Passat (B5) :: Engine Code PO116 - Engine Coolant Temp CKT Range / Performance
I just had my 1998 Passat 1.8T with 97000 miles checked since the engine light came on. It started this afternoon and the car ran just fine. I took it to an Advance Auto and after they plugged in the OBD tool it came back with the code PO 116. Engine Coolant temp CKT Range/Performance.
The fellow decided to clear the code and then the car would not start. I waited for about 15 minutes and the car started with some hesitation and the light was out. When I got home I let the car sit for a few seconds and it started perfectly like nothing ever happened.
Does that mean that the temperature coolant sensor is bad??? I have a Hanes manual and apparently is not too difficult to do. Would I have to partially drain the radiator?
Prius (Gen 2) :: P0A37 And P0A2B - Temperature Sensor Circuit Range / Performance
I have these two codes:
P0A37 - Generator temperature sensor circuit range/performance
P0A2B - Drive motor "A" temperature sensor circuit range/performance
Ford 6.0L Power Stroke Diesel :: Code P0404 - EGR Circuit Range / Performance
I keep getting a problem code of P0404 - EGR Circuit Range/Performance. What it is and if its a serious issue?
View 2 RepliesGolf IV R32 :: Coolant Temp Gauge Go Up When RPM Low And Goes Down When In Higher Range
Lately my engine/coolant temp gauge has been screwing with me. It is either been almost at 190* or dead 90-100*
It seems to go up when in the lower RPM range (idle-2000) and goes down when in the higher range (4000-redline I suppose).
I stayed at or above 4000rpm on my way home from work for 3-4 minutes and it was almost at 90*...went to 5000 for 2 minutes, same thing. I shifted to 6th and it rushes to 190*.
So is my sensor bad or what?
Golf IV / Jetta IV :: CEL On For Code P2181 Coolant System Performance
Like the title states, I've got P2181 (coolant system performance) CEL on again. I've had this code before and finally had everything serviced. It was off for 5k miles! I've spent a lot of time diagnosing this on the previous occurrences, and was 99% certain it was the thermostat due to the coolant temp dropping a notch or so when engine braking* on the interstate for more than a few seconds.
The current issue is mainly that the car will not heat up quite as fast, but it will not go lower from engine braking for a good chunk of time. I'm getting fairly poor MPG compared to what I was getting a month or two ago. The major changes are winter fuel blends and winter tires, which I'm sure affect the MPG a little, but I would hope not as much as I am seeing. Old average was around 27mpg combined and 30 or so for mostly highway, now I'm getting 24 tops. This is likely due to engine temps not being up to allow for most efficient fuel burning.
First plan is to change the CTS and see if that will fix it. If the code comes back after that, I'll have to check the thermostat and coolant mixture, but I wouldn't expect it to last only 5k miles.
Current: 105k
Thermostat and coolant changed at 100k
Water pump at 80k
CTS sometime around 70k
Engine braking lowering temp due to no fuel being ignited and coolant still circulating through the system if thermostat open.
Golf IV / Jetta IV :: 2001 - Engine Overheating - Coolant Temp Sensor Replacement
My temperature has been randomly dropping, them back to middle, and recently my engine was overheating because I'm guessing the fans didn't turn on, because I'm also guessing, the engine didn't know it was overheating?
Anywho, during my replacement, I made sure to get rid of the pressure, and the car was cold. I tightened the cap again, but when I took the sensor out, all the coolant spewed out.
Now if I understand this correctly, do I have a leak? I figured the leak I had was coming from the temp sensor as it is.
Here's some pictures for those who'd like to see ....
Golf IV / Jetta IV :: 2001 - Code P0102 / Air Temp Sensor Circuit Was Low
2001 jetta 2.0 VW guys a while back I was pulling a code saying that the air temp sensor circuit was low I believe it was P0112 so I replaced the maf with a bwd maf. Said it was for the car. Was fine for a day but now it has a P0102 code and the epc stays on (rough idle) what could be wrong ? Is it because the car hasn't learned the new sensor yet because I've only drove 10km or do I have a faulty sensor. BTW replacing the maf fixed the P0112 code
View 5 RepliesGolf IV / Jetta IV :: Coolant Temp Light Came Flashing On - Oil Getting Into Coolant
Okay so recently I was driving my 2000 Jetta and the coolant temp light came flashing on, when I went to check the coolant I was surprised to discover that it was like a mud brown color, almost looks like peanut butter. From everything I have read this can be from a few things, either rust build up that is gunking everything up and oil getting into the coolant somehow. I'm pretty sure its rust build up but I was wondering what everyone thinks about this, I was also not using G12 coolant which I'm told now is the premier brand for VW's.
View 3 RepliesGolf IV / Jetta IV :: 2004 VW 1.8T - Normal Coolant Temp?
I have a 2004 VW Jetta 1.8T , what the normal coolant temperature should be?
View 1 RepliesGolf IV / Jetta IV :: CEL Code For Bad Coolant Temp Sensor?
So my check engine light came on in my 04 jetta sw, and when I had the car read, it gave me a code that tracked down to be a bad coolant temp sensor. I bought the replacement part from my local VW dealership, installed it and the check engine light went away. Now about 2 weeks late it came back on, and I am getting a reading of "Coolant temp sensor high voltage". So it goes from needing replaced, then the replacement is running high voltage?
