Passat (B7) :: Evaporative Emission System Leak Detection Pump Sense Circuit Intermittent / Erratic
My 2.5L is throwing a check engine light with only 5000ish miles?!
P2407 - Powertrain - Auxiliary Emission Controls - "Evaporative Emission System Leak Detection Pump Sense Circuit Intermittent/Erratic"
I did a quick google search and apparently it MAY be due to a loose gas filler cap. I tightened it and drove around the block. Still on...
And (from the google search), this code isn't common with VWs.. (in fact, couldn't find a single VW with this code?).
Golf IV R32 :: EVAP Leak Detection Popping All The Time?
I know the EVAP Leak Detection system is supposed to pop and click on start-up, but from what I've read it goes away after a few minutes (after the system pressurizes?) - however I've been noticing my popping still happening after 10-15 minutes of driving (I believe it sometimes even pops when I shut off the car)... I am not getting any warning lights. Is this normal?
View 2 RepliesGolf IV / Jetta IV :: CEL Code For EVAP - Very Small Leak
Got a CEL tonight while driving. Originally I was driving and the light came on saying that my gas cap was loose. I corrected the problem when I got home and tightened again. The light stayed on however. I ran a scan with the OBDII and it gave me a code for EVAP- Very Small Leak .
I was reading around and some people suggested the MAF. Which would make sense because I recently had all of that stuff off and gave the engine a deep cleaning while it was exposed. I just don't see how the MAF could relate to the code my car is pushing?
Golf IV / Jetta IV :: EVAP Code (P0442) Small Leak Detected
so my girls car is throwing an evap code (P0442) small leak detected. I bought a new oem gas cap and replaced the purge valve solenoid under the hood. that didn't work, CEL still comes on about 100mi after clearing the code.
I have checked the rubber hoses that were attached to the purge valve solenoid when i replaced it and they are fresh, no dry rot or cracks that i can see. The hose on one side goes to a hard line that runs under the car to the back, the hose on the other side of the solenoid runs under the intake to the throttle body. That hose was fine as well. Connections were tight and i even put better clamps on the hose ends that attach to the solenoid. So I have ruled out that portion of the system (under the hood).
I also removed the rear seat to access the fuel pump. All those connections seem nice and tight, I don't smell any strong gas fumes indicating a leak so i don't think the fuel pump gasket is the problem either. Finally, i checked out the hard lines running under the car front to back and I see no apparent or obvious damage. I assume my next step is to pull off the rear passenger wheel well liner and asses the charcoal canister and the LDP connections, correct??
The last thing I will mention is, Idid notice the 2 fuel lines that attach to the fuel regulator are in pretty rough shape, however not leaking any fuel. Are both of these lines actual liquid fuel lines? I am thinking one of them is a vapor return which may be part of the EVAP system. If it's dry-rotted and leaking vapors could that be the culprit??
Golf IV / Jetta IV :: Check Engine Light Comes On - Code P0456 For Evap Leak
I have a 2005 1.8 TJetta GLI owned for about 2 months now. Gas cap warning pops up then goes away when I turn off the car then check engine light comes on. I've change the gas cap to new oem one changed the purge valve [URL] .... After a couple of weeks same issues again brought it to my mechanic he ran a leak detector and told me that there are Evap leaks. I read somewhere that I might need a need charcoal canister and a fuel tank.
View 12 RepliesGolf IV / Jetta IV :: Codes For Random Misfire And Small EVAP Leak Detected
Okay, so a few weeks ago, my tire blew out on the freeway. Of course my spare wasn't in there and when I got one I couldn't get the lugs loosened. My 4way was too big on all sides. It was late, I am a single mother of two young kids so I had no choice but to drive slowly to get it off the freeway. The next morning I came back fully prepared, got my car in to get a new tire. I have been driving with ONE code for my CEL, but at the shop (where I use to work) I used the scanner and it threw 5 codes.
P0300 Random misfire
P0442 Small EVAP leak detected (this one was already there)
P0420 Catalyst system below threshold bank 1
P0301 Misfire cyl 1
P0303 Misfire cyl 3
My beautiful love is an 02 Jetta 2.0 4 Cyl. Now, since 4 of these codes popped up AFTER my first blowout (I turn 30 next month, knock on wood)
Did driving my car at 5 mph about a mile and a half (everywhere up until the gas station was NO PARKING) do something to my car? All of a sudden, any in town driving ESP IDLING makes my check engine light blink and my car has no power I just have to pull over wherever I am. I checked the car out myself on the side of the road and my cat was glowing. After this I do not drive my car.
So, what should I do. I did a tune up. Should I replace the 02 sensors then the cat?
