, a year ago my timing belt went and had to replace the cylinder head and all associated parts. No problems since then, until now. Recently the check engine has come on, and got the code for an exhaust leak. Can't remember the exact code number, but the leak wasn't causing a lean condition or causing the engine to act weird so I left it until I had to time to find the leak. On the way home today I noticed an exhaust leak that got increasingly worse to the point where at a stop light I'd go to accelerate and it would pull away very sluggishly. Got home, opened the hood and tracked down the exhaust leak to somewhere around the manifold/downpipe/turbo area. I took off my cover and noticed what could be a bolt missing, and upon further inspection a bolt that may be coming loose.
Here's what I'm referring to:
- Missing bolt?
- Loose bolt missing bolt?
- Loose bolt?
Golf IV / Jetta IV :: Front Strut Mount All Sorts Of Crooked?
Was tinkering on my car this morning, and at first noticed one side had a bigger gap than the other. Ok, I really need to change strut mount bushings, no big deal. Then I actually looked closer, and they both have some lean to them, but the drivers side is much more than the other one. Is this normal? I've never noticed any play in control arm bushings or anything. So what could be causing this? I would assume they are meant to sit flat but maybe not?
View 8 RepliesGolf IV / Jetta IV :: Strut Mount Fully Popped Out Of Its Housing
I just installed my brand new coil overs. I went to drop the car from the jack and as it lowered I noticed my strut mount fully popped out of the strut mount housing. I can't even close my hood. Did I do something wrong?
View 1 RepliesGolf IV / Jetta IV :: 1.8t - Oil Leak / Drip Coming From Drain Bolt
So i noticed i am leaking oil, not much but enought that i will have to top it up before the next oil change. The drip comes from the drain bolt, and drips off the bottom of the oil pan right under it. I have replaced the bolt and it still continues to leak. What could be the cause of this?
View 1 RepliesGolf IV / Jetta IV :: Coil Pack Sparking When Try And Remove Hex Bolt
I'm in the middle of replacing my VC gasket and while I was removing one of the hex bolts that holds it in it started sparking like crazy and turned the tip of the hex wrench glowing red. It didn't do this for the first bolt I took out. I also forgot to disconnect the battery before I started, could that have had anything to do with it?
View 6 RepliesGolf IV / Jetta IV :: Steering / Suspension Assembly Bolt Missing
While changing the oil on my car I noticed that a bolt was missing from the steering or suspension assembly (not really sure what its for. I was wondering what it is for and how important it is. I went to the store to get a replacement and found that the threads in the hole have all rusted out so I can't get a new bolt in. Is this something I should definitely fix before driving again or is it not too serious.
Here is link for the pictures: [URL] ....