Golf IV / Jetta IV :: Only One Of Radiator Cooling Fans Working
I have a quick question, I got a 2005 mk4 gli, and when the cooling fans go on, only one works, the other one does not, I checked the fuse and its fine.
View 13 RepliesGolf IV / Jetta IV :: 2001 - When The Car Is Turned Off The Cooling Fans Stay On
I have a 2001 jetta 1.8 turbo. when I turn the car off the cooling fans stay on and kill my battery. Ive been told it could either be a relay or temp sending unit but i dont know what one to tackle first, also my coolent temp stays way low almost as if the thermostat is stuck open.
View 2 RepliesGolf IV / Jetta IV :: 2001 - Misfire At Idle - No Cooling Fans?
I have a problem I can't seem to figure out. My car has a misfire at idle. It has stumbled every once in a while at idle before while at Red lights. Now it does it all the time. Check engine light is on and I got 5 codes. P0300, p0301, p0302, p0303, p0340, and p0012. The last two are for cam position sensor. I took it outo and looked at it. Looks fine. I reinstalled it and hand cranked the motor with a meter hooked up and I am reading about 10 volts when it senses the metal ring going around. So I think that is good. I sprayed brake cleaner on all the hoses to see if the motor reved to hopefully find a vacuum leak. Nothing. I also noticed today that my cooling fans or my ac don't work. Now I have another issue to deal with. I checked all my plugs and wiring and coils also.
View 1 RepliesGolf IV / Jetta IV :: GTI VR6 Fans On Radiator Don't Turn On / Engine Gets Warm
I'm having an issue with my fans on my radiator. They don't turn on when the engine gets warm and the A/C is off. I've replaced the crack pipe, water pump, and belt tensioner. I've replaced the fans not to long ago because the low speed wasn't working. I tested low speed at the fan connector and it wasn't working. After replacing fans I tested and it was working when jumping the pins on the thermo switch connector. I got both low and high speeds to work during that test. I've since replaced the thermo switch to see if it would fix the issue but the fans still won't come on without turning the A/C on. Any other tests I could do or should I just try to get another thermo switch.
View 4 RepliesGolf IV / Jetta IV :: AC Will Not Activate Until Engine Gets Hot Enough That Radiator Fans Turn On
I have an odd problem. My AC will not activate until the engine gets hot enough that the radiator fans turn on. Once they do, the engine RPMs drop, the clutch kicks in, and I get frosty cold air with no problems. I already replaced my FCM and checked all fuses. It worked consistently all last summer and considering the AC is nice and cold once it kicks in, I don't think this is a pressure issue and it was recharged at the beginning of last summer by a good shop.
I changed my coolant flange a few months ago, same temp sensor. Didn't try AC back then as it was cool outside still. Could this have something to do with it? I have proper readout on my dash. Maybe it's the ambient temp sensor?
2.0 Getta GL AEG 230,000 miles.
Camry :: 2004 - Cooling Fans Not Turn On At Any Stage
I have a 2004 Camry that the cooling fans won't turn on at all. I checked one of the cooling fans by running direct power and it worked. I then checked all the fuses relating to fans and A/C. Then checked relays by using the horn relay in Fan 1 and Fan 3, which are both 4 pin. I bought a new relay for Fan 2 as it was a 5 pin and still no change. The fans don't come on at any stage, turning on A/C or letting the car idle to the point of the water boiling from overflow. I'm thinking it's not the sensors as the fans should turn on when the A/C is turned on.
View 3 RepliesFord Aerostar :: Cooling Fans Come On When Engine Gets To Temp But Not When Turn On AC
I have a 2004 freestar that cooling fans come on when engine gets to temp but not when I turn on ac it has 5 relays for the cooling fans and they run in series and a dropping resistor. Ithink someone replaced #2 relay with the wrong one and has caused my problem because they did not know what they were doing...
View 3 RepliesDodge - Caravan - Relay - Fans - Radiators :: 2000 - Cooling Fan Won't Turn On?
I have a 2000 Dodge Grand Caravan that has 195,000 miles. My radiator fan won't turn on and I'm stumped! The issue presented itself with a check engine light and the radiator cooling fan not turning on. The trouble code indicated the cooling fan relay was faulty. In all cases below, I tested the radiator fan by turning on the air conditioning (thus forcing the cooling fans to run) and also for it to come up to a high temperature coming close to the danger zone.
1. Fuse - first tested the fuse and it was OK. Had to start with simple things first.
2. Cooling fan relay - I replaced the relay which has a reputation for failing on the Dodge. Still the fan did not kick in.
3. Cooling fans - tested the cooling fans and the motor was seized. Replaced the cooling fans and tested them by jumping them. The cooling fans still do not turn on. There is no voltage leaving the cooling fan relay and coming into the cooling fan harness.
4. Wiring - tested the wiring between the relay and the fans. They checked out OK (good continuity and resistance check). There is no voltage leaving the cooling fan relay. Now it's getting more complicated... I unplugged the wiring harness from the ECM and tested the wiring between the ECM and the cooling fan relay. A-OK.
5. ECM - it is unclear how to check the ECM for functionality of the cooling fan.
There are 3 wires (supply, ground, and switch wire?) The supply voltage and ground is good, but I don't know what voltage the switch wire should be. I've read that it is pulse width modulated so I can't measure this with a simple voltmeter. I've also read that the switch wire goes to ground thus triggering the relay. I don't know which is correct. Several mechanics I talked to were skeptical that the issue is with the ECM, they knew of very few instances of this being the culprit. I even replaced the new cooling fan relay with another new cooling fan relay on the off chance that the replacement was faulty. Did I miss something in my logic and diagnostics? I've resorted to wiring a switch directly to the cooling fans and toggling them on and off.