Golf IV / Jetta IV :: Fuel Pump Is Supposed To Go Off When Open Driver Side Door
At some point I learned that the fuel pump is supposed to go off when I open the driver side door and after I notice it stopped I took it to a shop shop and they tried to get it to start and had to bang it wit a rubber mallat , after that they told me the pump has failed so I bought a new one (VDO) brand and installed it myself the car felt like it drove better and it made the noise when I open the driver side door in the mornings a couple of weeks after it stopped and I felt my car was back to how it was before , I still get the noise when I turn the key 3/4 of the way and have no issues starting the car coincidentally, I am noticing my car wont lock when I use the keyfob unless I do it manually, is the pump not priming because of the door module has failed too?
View 2 RepliesGolf IV / Jetta IV :: Coolant Leak On Passenger Side - Water Pump?
So my coolant system woes have continued! I recently replaced my thermostat ,thermostat housing, thermostat cover and all of the rings and gaskets. I finally stopped the leak on the driver side which seem to be the thermostat now about seven days later I am experiencing leaking on the passenger side. I walked out from work today and noticed I pool of coolant under the car. I can't tell exactly where it's coming from but it's coming from one of the components that runs off of the large belt. I snapped a few pics from the bottom of the car I don't think this is the actual component that's leaking. I think the leak is just falling off of it . I was wondering where the water pump is located.
View 5 RepliesGolf IV / Jetta IV :: Power Steering Fluid Leak / Pump Is Shot
A few days ago I had a big PS fluid leak. Turned out the return line had been sliced a bit. I had to drive it for a couple days before I could get around to fixing it. The steering is still stiff and the pump whines. Is this an indicator that I need to replace the pump?
View 4 RepliesGolf IV / Jetta IV :: 2004 - Stalling / Dies After Long Trips - Leak In Water Pump
I have a 2.0l Jetta that has been giving me problems for about a year now.
First, the car started dying out on me after long trips at en excessive rate where it would shut off and have trouble starting multiple times consistently. So I got the fuel lines cleaned, a new fuel filter, the fuel pump checked, and did a basic tune up by changing the sparks and oil.
Still the same problem. after some troubleshooting i gave up and decided to take it to the stealer dealer. after a $130 diagnostic fee and a $300 repair fee they told me that they had fixed it by replacing a speed sensor in the transmission. the car was noticeably running better and did not stall during the short driving i did. I am a student so not much driving was done initially. A couple of months later i took a ~150 mile trip and upon stopping at a red light and trying to go once the light turned green the car stalled.
I took it back to the dealer that told me they would check if the speed sensor was faulty. it was not and they could not refund me my money. i paid for another diagnostic for another $130 and this time they said it was a bad coil pack, a $400 repair fee that i was not going to pay. i went out and got myself a coil pack and installed it myself. still the same problem.
I met a guy that worked for the dealer and had the same tech as the dealers so i took the car to him. he had it for 2 days and drove it for over 80 miles to test run it. he could no replicate the problem and just charged me 80 dollars just for his time.
I decided to take matters into my own hands and I read on these forums a couple of common solutions to the problem such as changing cam,crank,speed sensors etc etc and i started out with the crank..then speed...etc etc.
2 days ago my water pump had been leaking and i believe the antifreeze caused the timing belt to slip about 3 teeth in the middle of driving. luckily no bent valves or any damage to the engine but i did have the push the car about half a mile. After a 5 hour job i replaced the pump and the timing belt along with the cam sensor. I drove it around 70 miles and everything seemed fine. just yesterday i drove around 120 miles and the car had a small stall about 50 miles in when i was at a red light. The rest of the trip it ran fine. As i got to my apartments I decided to see if i could replicate the stall since the engine was hot. I stopped and waited around 10 seconds and then stepped on the gas, the car did almost stall but it stayed on since i let go of the gas. I tried it again and it would no longer do it.
Ford Fuel System :: Fuel Pump Circuit Open
Pulled codes awhile ago...got a 96. Says "Fuel Pump Circuit Open"-Battery to ECA (1988 On). What is an ECA maybe the Pump Relay? And does this thing have a fuse for the fuel pump in the panel. Fuel Pumps not getting any juice.
View 1 RepliesGolf VI R :: Code P0456 For EVAP System - Very Small Leak Detected
It all started with a fuel cap loose light (it wasn't) after a day or two the MIL came on and got this code I reset it but I'm sure it'll come back since there's probably a real leak. What can I check myself to find this leak?
View 11 RepliesGolf IV / Jetta IV :: Deleting EVAP System?