View 3 RepliesGolf IV / Jetta IV :: Overheated - Coolant Temp Light Came On?
Today was the first time my wagon has stranded me due to a mechanical issue. During city driving my coolant temp light came on so I pulled over to check it out. The fans appeared to be working, the coolant was a fair bit above the normal mark, but I'm not sure the water pump was running. I couldn't feel anything when I squeezed the top radiator hose. This is an '03 with about 50k miles on it.
I'll be taking it in Monday morning so I was curious what people's thoughts were. If it's the water pump is there anything else I should consider getting replaced while I'm at it? I'm still on the original timing belt, a change I've been delaying a long time since I drive so little so it might be time to bite the bullet and do it.
Golf IV / Jetta IV :: Harness Protection Coolant Temp Sensor
I just replaced my CTS, and I noticed that there is a small section of exposed harness wiring between the end of the loom and the CTS connector. I can't tell if it came loose when I swapped the sensor, or if it was this way for awhile, but all of the other harness connections around this area are completely covered and the loom end doesn't seem to clip into the connector or anything. If I were to try and seal it, I would need to use tape.
How hot does this area get? It seems like there shouldn't be exposed wiring here.
Picture taken with the new sensor: [URL] ...
Golf IV / Jetta IV :: 2003 - Code P0118 / Coolant Temp Sensor Replacement?
I recently got the solid check engine light for my 2003 VW Jetta 1.8T GLS. I used a bluetooth OBDII dongle and Torque Pro to pull the code P0118. This seems to coincide with my symptoms:
Car idle at start in park stays around 1100RPM then in reverse it drops to 1000RPM then back into park and it stays around 900RPM and keeps that at idle.
If I start the car then immediately reverse out of my driveway then the car has a very rough idle but if I wait around 5 seconds in park idle then reverse out of my driveway it is smooth.
My car dash thermometer stays pretty close to the bottom low then after about 4-5 minutes it shoots up to 190F and stays. Gas mileage is also very poor.
I looked up a tutorial which shows the parts needed and how to replace the sensor : [URL] .....
I removed the engine cover and believe I found the coolant temp sensor in the spot the tutorial shows. My question is if there is anything I should be aware of before attempting to replace this sensor that this tutorial doesn't cover? I took a screenshot of what I believe is the coolant temp sensor.
Golf IV R32 :: CEL Code For Engine Coolant Temp
Few weeks ago I threw a CEL for an engine coolant temp. It went away and came back now as a P3081, I don't recall that being the code before. But from what I understand It is a simple sensor that I can replace myself. Car is running fine and not overheating.. it did however overheat the last time It threw a CEL but that was also stop and go traffic with AC on.
View 8 RepliesGolf IV / Jetta IV :: Check Engine Light Came On / P0135 Code For Sensor Heater Circuit
I have a 2002 Jetta 1.8t. My check engine light came on and it gave me the code P0135 sensor heater circuit. Bank 1 Sensor 1. We bought a new 02 sensor and replaced it. We definitely bought the right one too. Cleared the codes. After a little driving the CEL came back on with the same code P0135. What is wrong and how I can fix this?
View 6 RepliesGolf IV / Jetta IV :: Overheating / Engine Temp Was Slightly About 190?
So to start off, its 10 degrees here with a -7 degree windchill. With that in mind, I was driving home just now from dropping off a friend, and noticed my engine temp was slightly about 190. Didn't think much of it, but within a mile down the road the temp was crossing the final line before the red 260 degree line. I pulled over and let it get down to 190 (luckily didn't take long) but in the next 3 miles home it rose again, then fell, and then rose again as I drove through my neighborhood. I'm thinking maybe the thermostat is going bad...? There's no way it went from normal operating temp to almost overheating as cold as it is....
View 18 RepliesGolf IV / Jetta IV :: 2013 - Engine Temp Warning Light
Whilst about half way into an 8 hour drive to NYC my engine temp warning light goes off.
Blast the heater and pull over at the next closest rest stop.
No leak to be found. Looks as though the coolant level is okay Burk can't tell since the car hasn't cooled down yet. Engine bay doesn't seem crazy good. No strange smells.
Turn the car off then on and the warning turns off. I let the car cool for 20 min then back on the road. Warning comes on again on the highway.
What it could be? Possibly the thermostat? Could this fix itself?
Golf IV / Jetta IV :: Temp Light Comes On With Keys In - Engine Cold And Not Running
So my temp light comes on in my 2002 gti 1.8t. The light comes on with the engine cold and not running, just keys in. I replaced the temp sender and the fan switch. I already checked the fuses, still good. The only thing i can think of now is the relay. There is plenty of coolant in the system as well. And I am not getting any CEL.
View 5 RepliesGolf IV / Jetta IV :: 2005 - Engine Temp And Fuel Gauge Both Not Working
I have a 2005 mk4 gli and the other morning I went out to start my car for work and all I got was crank no start. I then realized my fuel pump wasn't priming when I opened the driver door. After work I came back and checked the fuel pump fuse and swapped the relay with another I had, still nothing. A buddy of mine came to me and decided to check the connector at the fuel pump for power, using a power probe I believe he hit all or the majority of the wires with 12v of negative and/or positive power. He then unplugged the connector and plugged it back in and the car fired right up. But I noticed that my fuel gauge, engine temp gauge, and outside air temp readout were all not functioning.
View 1 Replies