Golf IV / Jetta IV :: 2003 - Compressor Does Not Engage, Fans Do Not Come On
Compressor does not engage, and my fans do not come on when I turn on the A/C. They do come on low speed when I jumper pins 1 and 2 on the temp switch plug, but they do not come on high speed when I jumper pins 2 and 3.
I have replaced the FCM with a new one, as well as a guaranteed working used one; neither one changed anything. I assumed right away that it was the fcm because my original one has a hole eaten through it from battery acid.
Compressor clutch ohms out within spec, and it will engage if jumpered.
Golf IV / Jetta IV :: 2003 - Fans Still Running After Shut Off?
I went out to my car this morning and the fans were both running full speed. That's before I even got to it then they carried on doing so when I started the car and still ran after I shut it off. I have stopped them by pulling the 30A battery top fuse for them but what has caused it and how I can fix it? Preferably not too expensively as I am moving house next month typically.
The car is a 2003 1.8t GTI with climatronics ....
Golf IV R32 :: Cooling Fans Not Turning On And A/C Not Cold
The last few times I drove my car, I noticed the A/C didn't feel very cold. I checked today, and noticed that neither cooling fan comes on with the A/C on. My understanding is that both fans should be in LOW mode with the A/C on. Also, after idling for a while and even after doing some spirited driving and pulling over, the fans never turned on.
From what I'm reading, this sounds like it probably is either the fan control module or the fans themselves failed. Is the fact that both fans don't work in either high or low speed point to this being more likely to be a fan control module? Would this show up as a fault code on a VAG-Com scan?
Golf IV / Jetta IV :: Cooling Fan Won't Turn On - Power Loss After Driving For About 20 To 30 Minutes?
I want to start by saying I'm new and don't really fully know how to search vortex, I'm sure there's probably a bunch of things about this. I have an 04.5 gli, my temp gauge reads 190 all of the time but according to vag com I'm running at about 220 some times higher. I've heard my fan kick in once in the year I've owned it. Also I get a decent amount of power loss after driving for about 20 to 30 minutes. Idk if that's related, but just hard wire the fan with a switch? I don't have a lot of money so I'm not really trying to play a guessing game replacing stuff.
View 6 RepliesGolf IV R32 :: Cooling Fans Continue To Run Until Battery Disconnected
After about 3 weeks, I finally get my 04 .:R32 back from the shop after getting a new fuel pump (long story there) and the mechanic mentioned the fans began to run and stay running when the key is turned to the on position and then turned off, key removed etc. I picked the car up tonight and repeated his claim turning the key to the on position and the fans kicked on and stayed on until the battery was disconnected. I am hoping there is an easy fix. What this could be? FCM maybe?
View 20 RepliesGolf IV R32 :: Cooling Fans Cycle On And Then Off Every Three Seconds When Start The Car?
Why recently the fan comes on when I start the car, then a few seconds later it turns off, then a few seconds later it's on regardless of outside temp or engine temp? Is this simply caused by a malfunctioning green coolant temp sensor? What type of electrical Gremlin causes our cooling fans to cycle "on" and then "off" every three seconds?!
View 1 RepliesGolf V R32 :: Cooling Fans To Stay On Constantly During Track Days
I need a way to make my both fans be on constant during track days, I know induction makes a fan kit for the mk4 r32 which works great but the controller in the MK5 is different and the kit don't fit.
View 8 RepliesGolf/GTI VII :: Right Front Turn Signal Is Inoperative
So I was doing the DRL - Dimming on indication mod with the VAGCOM. I used the following steps:
Go to [09] Central Electronics
Go to Security Access and enter 31347
Go to adaptation channels and set the following (they're quite far down the list):
"Leuchte2SL VLB10-Lichtfunktion G 2" to Blinken links active (besides Phasen)
"Leuchte2SL VLB10-Dimmwert GH 2" to 35
"Leuchte2SL VLB10-Dimming Direction GH 2" to minimize
"Leuchte3SL VRB21-Lichtfunktion G 3" to Blinken rechts aktiv (beide Phasen)
"Leuchte3SL VRB21-Dimmwert GH 3" to 35
"Leuchte3SL VRB21-Dimming Direction GH 3" to minimize
Now my right front turn signal is inop. Checked voltage and swapped bulbs left to right. the bulb is good. No sure what I did. Could I have disabled the blinker somehow? Where is the channel for the right front blinker?
Camry :: 2003 Camry 2.4L - Cooling / Radiator Fans Stay On All The Time
My 2003 camry LE 4 cyl cooling/radiator fans stay on all the time. As soon as I turn the ignition key both radiator fan start to spin even though the car is cold and not on. I checked all the relays and fuses. Checked the voltage on the coolant sensor harness with ignition switch on, there is no 5v or the green pin is not grounded. I am clueless where to go next.
View 14 RepliesGolf V R32 :: Fans In Engine Bay Won't Turn Off
The fans in the engine bay wont turn off. As long as the car is on they run. they do turn off when the car is off.
View 10 RepliesGolf IV / Jetta IV :: Radiator Fans Are Unreliable
As it was such a matter of time, my fans on my 24v gave up during winter, no big deal as it was a pretty cold winter but now that spring is around the corner, I gotta fix this issue. To they change for the same OEM unit that will die in the next 30k miles.
View 3 Replies