I'm trying to delete the EVAP system on my 24v to clean up the bay. I tested the purge valve and it comes up as 25ohms so i was wondering if I could remove it and wire in a resistor to the connector in order to trick the car into thinking that it was still there.
Next question is in the picture listed below, would i be able to cap off # 11 and where the lines go into the intake manifold or would i have to delete the hoses going to #10 and #13 as well?
Golf IV / Jetta IV :: Replaced Evap Box, Heater Doesn't Work
I just replaced my evap box along with most everything connected to it (had some bad servos and replaced other stuff for good measure). AC works great now, but the heater still doesn't work. I've had this car 4 years and the heater has never worked. When I took the box apart, the doors were naked (no foam). Heater core looked ok, but thought it would be stupid not to replace it while I was there.
So, I was hoping this may cure my heater issue, but was really only looking to get the AC going. So, the car had been running for 30-45 minutes and while the heater was on, I went to check the heater core hoses, the pass side hose was hot, the driver's side wasn't. Driver's side goes to axillary pump and bottom of coolant reservoir. Not too long ago, I replaced the mechanical pump and t-stat along with other stuff (crack pipe, etc.). Thought I'd get everything while I had the system drained. Didn't work then, either.
Ford - Explorer :: 1999 - Code P1451 EVAP System Canister Vent Solenoid Circuit Malfunction
I have a 1999 Ford Explorer with the V-6 SOHC that is stuttering and stalling when I try to accelerate. A very slight acceleration will get the vehicle moving, but anything coming close to normal gas pedal pressure causes immediate stuttering and/or stalling. Check Engine light came on when problem started yesterday.
Where is the EVAP System Canister Vent Solenoid? I bought a code reader after beating my head against the truck all afternoon and got code "P1451 EVAP System Canister Vent Solenoid Circuit Malfunction". My Haynes book says on the left side frame rail... can't find anything along there that looks like it (based on picture from Rock Auto for replacement part) and found some people online talking about it being in the engine compartment on the passenger side...
Just crawled all over the truck and I think I found the charcoal canister, but couldn't trace it back to the vent solenoid... There was something right next to the canister, but again, it looked nothing like the replacement part listed on Rock Auto...
Golf IV / Jetta IV :: 2000 VW 2.0L - Code P0102 (MAF Circuit Low)
I keep having the P0102 (MAF Circuit Low) code come up. I've replaced the MAF twice already. I also have the P0113 (Intake Air Temp Sensor) which has been replaced as well. Could the breather hose coming off the Intake Air Duct leading to the oil cooler cause this.
View 1 RepliesFord Wiring/Electrical :: P1451 Code - EVAP Control System Canister Vent Solenoid Circuit Malfunction
I'm not too knowledgeable about wiring and electrical systems. I'm getting a P1451 code (EVAP Control System Canister Vent Solenoid Circuit Malfunction) on my 99 4.2. I've read that it could be a bad solenoid, bad wiring, or a blown fuse. So far I've;
- checked (and changed) the related fuse
- checked the wiring for damage at the connector
- checked voltage at the connector (12 volts)
- checked the resistance at the solenoid (around 60 ohms)
- actuated the solenoid with a 9V battery (can hear it opening and closing)
I haven't had a chance to check the wiring all the way back up the frame to yet, but I noticed that the ground at the trailer wiring harness has broken off the frame. Would this potentially cause a fault in the upstream wiring? I'm going to slap a new connector on and bolt it back down anyway, but as it's Labour (Labor) Day I'll have to wait for the stores to be open tomorrow.
Golf IV / Jetta IV :: 2001 - Code P0102 / Air Temp Sensor Circuit Was Low
2001 jetta 2.0 VW guys a while back I was pulling a code saying that the air temp sensor circuit was low I believe it was P0112 so I replaced the maf with a bwd maf. Said it was for the car. Was fine for a day but now it has a P0102 code and the epc stays on (rough idle) what could be wrong ? Is it because the car hasn't learned the new sensor yet because I've only drove 10km or do I have a faulty sensor. BTW replacing the maf fixed the P0112 code
View 5 RepliesGolf IV / Jetta IV :: CEL Is On For P0116 Engine Coolant Temp Circuit / Range Or Performance
My CEL is on for P0116 Engine Coolant temp circuit, range or performance problem. I replaced the CTS, thermostat, and did a complete coolant flush/replacement last November. Car worked well over the winter no issues. Last week when the CEL came on it gave me P0301 and P0440 as well. I did a reset and the lights stayed off for the week. Then P0116 came back. Is it possible that the CTS is bad again? I measured the resistance on the CTS and hot it is about 300 ohms and cold is 2.45k ohms.
View 8 Replies